Waste and Biomass Valorization

, Volume 8, Issue 5, pp 1803–1811 | Cite as

A Case Study of the Effects of Sewage Sludge Application on Soil Properties and Heavy Metal Availability in the Thessaloniki Plain (Greece)

  • P. Tziachris
  • E. Lekakis
  • K. Zambetoglou
  • I. Metaxa
  • F. Papadopoulos
Original Paper
First Online:
Received:
Accepted:

Abstract

The amended soils chemical properties as affected by the application of a single dose of sewage sludge were evaluated over a 1-year period. Three soil groups based on their pH values were examined. Data on pH, organic matter, CaCO3, electrical conductivity, exchangeable Ca and Mg, concentration of nine metals (Cd, Co, Cr, Pb, Zn, Ni, Fe, Mn, Cu) and nutrients before the application of sewage sludge in 2013 and after the wheat growing period in 2014, were statistically analyzed. Results showed that the application of lime stabilized sewage sludge significantly increased the electrical conductivity, CaCO3 and Mg in all soil groups as well as pH and Ca of acidic soils, while the organic matter was not affected. The levels of concentrations of most DTPA-extractable metals in soil, either decreased or remained the same as they were before the sludge application. Soil Zn was the only metal that increased in the acidic soil group, however in concentrations largely below ecotoxicological limits. It is concluded that the application of lime stabilized sewage sludge to soils may take place with no risk of increasing heavy metal bioavailability to phytotoxic levels. Further benefits to crops are provided by favoring pH conditions for plant growth in acidic soils and by improving plant nutrition via nitrogen addition.

Keywords

Sewage sludge Agricultural utilization Trace metals Lime stabilization 
This is a preview of subscription content, log in to check access.

Supplementary material

12649_2016_9766_MOESM1_ESM.xlsx (33 kb)
Supplementary material 1 (XLSX 33 kb)

