Advertisement

Journal of Central South University

, Volume 25, Issue 12, pp 3021–3032 | Cite as

Effects of initial bubble size on geometric and motion characteristics of bubble released in water

  • Can Kang (康灿)Email author
  • Wei Zhang (张伟)
  • Zi-wen Zou (邹子文)
  • Chun-bo Pang (庞春波)
Article
  • 5 Downloads

Abstract

To seek and describe the influence of bubble size on geometric and motion characteristics of the bubble, six nozzles with different outlet diameters were selected to inject air into water and to produce different bubble sizes. High-speed photography in conjunction with an in-house bubble image processing code was used. During the evolution of the bubble, bubble shape, traveling trajectory and the variation of bubble velocity were obtained. Bubble sizes acquired varied from 0.25 to 8.69 mm. The results show that after the bubble is separated from the nozzle, bubble shape sequentially experiences ellipsoidal shape, hat shape, mushroom shape and eventually the stable ellipsoidal shape. As the bubble size increases, the oscillation of the bubble surface is intensified. At the stabilization stage of bubble motion, bubble trajectories conform approximately to the sinusoidal function. Meanwhile, with the increase in bubble size, the bubble trajectory tends to be straightened and the influence of the horizontal bubble velocity component on the bubble trajectory attenuates. The present results explain the phenomena related to relatively large bubble size, which extends the existing relationship between the bubble terminal velocity and the equivalent bubble diameter.

Key words

bubble size nozzle diameter bubble deformation aspect ratio bubble terminal velocity 

初始尺寸对气泡在水中的几何和运动特征的影响

摘要

为了探究和描述气泡尺寸对气泡的几何形态及运动学特征的影响,使用6 种不同直径的喷嘴采 用向水中通气的方法产生了不同尺寸的气泡,采用高速摄像系统对气泡图像进行采集,并结合专门开 发的软件分析了气泡发展过程中的形状、运动轨迹和速度的变化。实验过程中获得的气泡尺寸范围为 0.25~8.69 mm。结果表明,气泡脱离喷嘴后,气泡形态依次经由椭球形、球帽形、蘑菇形,最终转变 为稳定的椭球形。随着气泡尺寸的增大,气泡表面的波动加剧。在气泡运动的稳定阶段,气泡的轨迹 可近似用正弦曲线来描述。同时,随着气泡尺寸的增大,气泡轨迹有被拉直的趋势,横向分速度对气 泡轨迹的影响减弱。研究结果解释了与大尺寸气泡相关的现象,拓展了已发表的气泡终速度与气泡当 量直径之间的关系。

关键词

气泡尺寸 喷嘴直径 气泡变形 纵横比 气泡终速度 

Preview

Unable to display preview. Download preview PDF.

Unable to display preview. Download preview PDF.

