Advertisement

An overview of technologies to recover phosphorus as struvite from wastewater: advantages and shortcomings

  • Shayok GhoshEmail author
  • Sergey Lobanov
  • Victor K. Lo
Review Article
  • 10 Downloads

Abstract

Phosphorus (P) is a significant limiting nutrient which is essential for all forms of lives. However, phosphate rock reserves are depleting rapidly due to population growth. At the same time, several countries have imposed legislative regulations on P-release into surface waters due to eutrophication. Nutrient recovery from wastewater can facilitate a sustainable, cost-effective and environment-friendly source of phosphorus. Although P-recovery as struvite from wastewater has been widely studied for a long time, there still exists a lot of challenges for widespread full-scale implementation. This paper presents a comprehensive analysis of the current state of the technologies for phosphorus recovery in the form of struvite. Fluidized bed reactors (FBRs) are widely used compared to continuously stirred reactors for P-recovery as struvite because of different solid and liquid retention time. Commercially available technologies were reported to accomplish about 80% P-removal efficiencies with a reasonable P-recovery for the most of the cases. The struvite production rate of various technologies varies from 0.89 to 13.7 kg/kg influent P. Nevertheless, these technologies are associated with several shortcomings such as high operational costs, high energy consumption, and large footprint. Increasing efforts focusing on the development of sustainable and commercially feasible technologies are expected in this sector as P-recovery is considered to be the future of wastewater engineering.

Keywords

Wastewater P-removal P-recovery Struvite Fluidized bed reactor (FBR) Continuous stirred tank reactor (CSTR) 

