Advertisement

Study on wear and corrosion properties of functionally graded nickel–cobalt–\((\hbox {Al}_{2}\hbox {O}_{3})\) coatings produced by pulse electrodeposition

  • A Karimzadeh
  • M AliofkhazraeiEmail author
  • A S Rouhaghdam
Article
  • 89 Downloads

Abstract

Functionally graded nickel–cobalt coatings with/without alumina nanoparticles were pulse electrodeposited on a carbon steel substrate by a continuous decrease in duty cycle from 95 to 10% at different frequencies of 100, 500 and 1000 Hz. The effect of pulse parameters on the nanoparticle content, chemical composition, microstructure, corrosion properties and tribological behaviour of coatings was studied. Energy-dispersive X-ray spectroscopy analysis showed that the amount of cobalt is gradually reduced and the content of alumina nanoparticles is increased from the substrate/coating interface to the surface. Based on the electrochemical studies in 3.5 wt% NaCl, the nanocomposite coatings gain the highest corrosion resistance at the lowest frequency. Also, the hardness of coatings gradually increased. Evaluation of the tribological behaviour of coatings by a pin-on-disk wear test showed that the nanoparticles have a positive effect on wear resistance and improve it by increasing frequency.

Keywords

Nickel–cobalt nanoparticles gradient coatings corrosion wear 

References

  1. 1.
    Narayanan T, Shaijumon M, Ajayan P and Anantharaman M 2010 Nanoscale Res. Lett. 5 164CrossRefGoogle Scholar
  2. 2.
    Shi L, Sun C, Gao P, Zhou F and Liu W 2006 Appl. Surf. Sci. 252 3591CrossRefGoogle Scholar
  3. 3.
    Chi B, Li J, Yang X, Gong Y and Wang N 2005 Int. J. Hydrogen Energy 30 29CrossRefGoogle Scholar
  4. 4.
    Oriňáková R, Turoňová A, Kladeková D, Gálová M and Smith R M 2006 J. Appl. Electrochem. 36 957CrossRefGoogle Scholar
  5. 5.
    Kim D, Park D-Y, Yoo B, Sumodjo P and Myung N 2003 Electrochim. Acta 48 819CrossRefGoogle Scholar
  6. 6.
    Li Y, Tao Y, Ke D, Ma Y and Han S 2015 Appl. Surf. Sci. 357 1714CrossRefGoogle Scholar
  7. 7.
    Tian L, Xu J and Qiang C 2011 Appl. Surf. Sci. 257 4689CrossRefGoogle Scholar
  8. 8.
    Farzaneh M, Zamanzad-Ghavidel M, Raeissi K, Golozar M, Saatchi A and Kabi S 2011 Appl. Surf. Sci. 257 5919CrossRefGoogle Scholar
  9. 9.
    El-Feky H, Negem M, Roy S, Helal N and Baraka A 2013 Sci. China Chem. 56 1446CrossRefGoogle Scholar
  10. 10.
    Li Y, Jiang H, Wang D and Ge H 2008 Surf. Coat. Technol. 202 4952CrossRefGoogle Scholar
  11. 11.
    Wang L, Gao Y, Xue Q, Liu H and Xu T 2005 Appl. Surf. Sci. 242 326CrossRefGoogle Scholar
  12. 12.
    Zamani M, Amadeh A and Baghal S L 2016 Trans. Nonferrous Met. Soc. China 26 484CrossRefGoogle Scholar
  13. 13.
    Dai P, Zhong Y and Zhou X 2011 Surf. Eng. 27 71CrossRefGoogle Scholar
  14. 14.
    Tian B and Cheng Y 2007 Electrochim. Acta 53 511CrossRefGoogle Scholar
  15. 15.
    Yang Y and Cheng Y 2011 Surf. Coat. Technol. 205 3198CrossRefGoogle Scholar
  16. 16.
    Vijayakumar J, Mohan S, Kumar S A, Suseendiran S and Pavithra S 2013 Int. J. Hydrogen Energy 38 10208CrossRefGoogle Scholar