References

  1. [1]
    SRINOI P, SATO K. Controllable air-bubbles size generator performance with swirl flow [J]. Engineering, Technology & Applied Science Research, 2015, 8(4): 245–249.Google Scholar
  2. [2]
    ONOE K, WADA Y, MATSUMOTO M. Fascination and engineering application of reaction field utilizing fine bubbles [J]. Japanese Journal of Multiphase Flow, 2016, 30(1): 27–36.CrossRefGoogle Scholar
  3. [3]
    NAGAMI Y, SAITO T. An experimental study of the modulation of the bubble motion by gas–liquid-phase interaction in oscillating-grid decaying turbulence [J]. Flow, Turbulence and Combustion, 2014, 92(1): 147–174.CrossRefGoogle Scholar
  4. [4]
    SINGH K K, GEBAUER F, BART H J. Bouncing of a bubble at a liquid-liquid interface [J]. AIChE Journal, 2017, 63(7): 3150–3157.CrossRefGoogle Scholar
  5. [5]
    SCHWARZ S, FRÖHLICH J. Numerical study of single bubble motion in liquid metal exposed to a longitudinal magnetic field [J]. International Journal of Multiphase Flow, 2014, 62(2): 134–151.CrossRefGoogle Scholar
  6. [6]
    LI Shao, YAN Zheng, LI Run, WANG Lei, LUAN Jing. Numerical simulation of single bubble rising in shear-thinning fluids by level set method [J]. Journal of Central South University, 2016, 23: 1000–1006.CrossRefGoogle Scholar
  7. [7]
    BÖHM L, BREHMER M, KRAUME M. Comparison of the single bubble ascent in a Newtonian and a non-Newtonian liquid: A phenomenological PIV study [J]. Chemie Ingenieur Technik, 2015, 88: 1–2.Google Scholar
  8. [8]
    YOSHIDA K, MORIOKA S, KAGAWA Y. Power-law dependence describing subharmonic generation from a non-spherically oscillating bubble [J]. Acoustical Science and Technology, 2015, 36(3): 191–200.CrossRefGoogle Scholar
  9. [9]
    LIU L, YAN H, ZHAO G, ZHANG J. Experimental studies on the terminal velocity of air bubbles in water and glycerol aqueous solution [J]. Experimental Thermal and Fluid Science, 2016, 78: 254–265.CrossRefGoogle Scholar
  10. [10]
    OKAMOTO R, ONUKI A. Bubble formation in water with addition of a hydrophobic solute [J]. The European Physical Journal E, 2015, 38: 72. DOI: https://doi.org/10.1140/epje/i2015-15072–9.CrossRefGoogle Scholar
  11. [11]
    ZAWALA J, WIERTEL A, NIECIKOWSKA A, MALYSA K. Influence of external vibrations on bubble coalescence time at water and oil surfaces—Experiments and modelling [J]. Colloids and Surfaces A, 2017, 519: 137–145.CrossRefGoogle Scholar
  12. [12]
    ORTIZ-VILLAFUERTE J, SCHEMIDL W D, HASSAN Y A. Three-dimensional PIV measurements of bubble drag and lift coefficients in restricted media [J]. Revista Mexicana de Física, 2013, 59: 444–452.Google Scholar
  13. [13]
    QUINN J J, MALDONADO M, GOMEZ C O, FINCH J A. Experimental study on the shape–velocity relationship of an ellipsoidal bubble in inorganic salt solutions [J]. Minerals Engineering, 2014, 55(1): 5–10.CrossRefGoogle Scholar
  14. [14]
    XIN Z, DONG H, DI B, KOIDE T. Effect of small amount of water on CO2 bubble behavior in ionic liquid systems [J]. Industrial and Engineering Chemistry Research, 2014, 53(1): 428–439.CrossRefGoogle Scholar
  15. [15]
    LAQUA K, MALONE K, HOFFMANN M, KRAUSE D, SCHLÜTER M. Methane bubble rise velocities under deep-sea conditions-influence of initial shape deformation [J]. Colloids and Surfaces A, 2016, 505: 106–117.CrossRefGoogle Scholar
  16. [16]
    CELATA G P, CUMO M, D’ANNIBALE F, MARCO P D, TOMIYAMA A, ZOVINI C. Effect of gas injection mode and purity of liquid on bubble rising in two-component systems [J]. Experimental Thermal and Fluid Science, 2006, 31(1): 37–53.CrossRefGoogle Scholar
  17. [17]
    KANG Can, ZHANG Wei, GU Yi, MA Ning. Bubble size and flow characteristics of bubbly flow downstream of a ventilated cylinder [J]. Chemical Engineering Research and Design, 2017, 122: 263–272.CrossRefGoogle Scholar
  18. [18]
    ZHANG Wei, NESSET J E, FINCH J A. A novel approach to prevent bubble coalescence during measurement of bubble size in flotation [J]. Journal of Central South University, 2014, 21: 338–343.CrossRefGoogle Scholar
  19. [19]
    DEHAECK S, PARYS H V, HUBIN A, BEECK J P A J V. Laser marked shadowgraphy: A novel optical planar technique for the study of microbubbles and droplets [J]. Experiments in Fluids, 2009, 47: 333–341.CrossRefGoogle Scholar
  20. [20]
    ZHANG A M, CUI P, CUI J, WANG Q. Experimental study on bubble dynamics subject to buoyancy [J]. Journal of Fluid Mechanics, 2015, 776: 137–160.CrossRefGoogle Scholar
  21. [21]
    TOMIYAMA A, KATAOKA I, ZUN I, SAKAGUCHI T. Drag coefficients of single bubbles under normal and micro gravity conditions [J]. JSME International Journal Series B, 1998, 41(2): 472–479.CrossRefGoogle Scholar
  22. [22]
    MENDELSON H D. The prediction of bubble terminal velocities from wave theory [J]. AIChE Journal, 2010, 13(2): 250–253.CrossRefGoogle Scholar

Copyright information

© Central South University Press and Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  1. 1.School of Energy and Power EngineeringJiangsu UniversityZhenjiangChina

Personalised recommendations