Notes

References

  1. Abarca RRM, Pusta RS Jr, Labad RB, et al (2017) Chapter fourteen - effect of upflow velocity on nutrient recovery from swine wastewater by fluidized bed struvite crystallization A2 - Ahuja, Satinder BT - Chemistry and Water. Elsevier, pp 511–518Google Scholar
  2. Abma WR, Driessen W, Haarhuis R, Van Loosdrecht MCM (2010) Upgrading of sewage treatment plant by sustainable and cost-effective separate treatment of industrial wastewater. Water Sci Technol 61:1715–1722.  https://doi.org/10.2166/wst.2010.977 CrossRefGoogle Scholar
  3. Adnan A, Mavinic DS, Koch FA (2003) Pilot-scale study of phosphorus recovery through struvite crystallization — II: applying in-reactor supersaturation ratio as a process control parameter. J Environ Eng Sci 2:473–483.  https://doi.org/10.1139/s03-048 CrossRefGoogle Scholar
  4. Amann A, Zoboli O, Krampe J, Rechberger H, Zessner M, Egle L (2018) Environmental impacts of phosphorus recovery from municipal wastewater. Resour Conserv Recycl 130:127–139.  https://doi.org/10.1016/j.resconrec.2017.11.002 CrossRefGoogle Scholar
  5. Battistoni P, Paci B, Fatone F, Pavan P (2005) Phosphorus removal from supernatants at low concentration using packed and fluidized-bed reactors. Ind Eng Chem Res 44:6701–6707CrossRefGoogle Scholar
  6. Baur R, Prasad R, Britton A (2009) Struvite harvesting to reduce ammonia and phosphorus recycle. In: International conference on nutrient recovery from wastewater streams. IWA Publishing, Vancouver, British Columbia, Canada, pp 351–359Google Scholar
  7. Benisch M, Baur R, Britton A, Neethling JB, Oleszkiewicz JA (2009) Startup of the first commercial phosphorus recycling facility in the US at Durham AWWTP. Proc Water Environ Fed 2009:102–119CrossRefGoogle Scholar
  8. Bergmans B (2011) Struvite recovery from digested sludge. Delft University of Technology, DelftGoogle Scholar
  9. Bowers KE, Westerman PW (2005) Performance of cone-shaped fluidized bed struvite crystallizers in removing phosphorus from wastewater. Trans ASAE 48:1227–1234CrossRefGoogle Scholar
  10. Brans J (2008) Das Schadeinheitenmodell zur Identifikation und Bewertung von Standorten mit schädlichen Bodenveränderungen am Beispiel Industriepark Höchst. Justus-Liebig-Univ.Google Scholar
  11. Brekelmans J (2013) Phosphorus removal in anaerobic effluent by struvite process: ANPHOS Proocess. Colsen Group, BolognaGoogle Scholar
  12. Britton A, Sacluti F, Oldham WK, et al (2007) Value from waste: struvite recovery at the city of Edmontons Gold Bar WWTP. Proc IWA spec Conf Mov Forw - wastewater biosolids sustain. pp 575–581Google Scholar
  13. Britton A, Prasad R, Balzer B, Cubbage L (2009) Pilot testing and economic evaluation of struvite recovery from dewatering centrate at HRSD’s Nansemond WWTP. In: Proceedings of the international conference on nutrient recovery from wastewater streams. pp 193–202Google Scholar
  14. Browers KE (2013) Technology Provider Presentations: Multiform Harvest Inc. In: WEF/IWA nutrient removal and recovery. Workshop a - making sence of extractive nutrient recovery. WEF and IWA, Vancouver, British Columbia, CanadaGoogle Scholar
  15. Cai L, Xiao H-R, Huang S-M, Li H, Zhou GT (2013) Solubilization of magnesium-bearing silicate minerals and the subsequent formation of glushinskite by Aspergillus niger. Geomicrobiol J 30:302–312CrossRefGoogle Scholar
  16. Çelen I, Buchanan JR, Burns RT, Bruce Robinson R, Raj Raman D (2007) Using a chemical equilibrium model to predict amendments required to precipitate phosphorus as struvite in liquid swine manure. Water Res 41:1689–1696CrossRefGoogle Scholar
  17. Cordell D, Drangert J, White S (2009) The story of phosphorus : global food security and food for thought. Glob Environ Chang 19:292–305.  https://doi.org/10.1016/j.gloenvcha.2008.10.009 CrossRefGoogle Scholar
  18. Cornel P, Schaum C (2009) Phosphorus recovery from wastewater: needs, technologies and costs. Water Sci Technol 59:1069–1076.  https://doi.org/10.2166/wst.2009.045 CrossRefGoogle Scholar