References

  1. 1.
    Werther, J., Ogada, T.: Sewage sludge combustion. Prog. Energ. Combust. 25, 55–116 (1999)CrossRefGoogle Scholar
  2. 2.
    Usman, K., Khan, S., Ghulam, S., Khan, M.U., Khan, N., Khan, M.A., Khalil, S.K.: Sewage sludge: an important biological resource for sustainable agriculture and its environmental implications. Am. J. Plant Sci. 3, 1708–1721 (2012)CrossRefGoogle Scholar
  3. 3.
    Fytili, D., Zabaniotou, A.: Utilization of sewage sludge in EU application of old and new methods—a review. Renew Sust. Energ. Rev. 12, 116–140 (2008)CrossRefGoogle Scholar
  4. 4.
    Kelessidis, A., Stasinakis, A.S.: Comparative study of the methods used for treatment and final disposal of sewage sludge in European countries. Waste Manage. 32, 1186–1195 (2012)CrossRefGoogle Scholar
  5. 5.
    Andreadakis, Α.D., Mamais, D., Gavalaki, E., Kampylafka, S.: Sludge utilization in agriculture: possibilities and prospects in Greece. In: Proceedings of the 7th International Conference on Environmental Science and Technology, September 3–6, Syros, Greece (2001)Google Scholar
  6. 6.
    CEC (Council of the European Communities): Council Directive of 12 June 1986 on the protection of the environment, and in particular of the soil, when sewage sludge is used in agriculture (86/278/EEC). Official Journal of the European Communities No. L 181/6-12 (1986)Google Scholar
  7. 7.
    Vieira, R.F., Moriconi, W., Pazianotto, R.A.A.: Residual and cumulative effects of soil application of sewage sludge on corn productivity. Environ. Sci. Pollut. Res. 21(10), 6472–6481 (2014)CrossRefGoogle Scholar
  8. 8.
    Antoniadis, V.: Sewage sludge application and soil properties effects on short-term zinc leaching in soil columns. Water Air Soil Pollut. 190, 35–43 (2008)CrossRefGoogle Scholar
  9. 9.
    Mahapatra, K., Ramteke, D.S., Paliwal, L.J., Naik, N.K.: Agronomic application of food processing industrial sludge to improve soil quality and crop productivity. Geoderma 207–208, 205–211 (2013)CrossRefGoogle Scholar
  10. 10.
    Mosquera-Losada, M.R., López-Díaz, M.L., Rigueiro-Rodriguez, A.: Sewage sludge fertilization of a silvopastoral system with pines in northwestern Spain. Agrofor. Syst. 53, 1–10 (2001)CrossRefGoogle Scholar
  11. 11.
    Motta, S.R., Maggiore, T.: Evaluation of nitrogen management in maize cultivation grows on soil amended with sewage sludge and urea. Eur. J. Agron. 45, 59–67 (2013)CrossRefGoogle Scholar
  12. 12.
    Alvarenga, P., Farto, M., Mourinha, C., Palma, P.: Beneficial use of dewatered and composted sewage sludge as soil amendments: behaviour of metals in soils and their uptake by plants. Waste Biomass Valoriz. (2016). doi: 10.1007/s12649-016-9519-z Google Scholar
  13. 13.
    Ojeda, G., Alcañiz, J.M., Le Bissonnais, Y.: Differences in aggregate stability due to various sewage sludge treatments on a Mediterranean calcareous soil. Agric. Ecosyst. Environ. 125, 48–56 (2008)CrossRefGoogle Scholar
  14. 14.
    Roig, N., Sierra, J., Martí, E., Nadal, M., Schuhmacher, M., Domingo, J.L.: Long-term amendment of Spanish soils with sewage sludge: effects on soil functioning. Agric. Ecosyst. Environ. 158, 41–48 (2012)CrossRefGoogle Scholar
  15. 15.
    Mathioudakis, V.L., Kapagiannidis, A.G., Athanasoulia, E., Paltzoglou, A.D., Melidis, P., Aivasidis, A.: Sewage sludge solar drying: experiences from the first pilot-scale application in Greece. Dry. Technol. 31, 519–526 (2013)CrossRefGoogle Scholar
  16. 16.
    Suchkova, N., Alifragkis, D., Ganoulis, J., Darakas, E., Sawidis, Th, Stolberg, F.: Reclamation with phytoremediation of area affected by sewage sludge at the Thessaloniki Wastewater Treatment Plant in Sindos (Greece). Toxicol. Environ. Chem. (2014). doi: 10.1080/02772248.2014.966715 Google Scholar
