Advertisement

Dynamics of Mn removal in an acid mine drainage treatment system over 13 years after installation

  • Elizabeth Crafton
  • Casey Pritchard
  • Lin Guo
  • John M. Senko
  • Teresa J. CutrightEmail author
Thematic Issue
Part of the following topical collections:
  1. Environmental Earth Sciences on Water Resources and Hydraulic Engineering

Abstract

Acid mine drainage (AMD) from abandoned and active mines continues to pose a serious threat to the environment. Metal-rich fluids may emerge from abandoned mine works for hundreds of years, so the long-term performance of treatment systems must be evaluated to minimize the environmental impacts of AMD. A two-step process consisting of an aerobic wetland and a limestone bed is being used to treat coal mine-derived AMD in the Huff Run watershed of eastern Ohio, USA, and has been in operation for over 13 years. In 2002, the water was acidic (3.66 pH). From 2004 to 2014, water entering the treatment system had a pH of ~ 5.7 that increased to 7.25 by the time it exited the limestone bed. Since 2004, the effluent Al, Mn, and Fe concentrations have been between 0.05 and 0.12 mg/L, 0.04 and 0.25 mg/L, and 0.05 and 0.34 mg/L, respectively, with the majority of Fe and Al removal occurring in the wetland along with partial Mn removal. Subsequently, further Mn removal occurs as AMD flows through a limestone bed that was inoculated with a consortium of Mn(II)-oxidizing bacteria at the time of construction. An evaluation of historical system performance and current conditions indicate that effective metal removal has been sustained for over 13 years. While Mn(II)-oxidizing bacteria were most abundant in the limestone bed, they were detected throughout the system, indicating that indigenous Mn(II)-oxidizing microorganisms may be contributing to Mn removal well after the inoculation of the system.

Keywords

Passive remediation Coal mine water Mn-oxidizing bacteria Wetland Limestone Drain 

Notes

Acknowledgements

This research was funded by the Ohio Department of Natural Resources (ID 1000002426). The contents do not necessarily reflect the official views or policies of the Ohio Department of Natural Resources. Maps were created using ArcGIS® software by Esri. ArcGIS® and ArcMap™ are the intellectual property of Esri and are used herein under license. Copyright © Esri. All rights reserved. http://www.esri.com.

Supplementary material

12665_2018_8008_MOESM1_ESM.docx (16 kb)
Supplementary material 1 (DOCX 16 KB)
12665_2018_8008_MOESM2_ESM.docx (14 kb)
Supplementary material 2 (DOCX 14 KB)
12665_2018_8008_MOESM3_ESM.docx (15 kb)
Supplementary material 3 (DOCX 15 KB)