  19. Desmidt E, Ghyselbrecht K, Zhang Y, Pinoy L, van der Bruggen B, Verstraete W, Rabaey K, Meesschaert B (2015) Global phosphorus scarcity and full-scale P-recovery techniques: a review. Crit Rev Environ Sci Technol 45:336–384.  https://doi.org/10.1080/10643389.2013.866531 CrossRefGoogle Scholar
  20. Dewaele C (2015) NuReSys – from P recovery to fertilizer production. In: Eurpoean sustainable phosphorus conference. BerlinGoogle Scholar
  21. Dockhorn T (2009) About the economy of phosphorus recovery. In: International conference on nutrient recovery from wastewater streams. IWA Publishing, London, pp 145–158Google Scholar
  22. Doyle JD, Parsons SA (2002) Struvite formation, control and recovery. Water Res 36:3925–3940CrossRefGoogle Scholar
  23. Egle L, Rechberger H, Krampe J, Zessner M (2016) Phosphorus recovery from municipal wastewater : an integrated comparative technological , environmental and economic assessment of P recovery technologies. Sci Total Environ 571:522–542.  https://doi.org/10.1016/j.scitotenv.2016.07.019 CrossRefGoogle Scholar
  24. Fessler E (2013) Crystalactor: struvite recovery. In: nutrients removal and recovery: trends in resource recovery and use. WEF/IWA, Vancouver,BC, CanadaGoogle Scholar
  25. Forster CF (2003) Wastewater treatment and technology. Thomas TelfordGoogle Scholar
  26. Forstner G (2015) AirPrex™: biosolids treatment optimization process with the option of phosphate recovery. In: MWEA -Annual Biosolids Conference. Michigan. USAGoogle Scholar
  27. Gaastra S, Schemen R, Bakker P, Bannink M (1998) Full scale phosphate recovery at sewage treatment plant Geestmerambacht, Holland. In: 1st international conference on phosphorus recovery for recycling, Warwick University, UKGoogle Scholar
  28. González-Muñoz MT, De Linares C, Martínez-Ruiz F et al (2008) Ca–Mg kutnahorite and struvite production by Idiomarina strains at modern seawater salinities. Chemosphere 72:465–472CrossRefGoogle Scholar
  29. Goss T (2016) Struvite , turning a potential maintenance problem into an opportunity. In: NC WEA conference. Raleigh, NC, USAGoogle Scholar
  30. Grini T (2018) Seawater as magnesium source for struvite crystallization in wastewater - an assessment of seawater as an alternative magnesium source of struvite production in wastewater treatment plants. Norwegian University of Science and TechnologyGoogle Scholar
  31. Herzel H, Stemann J, Adam C (2015) P-Recovery Technologies and Products. AmsterdamGoogle Scholar
  32. Howorth C, Wirtel S (2015) Nutrient recovery delivers economic and environmental sustainability , and helps you meet effluent and biosolids nutrient permits. Vancouver,BC, CanadaGoogle Scholar
  33. Huang H (2003) Pilot scale phosphorus recovery from anaerobic digester supernatant. The University of British Columbia, VancouverGoogle Scholar
  34. Jaffer Y, Clark TA, Pearce P, Parsons SA (2002) Potential phosphorus recovery by struvite formation. Water Res 36:1834–1842CrossRefGoogle Scholar
  35. Jeanmaire N, Evans T (2001) Technico-economic feasibility of P-recovery from municipal wastewaters. Environ Technol 22:1355–1361CrossRefGoogle Scholar
  36. Jeyanayagam S, Hahn T, Fergen R, Boltz J (2012) Nutrient recovery , an emerging component of a sustainable biosolids management program. In: Miami. Florida, USAGoogle Scholar
  37. Johnston AE, Steén I (2000) Understanding phosphorus and its use in agriculture. http://www.fertilizerseurope.com/fileadmin/user_upload/publications/agriculture_publications/EFMA_Phosphorus_booklet__2_.pdf. Accessed 5 July 2017
  38. Jones AG (2002) Crystallization process systems, first. Butterworth-Heinemann, OxfordGoogle Scholar
  39. Kabbe C (2015) Nutrient Recovery Developments. WaterWorld 30Google Scholar
  40. Karabegovic L, Uldal M, Werker A, Morgan-Sagastume F (2013) Phosphorus recovery potential from a waste stream with high organic and nutrient contents via struvite precipitation. Environ Technol (United Kingdom) 34:871–883.  https://doi.org/10.1080/09593330.2012.720718 Google Scholar
  41. Karunanithi R, Szogi AA, Bolan N, Naidu R, Loganathan P, Hunt PG, Vanotti MB, Saint CP, Ok YS, Krishnamoorthy S (2015) Phosphorus recovery and reuse from waste streams. In: Advances in agronomy. Elsevier, pp 173–250Google Scholar