  17. 17.
    Tsadilas, C., Samaras, V., Evangelou, E., Shaheen, S.M.: Influence of fly ash and sewage sludge application on wheat biomass production, nutrients availability and soil properties. Int. J. Coal Sci. Technol. 1(2), 221–226 (2014)CrossRefGoogle Scholar
  18. 18.
    Suchkova, N., Darakas, E., Ganoulis, J.: Phytoremediation as a prospective method for rehabilitation of areas contaminated by long-term sewage sludge storage: a Ukrainian–Greek case study. Ecol. Eng. 36, 373–378 (2010)CrossRefGoogle Scholar
  19. 19.
    Katsoyiannis, A., Samara, C.: Ecotoxicological evaluation of the wastewater treatment process of the sewage treatment plant of Thessaloniki, Greece. J. Hazard. Mater. 141, 614–621 (2007)CrossRefGoogle Scholar
  20. 20.
    Suchkova N.G.: Experimental investigation of phytoreclamation of sites affected by sewage sludge. Ph.D. Thesis, Aristotle University, Department of Civil Engineering, Division of Hydraulics and Environmental Engineering, Thessaloniki, Greece (2014)Google Scholar
  21. 21.
    Suchkova, N., Papadopoulos, F., Korpetis, E., Metaxa, I., Lekakis, E., Zampetoglou, K.: A software for the agricultural utilization of sewage sludge: Determination of application doses. In: Greek. Proceedings of the Second Environmental Conference of Thessaly, September 26–28, Skiathos, Greece (2015)Google Scholar
  22. 22.
    JMD (Joint Ministerial Decision): Terms, Conditions and Limitations for the Agricultural Utilization of Sewage Sludge, originating from Municipal and Domestic Waste Water Treatment (JMD 80568/4225/91). Government Gazette No. 641/Β/7-08-1991 (1991)Google Scholar
  23. 23.
    Papadopoulos, A., Papadopoulos, F., Tziachris, P., Metaxa, I., Iatrou, M.: Site specific management with the use of a digitized soil map for the regional unit of Kastoria. Fork Farm Int. J. Innov. Res. Pract. 1(1), 1–10 (2014)Google Scholar
  24. 24.
    Papadopoulos, A., Papadopoulos, F., Tziachris, P., Metaxa, I., Iatrou, M.: Site specific agricultural soil management with the use of new technologies. Glob. Nest J. 16(1), 59–67 (2014)Google Scholar
  25. 25.
    Rhoades, J.D. Salinity: Electrical conductivity and total dissolved solids. In: Sparks, D.L., Page, A.L., Helmke, P.A., Loeppert, R.H., Soltanpour, P.N., Tabatabai, M.A., Johnston, C.T., Sumner, M.E. (eds.) Methods of Soil Analysis. Part 3. Chemical Methods; Soil Science Society of America Book Series 5.3; Soil Science Society of America, American Society of Agronomy, pp. 417–436. Madison, WI, USA (1996)Google Scholar
  26. 26.
    Ben-Dor, E., Banin, A.: Determination of organic matter content in arid zone soils using a simple “loss-on-ignition” method. Commun. Soil Sci. Plant Anal. 20, 1675–1695 (1989)CrossRefGoogle Scholar
  27. 27.
    Loeppert, R.H., Suarez, G.L.: 1996. Carbonates and Gypsum. In Sparks D.L. ed. Methods of soil analysis. Part 3, Chemical methods. Madison, Wisconsin, USA (1996)Google Scholar
  28. 28.
    Clesceri, L.S., Greenberg, A.E., Truseell, R.R.: Standard Methods for the Examination of Water and Wastewater, 17th edn. APHA, AWWA, WPCF, Washington (1989)Google Scholar
  29. 29.
    Nelson, D.W.: Determination of ammonium in KCl extracts of soil by the salicylate method. Commun. Soil Sci. Plant Anal. 14, 1051–1062 (1983)CrossRefGoogle Scholar
  30. 30.
    Bremner, J.M.: Total nitrogen. In C.A. Black et al. (ed.) Methods of soil analysis. Part 2, American Society of Agronomy, Madison, WI, pp. 1145–1178 (1965)Google Scholar
  31. 31.
    Thomas, G.W.: Exchangeable cations. In: Klute, A. (ed.) Methods of soil analysis. Part 2. Chemical and microbiological properties, 2nd ed., Agronomy Monograph 9. American Society of Agronomy, Soil Science Society of America, pp. 159–165. Madison, WI, USA (1982)Google Scholar
  32. 32.
    Watanabe, F.S., Olsen, S.R.: Test of an ascorbic acid method for determining phosphorus in water and NaHCO3 extracts from soils. Soil Sci. Soc. Am. Proc. 29, 677–678 (1965)CrossRefGoogle Scholar
  33. 33.
    Lindsay, W.L., Norvell, W.A.: Development of a DTPA soil test for zinc, iron, manganese and copper. Soil Sci. Soc. Am. J. 42, 421–428 (1978)CrossRefGoogle Scholar
  34. 34.
    Allen, S.E.: Chemical Analysis of Ecological Materials. Blackwell, Oxford (1989)Google Scholar
  35. 35.
    Walkley, A., Black, I.A.: An examination of the Degtjareff method for determining soil organic matter, and a proposed modification of the chromic acid titration method. Soil Sci. 37, 29–38 (1934)CrossRefGoogle Scholar
  36. 36.
    Sommers, L.E., Parker, C.F., Meyers G.J.: Volatilization, plant uptake and mineralization of nitrogen in soils treated with sewage sludge. Technical Reports. Paper 133. Indiana Water Resources Research Center, Purdue University, West Lafayette, IN (1981)Google Scholar
  37. 37.
    Guo, M., Song, W., Kazda, R.: Fertilizer value of lime-stabilized biosolids as a soil amendment. Agron. J. 104(6), 1679–1686 (2012)CrossRefGoogle Scholar
  38. 38.
    Nogueira, T.A.R., Franco, A., He, Z., Braga, V.S., Firme, L.P., Abreu-Junior, C.H.: Short-term usage of sewage sludge as organic fertilizer to sugarcane in a tropical soil bears little threat of heavy metal contamination. J. Environ. Manage. 114, 168–177 (2013)CrossRefGoogle Scholar
  39. 39.
    Willett, I.R., Jakobsen, P., Malafant, K.W.J.: Fertilizer and liming value of lime-treated sewage sludge. Fert. Res. 8(3), 313–328 (1986)CrossRefGoogle Scholar
  40. 40.
    Tsadilas, C.D., Matsi, T., Barbayiannis, N., Dimoyiannis, D.: Influence of sewage sludge application on soil properties and on the distribution and availability of heavy metal fractions. Commun. Soil Sci. Plan. 26(15–16), 2603–2619 (1995)CrossRefGoogle Scholar
  41. 41.
    Akrivos, J., Mamais, D., Katsara, K., Andreadakis, A.: Agricultural utilization of lime treated sewage sludge. Water Sci. Technol. 42(9), 203–210 (2000)Google Scholar
  42. 42.
    Mendoza, J., Garrido, T., Castillo, G., San Martin, N.: Metal availability and uptake by sorghum plants grown in soils amended with sludge from different treatments. Chemosphere 65(11), 2304–2312 (2006)CrossRefGoogle Scholar
  43. 43.
    Merrington, G., Oliver, I., Smernik, R.J., McLaughlin, M.J.: The influence of sewage sludge properties on sludge-borne metal availability. Adv. Environ. Res. 8, 21–36 (2003)CrossRefGoogle Scholar
  44. 44.
    Correa, R.S., White, R.E., Weatherley, A.J.: Risk of nitrate leaching from two soils amended with biosolids. Water Resour. 33(4), 453–462 (2006)CrossRefGoogle Scholar
  45. 45.
    Corrêa, R.S., White, R.E., Weatherley, A.J.: Effects of sewage sludge stabilization on organic-N mineralization in two soils. Soil Use Manage. 28(1), 12–18 (2012)CrossRefGoogle Scholar
  46. 46.
    Osman, K.T.: Soils. Principles, Properties and Management. Springer, Dordrecht. ISBN 978-94-007-5663-2 (eBook) (2013)Google Scholar
  47. 47.
    Christie, P., Easson, D.L., Picton, J.R., Love, S.C.P.: Agronomic value of alkaline-stabilized sewage biosolids for spring barley. Agron. J. 93(1), 144–151 (2001)CrossRefGoogle Scholar
  48. 48.