References

  1. Aguiar AO, Duarte RA, Ladeira ACQ (2013) The application of MnO2 in the removal of manganese from acid mine water. Water Air Soil Pollut 224:1690–1698CrossRefGoogle Scholar
  2. Akcil A, Koldas S (2006) Acid mine drainage (AMD): causes, treatment and case studies. J Clean Prod 14:1139–1145CrossRefGoogle Scholar
  3. Bai H, Kang Y, Quan H, Han Y, Sun J, Feng Y (2013) Treatment of acid mine drainage by sulfate reducing bacteria with iron in bench scale runs. Bioresour Technol 128:818–822CrossRefGoogle Scholar
  4. Baker BJ, Banfield JF (2003) Microbial communities in acid mine drainage. FEMS Microbiol Ecol 44:139–152CrossRefGoogle Scholar
  5. Batty L, Hooley D, Younger P (2008) Iron and manganese removal in wetland treatment systems: rates, processes, and implications for management. Sci Total Environ 394:1–8CrossRefGoogle Scholar
  6. Bohu T, Santelli CM, Akob DM, Neu TR, Ciobota V, Rösch P, Popp J, Nietzsche S, Küsel K (2015) Characterization of pH dependent Mn(II) oxidation strategies and formation of a bixbyite-like phase by Mesorhizobium australicum T-G1. Front Microbiol 6:734CrossRefGoogle Scholar
  7. Box GEP, Cox DR (1964) An analysis of transformations. J R Stat Soc Ser B 26:211–252Google Scholar
  8. Brantner JS, Senko JM (2014) Response of soil-associated microbial communities to intrusion of coal mine-derived acid mine drainage. Environ Sci Technol 48:8556–8563CrossRefGoogle Scholar
  9. Brantner JS, Haake ZJ, Burwick JE, Menge CM, Hotchkiss ST, Senko JM (2014) Depth-dependent geochemical and microbiological gradients in Fe(III) deposits resulting from coal mine-derived acid mine drainage. Front Microbiol 5:2215–2218CrossRefGoogle Scholar
  10. Chaput DL, Hansel CM, Burgos WD, Santelli SM (2015) Profiling microbial communities in manganese remediation systems treating coal mine drainage. Appl Environ Microbiol 81:2189–2198CrossRefGoogle Scholar
  11. Cravotta CA III (2008) Dissolved metals and associated constituents in abandoned coal-mine discharges, Pennsylvania, USA. Part 1: constituent quantities and correlations. Appl Geochem 23:166–202CrossRefGoogle Scholar
  12. Duarte RA, Ladeira AC (2011) Study of manganese removal from mining effluent. In: IMWA Conference, Aachen Germany, pp 297–300Google Scholar
  13. Francis CA, Tebo BM (2001) Enzymatic manganese(II) oxidation by a marine α-proteobacterium. Appl Environ Microbiol 67:4024–4029CrossRefGoogle Scholar
  14. Gazea B, Adam K, Kontopoulos A (1996) A review of passive systems for the treatment of acid mine drainage. Miner Eng 9:23–42CrossRefGoogle Scholar
  15. Gray JB, Vis ML (2013) Reference diatom assemblage response to restoration of an acid mine drainage stream. Ecol Indic 29:234–245CrossRefGoogle Scholar
  16. Hallberg KB, Johnson DB (2003) Novel acidophiles isolated from moderately acidic mine drainage waters. Hyrdometallurgy 71:139–148CrossRefGoogle Scholar
  17. Hallberg KB, Johnson DB (2005) Biological manganese removal from acid mine drainage in constructed wetlands and prototype bioreactors. Sci Total Environ 338:115–124CrossRefGoogle Scholar
  18. HRWRP (2014) NPS Report—Huff Run Watershed Report. http://www.watersheddata.com/userview_file.aspx?UserFileLo=1&UserFileID=177. Accessed Nov 2017
  19. HRWRP (2015) Surface water database. http://www.watersheddata.com/map/map.aspx?WaterShed=HR1. Accessed Nov 2017
  20. HRWRP, Huff Run Watershed-Linden Bioremediation Project (2003) Non-point source monitoring system. http://watersheddata.com/userview_file.aspx?UserFileLo=2&UserFileID=377. Accessed Nov 2017
  21. Johnson DB (1995) Selective solid media for isolating and enumerating acidophilic bacteria. J Microbiol Methods 23:205–218CrossRefGoogle Scholar
  22. Johnson DB, Hallberg KB (2002) Pitfalls of passive mine water treatment. Rev Environ Sci Biotechnol 1:335–343CrossRefGoogle Scholar
