Study on microscopic flow mechanism of polymer flooding
- 14 Downloads
Polymer flooding plays an important role in chemical enhanced oil recovery (EOR) methods, and has been widely used in oilfields, particularly Daqing, the largest oilfield in China. However, our understanding of the mechanism of polymer flooding is not very clear. The mechanism of a two-phase micro-flow remains a challenge to researchers, because the structural complexity of a porous medium and the rheological property of a non-Newtonian fluid can increase the difficulty in such research. Computational fluid dynamics provides a numerical simulation method for further investigating the mechanism of polymer flooding at the micro-scale. In this study, OpenFOAM was used to study the two-phase micro-flow of both water and polymer flooding. Based on a micro-physical model of a complex pore structure, the continuity equation, momentum equation, and non-Newtonian fluid constitutive equations of a two-phase flow are established, and the phase equation of the two-phase interface is then developed using the volume of fluid methodology. These equations are solved using the InterFoam solver in OpenFOAM. The saturation, pressure, and velocity distribution characteristics of water and polymer flooding were obtained. The results show that the high viscosity of a polymer solution improves the mobility ratio, inhibits the fingering phenomena, increases the displacement area, and improves the displacement efficiency. The breakthrough time of polymer flooding under a Newtonian rheological property occurs 0.3 s later than that of water flooding, and the displacement pressure drop is higher. When the flow reaches a steady state, the displacement pressure drop of polymer flooding under a Newtonian rheological property is five times that of water flooding, and the displacement efficiency increases by 8–20%. In non-Newtonian fluids with a shear thinning characteristic, where the viscosity of the polymer solution is reduced as compared with polymer flooding under a Newtonian rheological property, polymer flooding under a non-Newtonian rheological property occurs 0.1 s earlier, the displacement pressure drop is reduced by 300 Pa, and the displacement efficiency decreases 4%. These research results will provide a theoretical foundation for a micro-flow mechanism of a two-phase flow in a complex pore structure.
KeywordsPolymer flooding Complex pore model Two-phase micro-flow OpenFOAM
This work presented in this paper was financially supported by the National Natural Science Funds for Young Scholars of China (Grant no. 51604079) and the Natural Science Foundation of Heilongjiang Province (Grant no. E2017012). The Natural Science Foundation of Heilongjiang Province (Grant no. E2016015) and the University Nursing Program for Young Scholars with Creative Talents in Heilongjiang Province (Grant no. UNPYSCT-2016126) are gratefully acknowledged.
- Békri S, Laroche C, Vizika O (2005) Pore network models to calculate transport and electrical properties of single or dual-porosity rocks. In: SCA2005–35, Proceedings of the International Symposium of the Society of Core Analysts, Toronto, CanadaGoogle Scholar
- Buchgraber M, Clemens T, Castanier LM, Kovscek A (2011) A microvisual study of the displacement of viscous oil by polymer solutions. SPE Reserv Eval Eng 14(3):269–280Google Scholar
- Doorwar S, Mohanty KK (2011) Viscous fingering during non-thermal heavy oil recovery. In: SPE-146841-MS, Proceedings of the SPE Annual Technical Conference and Exhibition, Denver, Colorado, USAGoogle Scholar
- Hornbrook JW, Castanier LM, Pettit PA (1991) Observation of foam/oil interactions in a new, high-resolution micromodel. In: SPE-22631-MS, Proceedings of the SPE Annual Technical Conference and Exhibition, Dallas, Texas, USAGoogle Scholar
- Koroteev DA, Dinariev O, Evseev N, Klemin DV, Safonov S, Gurpinar OM, Berg S, van Kruijsdijk C, Myers M, Hathon L, de Jong H, Armstrong R (2013) Application of digital rock technology for chemical EOR screening. In: SPE-165258-MS, Proceedings of the SPE Enhanced Oil Recovery Conference, Kuala Lumpur, MalaysiaGoogle Scholar
- Li X, Novotny RJ (2006) Study on cement displacement by Lattice-Boltzmann method. In: SPE-102979-MS, Proceedings of the SPE Annual Technical Conference and Exhibition, San Antonio, Texas, USAGoogle Scholar
- Liu Y (2011) Exact solutions to nonlinear Schrödinger equation with variable coefficients. Appl Math Comput 217(12):5866–5869Google Scholar
- Shiran BS, Skauge A (2015) Wettability and oil recovery by polymer and polymer particles. In: SPE-174568-MS, Proceedings of the SPE Asia Pacific Enhanced Oil Recovery Conference, Kuala Lumpur, MalaysiaGoogle Scholar
- Tetteh JT, Rankey E, Barati R (2017) Low salinity waterflooding effect: Crude oil/brine interactions as a recovery mechanism in carbonate rocks. In: OTC-28023-MS, Proceedings of the Offshore Technology Conference Brasil, Rio de Janeiro, BrazilGoogle Scholar
- Wang D, Cheng J, Yang Q, Guo W, Li Q, Chen F (2000) Visco-elastic polymer can increase microscale displacement efficiency in cores. In: SPE-63227-MS, Proceedings of the SPE Annual Technical Conference and Exhibition, Dallas, USAGoogle Scholar
- Zhu Y (2015) Current developments and remaining challenges of chemical flooding EOR techniques in China. In: SPE-174566-MS, Proceedings of the SPE Enhanced Oil Recovery Conference, Kuala Lumpur, MalaysiaGoogle Scholar