    Li, Q., Li, J.M., Cui, X.L., Wei, D.P., Ma, Y.B.: On-farm assessment of biosolids effects on nitrogen and phosphorus accumulation in soils. J. Integr. Agr. 11(9), 1545–1554 (2012)CrossRefGoogle Scholar
  49. 49.
    Fuentes, A., Lloréns, M., Sáez, J., Aguilar, M.I., Pérez-Marín, A.B., Ortuño, J.F., Meseguer, V.F.: Ecotoxicity, phytotoxicity and extractability of heavy metals from different stabilised sewage sludges. Environ. Pollut. 143, 355–360 (2006)CrossRefGoogle Scholar
  50. 50.
    Marchi, G.: Guilherme, L.R.G., Chang, A.C., do Nascimento, C.W.A.: Heavy metals extractability in a soil amended with sewage sludge. Sci. Agric. 66(5), 643–649 (2009)CrossRefGoogle Scholar
  51. 51.
    Tsadilas, C.D.: Effect of soil pH on the distribution of heavy metals among soil fractions. In: Iskandar, I. (ed.) Environment Restoration of Metals-Contaminated Soils, pp. 107–119. Lewis Publishers, Boca Raton (2000)CrossRefGoogle Scholar
  52. 52.
    Shaheen, S.M., Tsadilas, C.D.: Influence of fly ash and sewage sludge application on cadmium and lead sorption by an acidic Alfisol. Pedosphere 20(4), 436–445 (2010)CrossRefGoogle Scholar
  53. 53.
    Rigueiro-Rodríguez, A., Mosquera-Losada, M.R., Ferreiro-Domínguez, N.: Pasture and soil zinc evolution in forest and agriculture soils of Northwest Spain three years after fertilization with sewage sludge. Agr. Ecosyst. Environ. 150, 111–120 (2012)CrossRefGoogle Scholar
  54. 54.
    Mosquera-Losada, M.R., Muñoz-Ferreiro, N., Rigueiro-Rodríguez, A.: Agronomic characterization of different types of sewage sludge: policy implications. Waste Manage. 30, 492–503 (2010)CrossRefGoogle Scholar
  55. 55.
    Kabata-Pendias, A.: Trace elements in soils and plants, 4th edn. CRC Press, Taylor & Francis Group, Boca Raton (2011)Google Scholar
  56. 56.
    Long, X.X., Yang, X.E., Ni, W.Z., Ye, Z.Q., He, Z.L., Calvert, D.V., Stoffella, J.P.: Assessing zinc thresholds for phytotoxicity and potential dietary toxicity in selected vegetable crops. Commun. Soil Sci. Plan. 34(9 & 10), 1421–1434 (2003)CrossRefGoogle Scholar
  57. 57.
    McGrath, S.P., Zhao, F.J., Dunham, S.J., Crosland, A.R., Coleman, K.: Long-term changes in the extractability and bioavailability of zinc and cadmium after sludge application. J. Environ. Qual. 29, 875–883 (2000)CrossRefGoogle Scholar
  58. 58.
    Fuentes, A., Lloréns, M., Sáez, J., Soler, A., Aguilar, M., Ortuño, F.: Phytotoxicity and heavy metals speciation of stabilised sewage sludges. J. Hazard. Mater. 108(3), 161–169 (2004)CrossRefGoogle Scholar
  59. 59.
    Sharma, B.D., Mukhopadhyay, S.S., Sidhu, P.S., Katyal, J.C.: Pedospheric attributes in distribution of total and DTPA-extractable Zn, Cu, Mn and Fe in Indo Gangetic plains. Geoderma 96, 131–151 (2000)CrossRefGoogle Scholar
  60. 60.
    Jiang, Y., Qin, Y., Zhang, Y., Li, Q., Liang, W.: Spatial heterogeneity of soil DTPA-extractable copper as affected by city pollution and land use in cultivated fields of Shenyang, China. Am Eurasian J. Agric. Environ. Sci. 4, 294–301 (2008)Google Scholar
  61. 61.
    McGonigle, T.P., Evans, L.J., Wells, C.J.: Soil and crop micronutrient concentrations as modified by wastewater sludge. J. Environ. Ecol. 5(2), 33–47 (2014)CrossRefGoogle Scholar
  62. 62.
    Seyhan, D., Erdincler, A.: Plant availability of heavy metals and phosphorus in the agricultural reuse of biological sludges. J. Environ. Sci. Health A Tox. Hazard. Subst. Environ. Eng. 38(10), 2413–2423 (2003)CrossRefGoogle Scholar
  63. 63.
    Cuevas, G., Martínez, F., Walter, I.: Field-grown maize (Zea mays L.) with composted sewage sludge. Effects on soil and grain quality. Span. J. Agric. Res. 1(3), 111–119 (2003)CrossRefGoogle Scholar
  64. 64.