  42. Koch FA, Mavinic DS, Yonemitsu N, Britton AT (2009) Fluidized bed wastewater treatment. 2Google Scholar
  43. Krom MD, Ben DA, Ingall ED et al (2014) Bacterially mediated removal of phosphorus and cycling of nitrate and sulfate in the waste stream of a “zero-discharge” recirculating mariculture system. Water Res 56:109–121CrossRefGoogle Scholar
  44. Kumar R, Pal P (2015) Assessing the feasibility of N and P recovery by struvite precipitation from nutrient-rich wastewater: a review. Environ Sci Pollut Res 22:17453–17464.  https://doi.org/10.1007/s11356-015-5450-2 CrossRefGoogle Scholar
  45. Langeveld CP, Ten Wolde KW (2013) Phosphate recycling in mineral fertiliser production. International Fertiliser SocietyGoogle Scholar
  46. Le Corre KS, Valsami-Jones E, Hobbs P, Parsons SA (2009) Phosphorus recovery from wastewater by struvite crystallization: a review. Crit Rev Environ Sci Technol 39:433–477.  https://doi.org/10.1080/10643380701640573 CrossRefGoogle Scholar
  47. Li H, Yao Q-Z, Yu S-H, Huang YR, Chen XD, Fu SQ, Zhou GT (2017) Bacterially mediated morphogenesis of struvite and its implication for phosphorus recovery. Am Mineral 102:381–390CrossRefGoogle Scholar
  48. Li B, Boiarkina I, Yu W, Huang HM, Munir T, Wang GQ, Young BR (2018) Phosphorous recovery through struvite crystallization: challenges for future design. Sci Total Environ 648:1244–1256.  https://doi.org/10.1016/j.scitotenv.2018.07.166 CrossRefGoogle Scholar
  49. Lodder R, Meulenkamp R (2011) Fosfaatterugwinning in communale afvalwaterzuiveringsinstallaties (recuperation of phosphate in communal wastewater treatment plants)Google Scholar
  50. Mangin D, Klein JP (2004) Fluid dynamic concepts for a phosphate precipitation reactor design. Phosphorus Environ Technol Princ Appl London IWA Publ 358–400Google Scholar
  51. Mayer BK, Baker LA, Boyer TH, Drechsel P, Gifford M, Hanjra MA, Parameswaran P, Stoltzfus J, Westerhoff P, Rittmann BE (2016) Total value of phosphorus recovery. Environ Sci Technol 50:6606–6620.  https://doi.org/10.1021/acs.est.6b01239 CrossRefGoogle Scholar
  52. Mihelcic JR, Fry LM, Shaw R (2011) Global potential of phosphorus recovery from human urine and feces. Chemosphere 84:832–839.  https://doi.org/10.1016/j.chemosphere.2011.02.046 CrossRefGoogle Scholar
  53. Moerman W, Carballa M, Vandekerckhove A, Derycke D, Verstraete W (2009) Phosphate removal in agro-industry: pilot- and full-scale operational considerations of struvite crystallization. Water Res 43:1887–1892.  https://doi.org/10.1016/j.watres.2009.02.007 CrossRefGoogle Scholar
  54. Morse GK, Brett SW, Guy JA, Lester JN (1998) Phosphorus removal and recovery technologies. Sci Total Environ 212:69–81.  https://doi.org/10.1016/S0048-9697(97)00332-X CrossRefGoogle Scholar
  55. Mullin JW (2001) Crystallization, Fourth. Butterworth-Heinemann, OxfordGoogle Scholar
  56. Multiform Harvest (2018) Typical Installations — Multiform Harvest. http://www.multiformharvest.com/installations/. Accessed 24 Nov 2018
  57. Munch EV, Barr K (2001) Controlled struvite crystallisation for removing phosphorus from anaerobic digester Sidestreams. Water Res 35:151–159CrossRefGoogle Scholar
  58. Nawa Y (2009) P-recovery in Japan-the PHOSNIX process. In: BALTIC 21-Phosphorus Recycling and Good Agricultural Management Practice Symposium. Berlin, GermanyGoogle Scholar
  59. Nieminen J (2010) Phosphorus recovery and recycling from municipal wastewater sludge. Aalto UniversityGoogle Scholar
  60. NuReSys (2016) NuReSys: recovers natures essentials. http://www.nuresys.be/. Accessed 2 Jun 2017
  61. Oleszkiewicz J (2015) Options for improved nutrient removal and recovery from municipal wastwater in the Canadian contextGoogle Scholar
  62. Ostara (2018) Technology - Ostara nutrient recovery. http://ostara.com/nutrient-management-solutions/. Accessed 24 Nov 2018
  63. Paques (2016) PHOSPAQ. http://en.paques.nl/products/other/phospaq. Accessed 17 Jun 2016
  64. Pedemonte DC, Frison N, Tayà C, et al (2016) Chemical and biological processes for nutrients removal and recovery. In: del Río ÁV, Gómez JLC, Corral AM (eds) Technologies for the treatment and recovery of nutrients from industrial wastewater. IGI Global, pp 76–111Google Scholar