  17. 17.
    Yang Y and Cheng Y 2013 Surf. Coat. Technol. 216 282CrossRefGoogle Scholar
  18. 18.
    Chen L, Wang L, Zeng Z and Zhang J 2006 Mater. Sci. Eng. A 434 319CrossRefGoogle Scholar
  19. 19.
    Chen W, Tu J, Gan H, Xu Z, Wang Q, Lee J et al 2002 Surf. Coat. Technol. 160 68CrossRefGoogle Scholar
  20. 20.
    Wang Y, Tay S L, Wei S, Xiong C, Gao W, Shakoor R et al 2015 J. Alloys Compd. 649 222CrossRefGoogle Scholar
  21. 21.
    Harsha S, Dwivedi D and Agrawal A 2007 Surf. Coat. Technol. 201 5766CrossRefGoogle Scholar
  22. 22.
    Vazquez-Arenas J, Treeratanaphitak T and Pritzker M 2012 Electrochim. Acta 62 63CrossRefGoogle Scholar
  23. 23.
    Vazquez-Arenas J, Altamirano-Garcia L, Treeratanaphitak T, Pritzker M, Luna-Sánchez R and Cabrera-Sierra R 2012 Electrochim. Acta 65 234CrossRefGoogle Scholar
  24. 24.
    Tury B, Radnóczi G, Radnóczi G and Varsányi M 2007 Surf. Coat. Technol. 202 331CrossRefGoogle Scholar
  25. 25.
    Chang L, An M and Shi S 2005 Mater. Chem. Phys. 94 125CrossRefGoogle Scholar
  26. 26.
    Wang L, Gao Y, Xue Q, Liu H and Xu T 2005 J. Phys. D: Appl. Phys. 38 1318CrossRefGoogle Scholar
  27. 27.
    Bostani B, Parvini Ahmadi N and Yazdani S 2016 Surf. Eng. 32 495CrossRefGoogle Scholar
  28. 28.
    Orlovskaja L, Periene N, Kurtinaitiene M and Bikulčius G 1998 Surf. Coat. Technol. 105 8CrossRefGoogle Scholar
  29. 29.
    Hou K, Ger M, Wang L and Ke S 2002 Wear 253 994CrossRefGoogle Scholar
  30. 30.
    Baghal S L, Sohi M H and Amadeh A 2012 Surf. Coat. Technol. 206 4032CrossRefGoogle Scholar
  31. 31.
    Lajevardi S, Shahrabi T, Szpunar J, Rouhaghdam A S and Sanjabi S 2013 Surf. Coat. Technol. 232 851CrossRefGoogle Scholar
  32. 32.
    García-Lecina E, García-Urrutia I, Díez J, Salvo M, Smeacetto F, Gautier G et al 2009 Electrochim. Acta 54 2556CrossRefGoogle Scholar
  33. 33.
    Dong Y, Lin P and Wang H 2006 Surf. Coat. Technol. 200 3633CrossRefGoogle Scholar
  34. 34.
    Wang H, Yao S and Matsumura S 2004 J. Mater. Process. Technol. 145 299CrossRefGoogle Scholar
  35. 35.
    Torabinejad V, Aliofkhazraei M, Rouhaghdam A S and Allahyarzadeh M 2017 Wear 380 115CrossRefGoogle Scholar
  36. 36.
    Allahyarzadeh M, Aliofkhazraei M, Rouhaghdam A S and Torabinejad V 2017 J. Alloys Compd. 705 788CrossRefGoogle Scholar
  37. 37.
    Majidi H, Aliofkhazraei M, Karimzadeh A and Rouhaghdam A S 2017 Can. Metall. Q 56 179CrossRefGoogle Scholar
  38. 38.
    Torabinejad V, Rouhaghdam A S, Aliofkhazraei M and Allahyarzadeh M 2016 J. Alloys Compd. 657 526CrossRefGoogle Scholar
  39. 39.
    Allahyarzadeh M, Aliofkhazraei M, Rouhaghdam A S and Torabinejad V 2017 Surf. Eng. 33 327CrossRefGoogle Scholar
  40. 40.
    Baghal S L, Amadeh A, Sohi M H and Hadavi S 2013 Mater. Sci. Eng. A 559 583CrossRefGoogle Scholar
  41. 41.
    Ma E 2003 Scr. Mater. 49 663CrossRefGoogle Scholar
  42. 42.
    Qin L, Lian J and Jiang Q 2010 J. Alloys Compd. 504 S439CrossRefGoogle Scholar
  43. 43.