    Frost, H.L., Ketchum Jr., L.H.: Trace metal concentration in durum wheat from application of sewage sludge and commercial fertilizer. Adv. Environ. Res. 4, 347–355 (2000)CrossRefGoogle Scholar
  65. 65.
    Pascual, I., Antolín, M.C., García, C., Polo, A., Sánchez-Díaz, M.: Plant availability of heavy metals in a soil amended with a high dose of sewage sludge under drought conditions. Biol. Fertil. Soils 40, 291–299 (2004)CrossRefGoogle Scholar
  66. 66.
    Narwal, R.P., Singh, B.R., Panhwar, A.R.: Plant availability of heavy metals in a sludge-treated soil: I. Effect of sewage sludge and soil pH on the yield and chemical composition of rape. J. Environ. Qual. 12, 358–365 (1983)CrossRefGoogle Scholar
  67. 67.
    Christensen, T.H.: Cd soil sorption at low concentrations: I. Effect of time, Cd load, pH and Ca. Water Air Soil Pollut. 21, 105–114 (1984)CrossRefGoogle Scholar
  68. 68.
    Wong, J.W.C., Selvam, A.: Speciation of heavy metals during co-composting of sewage sludge with lime. Chemosphere 63, 980–986 (2006)CrossRefGoogle Scholar
  69. 69.
    Rodríguez-Jordá, M.P., Garrido, F., García-González, M.T.: Potential use of gypsum and lime rich industrial by-products for induced reduction of Pb, Zn and Ni leachability in an acid soil. J. Hazard. Mater. 175, 762–769 (2010)CrossRefGoogle Scholar
  70. 70.
    Dowdy, R.H., Clapp, C.E., Linden, D.R., Larson, W.E., Halbach, T.R., Polta, R.C.: Twenty years of trace metal partitioning on the Rosemount sewage sludge watershed, Ιn: Clapp, E.C., Larson, W.E., Dowdy, R.H., (eds.), Sewage Sludge Land Utilization and the Environment, pp. 149–155. American Society of Agronomy, Inc., Crop Science Society of America, Inc., Soil Science Society of America, Inc., 5585 Guilford Rd., Madison, WI 53711 USA (1994)Google Scholar
  71. 71.
    Barbarick, K.A., Ippolito, J.A., Westfall, D.G.: Extractable trace elements in the soil profile after years of biosolids application. J. Environ. Qual. 27(4), 801–805 (1998)CrossRefGoogle Scholar
  72. 72.
    Han, F.X., Kingery, W.L., Selim, H.M.: Accumulation, redistribution, transport and bioavailability of heavy metals in waste-amended soils In: Iskandar, I.K., Kirkham, M.B. (eds.) Trace Elements in Soil: Bioavailability, Flux, and Transfer. pp. 145–174. CRC Press LLC, N.W. Corporate Blvd., Boca Raton, FL, p. 33431 (2001)Google Scholar
  73. 73.
    Hormann, C.M., Clapp, C.E., Dowdy, R.H, Larson, W.E., Duncomb, D.R., Halbach, T.R., Polta, R.C.: Effect of lime-cake municipal sewage sludge on corn yield, nutrient uptake and soil analyses. In: Clapp, E.C., Larson, W.E., Dowdy, R.H., (eds), Sewage Sludge Land Utilization and the Environment. pp. 173–183. American Society of Agronomy, Inc., Crop Science Society of America, Inc., Soil Science Society of America, Inc., 5585 Guilford Rd., Madison, WI 53711 USA (1995)Google Scholar
  74. 74.
    Jarausch-Wehrheim, B., Mocquot, M., Mench, M.: Uptake and partitioning of sludge borne copper in field-grown maize (Zea mays L.). Eur. J. Agron. 5, 259–271 (1996)CrossRefGoogle Scholar
  75. 75.
    Börjesson, G., Kirchmann, H., Kätterer, T.: Four Swedish long-term field experiments with sewage sludge reveal a limited effect on soil microbes and on metal uptake by crops. J. Soil Sediment. 14(1), 164–177 (2014)CrossRefGoogle Scholar

Copyright information

© Springer Science+Business Media Dordrecht 2016

Authors and Affiliations

  1. 1.Soil and Water Resources InstituteHellenic Agricultural Organization (H.A.O.) DIMITRAThessalonikiGreece
  2. 2.Thessaloniki-Greece Water Supply and Sewerage Cο. S.A. EYATH S.A.ThessalonikiGreece

Personalised recommendations