  65. Peng L, Dai H, Wu Y, Peng Y, Lu X (2018a) A comprehensive review of phosphorus recovery from wastewater by crystallization processes. Chemosphere 197:768–781.  https://doi.org/10.1016/j.chemosphere.2018.01.098 CrossRefGoogle Scholar
  66. Peng L, Dai H, Wu Y, Peng Y, Lu X (2018b) A comprehensive review of the available media and approaches for phosphorus recovery from wastewater. Water Air Soil Pollut 229.  https://doi.org/10.1007/s11270-018-3706-4
  67. Picavet M (2013) Phosphorus removal in WWTPs: the ANPHOS process. Colsen Group, HulstGoogle Scholar
  68. Piekema P, Giesen A (2001) Phosphate recovery by the crystallisation process: experience and developments. AL Amersfoort, The NetherlandsGoogle Scholar
  69. P-Rex (2015) AirPrex® struvite crystallization in sludge. http://p-rex.eu/uploads/media/PREX_Factsheet_AIRPREX.pdf. Accessed 17 Jun 2016
  70. Prywer J, Torzewska A (2010) Biomineralization of struvite crystals by Proteus mirabilis from artificial urine and their mesoscopic structure. Cryst Res Technol 45:1283–1289CrossRefGoogle Scholar
  71. Quintana M, Colmenarejo MF, Barrera J, García G, García E, Bustos A (2004) Use of a byproduct of magnesium oxide production to precipitate phosphorus and nitrogen as struvite from wastewater treatment liquors. J Agric Food Chem 52:294–299.  https://doi.org/10.1021/jf0303870 CrossRefGoogle Scholar
  72. Quist-Jensen CA, Jørgensen MK, Christensen ML (2016) Treated seawater as a magnesium source for phosphorous recovery from wastewater—a feasibility and cost analysis. Membranes (Basel) 6.  https://doi.org/10.3390/membranes6040054
  73. Remy M, Driessen W, Hendrickx T, Haarhuis R (2013) Recovery of phosphorus by formation of struvite with the PHOSPAQ process. In: 18th European Biosolids and Organic Resources Conference RECOVERY. Manchester, UKGoogle Scholar
  74. Royal HaskoningDHV (2017) The Crystalactor: efficient treatment without waste. https://www.royalhaskoningdhv.com/en/crystalactor/plants. Accessed 24 Nov 2018
  75. Sartorius C, von Horn J, Tettenborn F (2012) Phosphorus recovery from wastewater—expert survey on present use and future potential. Water Environ Res 84:313–322.  https://doi.org/10.2175/106143012X13347678384440 CrossRefGoogle Scholar
  76. Schipper WJ, Klapwijk A, Potjer B et al (2001) Phosphate recycling in the phosphorus industry. Environ Technol 22:1337–1345.  https://doi.org/10.1080/09593330.2001.9619173 CrossRefGoogle Scholar
  77. Shu L, Schneider P, Jegatheesan V, Johnson J (2006) An economic evaluation of phosphorus recovery as struvite from digester supernatant. Bioresour Technol 97:2211–2216.  https://doi.org/10.1016/j.biortech.2005.11.005 CrossRefGoogle Scholar
  78. Sikosana M, Randall DG, Blottnitz H von (2015) A technological, economic and social exploration of phosphate recovery from centralised sewage treatment in a transitioning economy contextGoogle Scholar
  79. Sinha A, Singh A, Kumar S, Khare SK, Ramanan A (2014) Microbial mineralization of struvite: a promising process to overcome phosphate sequestering crisis. Water Res 54:33–43CrossRefGoogle Scholar
  80. Soares A, Veesam M, Simoes F, Wood E, Parsons SA, Stephenson T (2014) Bio-struvite: a new route to recover phosphorus from wastewater. CLEAN–Soil, Air, Water 42:994–997CrossRefGoogle Scholar
  81. Stratful I, Brett S, Scrimshaw MB, Lester JN (1999) Biological phosphorus removal, its role in phosphorus recycling. Environ Technol 20:681–695.  https://doi.org/10.1080/09593332008616863 CrossRefGoogle Scholar
  82. Tarragó E, Puig S, Ruscalleda M, Balaguer MD, Colprim J (2016) Controlling struvite particles’ size using the up-flow velocity. Chem Eng J 302:819–827.  https://doi.org/10.1016/j.cej.2016.06.036 CrossRefGoogle Scholar
  83. Ueno Y (2004) Full scale struvite recovery in Japan. In: Valsami-Jones E (ed) Phosphorus Environ Technol Princ Appl. IWA Publ LondonGoogle Scholar
  84. Ueno Y, Fujii M (2001) Three years experience of operating and selling recovered struvite from full-scale plant. Environ Technol 22:1373–1381.  https://doi.org/10.1080/09593332208618196 CrossRefGoogle Scholar
  85. Valsami-Jones E (2004) