Advertisement

Journal of Mechanical Science and Technology

, Volume 32, Issue 11, pp 5493–5500 | Cite as

Experimental study of biomass combustion and separation using vertical cyclone combustor

  • Ahmed Gharib
  • Ibrahim Abdel-Rahman
  • Mohamed Shehata
Article
  • 17 Downloads

Abstract

The present work is devoted to study experimentally the effect of the vortex finder length to the cyclone height ratio (S/H), the air flow rate, and the biomass particles (diameters, feeding flow rates, and type) on the separation efficiency of the cyclone in cold tests. Results from the cold tests were taken as a base of the combustion tests in order to identify the optimum operating conditions. In addition, the combustion characteristics of the cyclone were studied. The experimental results showed that, by increasing the air flow rate, the biomass particles diameter and decreasing the biomass feeding flow rate, the separation efficiency increased. Also, by increasing the vortex finder length to the cyclone height ratio (S/H) the separation efficiency increased for vortex finder ratios greater than 8 % up to 16 % where the separation efficiency reached its maximum value. After that, the separation efficiency started to decrease by further increase of the vortex finder ratio. It is worth stating that, the fine biomass particles gave lower separation efficiency than the coarse particles at whole ranges of feeding flow rates. For all particles diameters, the maximum centerline axial temperatures were obtained at the top of the cyclone. For coarse particles diameters, the centerline axial temperature started to decrease until axial distance of y/D = 3. After that, the centerline axial temperature increased slightly until the exit of the cyclone. For fine particles diameters the centerline axial temperature decreased until the bottom of the cyclone. Finally, the combustion of LPG and biomass fuel mixture revealed higher values of radial temperatures than those obtained from the combustion of the LPG only at the same thermal load.

Keywords

Biomass fuel Cyclone separator Vortex finder Cyclone combustor Separation efficiency 

Preview

Unable to display preview. Download preview PDF.

Unable to display preview. Download preview PDF.

References

  1. [1]
    M. Parikka, Global biomass fuel resources, Biomass and Bioenergy, 27 (9) (2004) 613–620.CrossRefGoogle Scholar
  2. [2]
    M. Peter, Energy production from biomass (part 2): Conversion technologies, Bioresource Technology, 83 (5) (2002) 47–54.Google Scholar
  3. [3]
    C. Syred, W. Fick, A. J. Griffiths and N. Syred, Cyclone gasifier and cyclone combustor for the use of biomass derived gas in the operation of a small gas turbine in cogeneration plants, Fuel, 83 (2004) 2381–2392.CrossRefGoogle Scholar
  4. [4]
    G. B. Sakura and A. Y. T. Leung, Improvements of the cyclone separator performance by down–comer tubes, Journal of Hazardous Materials, 311 (3) (2016) 100–114.Google Scholar
  5. [5]
    K. Elsayed and C. Lacor, The effect of cyclone vortex finder dimensions on the flow pattern and performance using LES, Computers & Fluids, 71 (2013) 224–239.MathSciNetCrossRefzbMATHGoogle Scholar
  6. [6]
    C. H. Alex and E. S. Louis, Gas cyclones and swirl tubes, Second Edition, Springer (2007).Google Scholar
  7. [7]
    R. Hriez, C. Gentric and N. Midoux, Numerical investigation of swirling flow in cylindrical cyclones, Chemical Engineering Research and Design, 89 (15) (2011) 2521–2539.CrossRefGoogle Scholar
  8. [8]
    G. Jolius, S. Y. Thomas, A. Razi and T. G. Chuah, Prediction of dimension, particle, density, temperature and inlet velocity on cyclone collection efficiency, Jurnal Teknologi, 40 (2004) 37–50.Google Scholar
  9. [9]
    S. N. Young, Combustion characteristics of anthracite in a vertical cyclone combustor, KSME Journal, 7 (4) (1993) 295–302.CrossRefGoogle Scholar
  10. [10]
    A. Carneiro, Performance quantification of a cyclonic boiler using biomass, Energy Procedia, 120 (2017) 403–409.CrossRefGoogle Scholar
  11. [11]
    Lima et al., CFD modeling of a small–scale cyclonic combustor chamber using biomass powder, Energy Procedia, 120 (2017) 556–563.CrossRefGoogle Scholar

Copyright information

© The Korean Society of Mechanical Engineers and Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  • Ahmed Gharib
    • 1
  • Ibrahim Abdel-Rahman
    • 1
  • Mohamed Shehata
    • 1
  1. 1.Department of Mechanical Power EngineeringPort Said UniversityPort SaidEgypt

Personalised recommendations