    Cavaliere P 2008 Comput. Mater. Sci. 41 440CrossRefGoogle Scholar
  44. 44.
    Allahyarzadeh M, Aliofkhazraei M, Rouhaghdam A S and Torabinejad V 2016 J. Alloys Compd. 666 217CrossRefGoogle Scholar
  45. 45.
    Chang L, Liu W, Duan X and Xu J 2012 Surf. Eng. 28 725CrossRefGoogle Scholar
  46. 46.
    Hammami O, Dhouibi L, Berçot P and Rezrazi E M 2014J. Appl. Electrochem. 44 115CrossRefGoogle Scholar
  47. 47.
    Ghazanlou S I, Farhood A, Hosouli S, Ahmadiyeh S and Rasooli A 2017 J. Mater. Sci.: Mater. Electron. 28 1Google Scholar
  48. 48.
    Boonyongmaneerat Y, Saengkiettiyut K, Saenapitak S and Sangsuk S 2014 J. Mater. Eng. Perform. 23 302CrossRefGoogle Scholar
  49. 49.
    Lajevardi S, Shahrabi T and Szpunar J 2013 Appl. Surf. Sci. 279 180CrossRefGoogle Scholar
  50. 50.
    Bahrololoom M and Sani R 2005 Surf. Coat. Technol. 192 154CrossRefGoogle Scholar
  51. 51.
    Thiemig D, Lange R and Bund A 2007 Electrochim. Acta 52 7362CrossRefGoogle Scholar
  52. 52.
    Chen L, Wang L, Zeng Z and Xu T 2006 Surf. Coat. Technol. 201 599CrossRefGoogle Scholar
  53. 53.
    Guglielmi N 1972 J. Electrochem. Soc. 119 1009CrossRefGoogle Scholar
  54. 54.
    Ghazanlou S I, Ahmadiyeh S and Yavari R 2017 Surf. Eng. 33 337CrossRefGoogle Scholar
  55. 55.
    Goldasteh H and Rastegari S 2014 Surf. Coat. Technol. 259 393CrossRefGoogle Scholar
  56. 56.
    Feng Q, Li T, Teng H, Zhang X, Zhang Y, Liu C et al 2008 Surf. Coat. Technol. 202 4137CrossRefGoogle Scholar
  57. 57.
    Gupta R, Das A, Nagahanumaiah and Henal S 2016 Mater. Manuf. Process. 31 42CrossRefGoogle Scholar
  58. 58.
    Rezaeiolum A, Aliofkhazraei M, Karimzadeh A, Rouhaghdam A and Miresmaeili R 2017 Surf. Eng. 34 1Google Scholar
  59. 59.
    Soleimani R, Mahboubi F, Kazemi M and Arman S 2015 Surf. Eng. 31 714CrossRefGoogle Scholar
  60. 60.
    Sajjadnejad M, Omidvar H, Javanbakht M, Pooladi R and Mozafari A 2014 Trans. IMF 92 227CrossRefGoogle Scholar
  61. 61.
    Sharma G, Yadava R and Sharma V 2006 Bull. Mater. Sci. 29 491CrossRefGoogle Scholar
  62. 62.
    Torabinejad V, Aliofkhazraei M, Rouhaghdam A S and Allahyarzadeh M 2016 J. Mater. Eng. Perform. 25 5494CrossRefGoogle Scholar
  63. 63.
    Torabinejad V, Aliofkhazraei M, Rouhaghdam A S and Allahyarzadeh M 2017 Tribol. Trans. 60 923CrossRefGoogle Scholar
  64. 64.
    Mishra R, Basu B and Balasubramaniam R 2004 Mater. Sci. Eng. A 373 370CrossRefGoogle Scholar
  65. 65.
    Jeong D, Gonzalez F, Palumbo G, Aust K and Erb U 2001 Scr. Mater. 44 493CrossRefGoogle Scholar
  66. 66.
    Hanlon T, Chokshi A, Manoharan M and Suresh S 2005 Int. J. Fatigue 27 1159CrossRefGoogle Scholar
  67. 67.
    Ramezanalizadeh H, Emamy M and Shokouhimehr M 2016 Tribol. Trans. 59 219CrossRefGoogle Scholar

Copyright information

© Indian Academy of Sciences 2019

Authors and Affiliations

  • A Karimzadeh
    • 1
  • M Aliofkhazraei
    • 1
    Email author
  • A S Rouhaghdam
    • 1
  1. 1.Department of Materials Engineering, Faculty of EngineeringTarbiat Modares UniversityTehranIran

Personalised recommendations