  23. Johnson DB, Hallberg KB (2005) Acid mine drainage remediation options: a review. Sci Total Environ 338:3–14CrossRefGoogle Scholar
  24. Lagos GI (2011) The use of bench-scale treatability studies in the design of engineered wetlands for the remediation of acid mine drainage (AMD) and leachate in the vicinity of coal mines. A case study in Ohio, United States. Proc Earth Planet Sci 3:11–16CrossRefGoogle Scholar
  25. Larson LN, Sanchez-Espana J, Burgos W (2014) Rates of low-pH biological Fe(II) oxidation in the Appalachian bituminous coal basin and the Iberian pyrite belt. Appl Geochem 47:85–98CrossRefGoogle Scholar
  26. Learman DR, Wankel SD, Webb SM, Martinez N, Madden AS, Hansel CM (2011) Coupled biotic-abiotic Mn(II) oxidation pathway mediates the formation and structural evolution of biogenic Mn oxides. Geochim Cosmochim Acta 75:6048–6063CrossRefGoogle Scholar
  27. Luan F, Santelli CM, Hansel CM, Burgos WD (2012) Defining manganese(II) removal processes in passive coal mine drainage treatment systems through laboratory incubation experiments. Appl Geochem 27:1567–1578CrossRefGoogle Scholar
  28. Luptakova A, Ubaldini S, Macingova E, Fornari P, Guiliano V (2012) Application of physical-chemical and biological-chemical methods for heavy metals removal from acid mine drainage. Proc Biochem 47:1633–1639CrossRefGoogle Scholar
  29. Matlock MM, Howerton BS, Atwood DA (2002) Chemical precipitation of heavy metals from acid mine drainage. Water Res 36:4757–4764CrossRefGoogle Scholar
  30. Matthies R, Aplin AC, Jarvis AP (2010) Performance of a passive treatment systems for net-acidic coal mine drainage over five years of operation. Sci Total Environ 408:4877–4885CrossRefGoogle Scholar
  31. Mays PA, Edwards GS (2001) Comparison of heavy metal accumulation in a natural wetland and constructed wetlands receiving acid mine drainage. Ecol Eng 16:487–500CrossRefGoogle Scholar
  32. ODNR (Ohio Department Natural Resources (2008) High calcium limestones in Ohio. GeoFacts 25. http://www.OhioGeology.com. Accessed Nov 2017
  33. Outram JG, Couperthwaite SJ, Millar GJ (2018) Enhance removal of high Mn(II) and minor heavy metals from acid mine drainage using tunneled manganese oxides. J Environ Chem Eng 6:3249–3261CrossRefGoogle Scholar
  34. Riefler RG, Krohn J, Stuart B, Socotch C (2008) Role of sulfur-reducing bacteria in a wetland system treating acid mine drainage. Sci Total Environ 394:222–229CrossRefGoogle Scholar
  35. Robinson-Lora MA, Brennan RA (2010) Biosorption of manganese onto chitin and associated proteins during the treatment of mine impacted water. Chem Eng J 162:565–572CrossRefGoogle Scholar
  36. Santelli CM, Pfister DH, Lazarus D, Sun L, Burgos WD, Hansel CM (2010) Promotion of Mn(II) oxidation and remediation of cola mine drainage in passive treatment systems of diverse fungal and bacterial communities. Appl Environ Microbiol 76:4871–4875CrossRefGoogle Scholar
  37. Santelli CM, Webb SM, Dohnalkova AC, Hansel CM (2011) Diversity of oxides produced by Mn(II)-oxidizing fungi. Geochim Cosmochim Acta 75:2762–2776CrossRefGoogle Scholar
  38. Schaider LA, Senn DB, Estes ER, Brabander DJ, Shine JP (2014) Sources and fates of heavy metals in a mining-impacted stream: temporal variability and the role of iron oxides. Sci Total Environ 490:456–466CrossRefGoogle Scholar
  39. Senko JM, Wanjugi P, Lucas M, Bruns MA, Burgos WD (2008) Characterization of Fe(II) oxidizing bacterial communities at two acidic Appalachian coal mine drainage impacted sites. ISME J 2:1134–1145CrossRefGoogle Scholar
  40. Sikora FJ, Behrends LL, Brodie GA, Taylor HN (2000) Design criteria and required chemistry for removing manganese in acid mine drainage using subsurface flow wetlands. Water Environ Res 72:536–544CrossRefGoogle Scholar
  41. Silva AM, Cruz FLS, Lima RMF, Teixeira MC, Leao VA (2010) Manganese interactions during mine water treatment. J Hazard Mater 181:514–520CrossRefGoogle Scholar
  42. Silva AM, Cunha EC, Silva FDR, Leao VA (2012) Treatment of high-manganese mine water with limestone and sodium carbonate. J Clean Prod 29–30:11–19CrossRefGoogle Scholar
  43. Simate GS, Ndlovu S (2014) Acid mine drainage: challenges and opportunities. J Environ Chem Eng 2:1785–1803CrossRefGoogle Scholar
  44. Skousen JG, Sexstone A, Ziemkiewica PF (2000) Acid mine drainage control and treatment: reclamation of drastically disturbed lands, American Society of Agronomy and American Society for Surface Mining and Reclamation. Agronomy No. 41Google Scholar
  45. Skousen J, Zipper CE, Rose A, Ziemkiewica PF, Nairn R, McDonald LM, Kleinmann RL (2017) Review of passive systems for acid mine drainage. Mine Water Environ 36:133–153CrossRefGoogle Scholar
  46. Socotch C, Gue J, Seger NA, Uranowski L (2003) Development of the Linden AMD bioremediation system: Huff Run watershed, Tuscarawas and Carroll County, Ohio. http://www.huffrun.org. Accessed Nov 2017
  47. Stookey LL (1970) Ferrozine—a new spectrophotometric reagent for iron. Anal Chem 42:779–781CrossRefGoogle Scholar
  48. Tan H, Zhang G, Heaney PJ, Webb SM, Burgos WD (2010) Characterization of manganese oxide precipitates from Appalachian coal mine drainage treatment systems. Appl Geochem 25:389–399CrossRefGoogle Scholar
  49. Tang Y, Zeiner CA, Santelli CM, Hansel CM (2013) Fungal oxidative dissolution of the Mn(II)-bearing mineral rhodochrosite and the role of metabolites in manganese oxide formation. Environ Microbiol 15:1063–1077CrossRefGoogle Scholar
  50. Tarutis WJ Jr, Unz RF (1995) Iron and manganese release in coal mine drainage wetland microcosms. Water Sci Technol 32:187–192CrossRefGoogle Scholar
  51. Tebo BM, Bargar JR, Clement BG, Dick GJ, Murray KJ, Parker D, Verity R, Webb SM (2004) Biogenic manganese oxides: properties and mechanisms of formation. Ann Rev Earth Planet Sci 32:287–328CrossRefGoogle Scholar
  52. Tebo BM, Johnson HA, McCarthy JK, Templeton AS (2005) Geomicrobiology of manganese(II) oxidation. Trends Microbiol 13:421–428CrossRefGoogle Scholar
  53. USGS (US Geological Survey) (2018) Geologic units in Tuscarawas county, Ohio. https://mrdata.usgs.gov/geology/state/fips-unit.php?code=f39157. Accessed Nov 2017
  54. Vail WJ, Riley RK (1995) Process for removing manganese from solutions including aqueous industrial waste. United States Patent Number 5,441,641Google Scholar
  55. Valente TM, Antunes M, Braga AS, Prudencio MI, Marques R, Pamplona J (2012) Mineralogical attenuation fro metallic remediation in a passive system for mine water treatment. Environ Earth Sci 66:39–54CrossRefGoogle Scholar
  56. White RA, Freeman C, Kang H (2011) Plant-derived phenolic compounds impair the remediation of acid mine drainage using treatment wetlands. Ecol Eng 37:172–175CrossRefGoogle Scholar
  57. Wilkin RT (2008) Containment attenuation processes at mine sites. Mine Water Environ 27:251–258CrossRefGoogle Scholar
  58. Wise M (2010) Huff Run watershed plan. http://www.water.ohiodnr.gov/portals/soilwater/downloads/wap/HuffRun.pdf. Accessed Nov 2017
  59. Ye ZH, Whiting SN, Lin ZQ, Lytlem CM, Qian JH, Terry N (2001) Removal and distribution of iron, manganese, cobalt and nickel within a Pennsylvanian constructed wetland treating coal combustion by-product leachate. J Environ Qual 30:1464–1473CrossRefGoogle Scholar
  60. Younger PL (1997) The longevity of minewater pollution: a basis for decision-making. Sci Total Environ 194/195:457–466CrossRefGoogle Scholar
  61. Zipper CE, Skousen JG (2010) Influent water quality affects performance of passive treatment systems for acid mine drainage. Mine Water Environ 29:135–143CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  1. 1.Department of Civil EngineeringThe University of AkronAkronUSA
  2. 2.Department of Geosciences, Department of BiologyThe University of AkronAkronUSA

Personalised recommendations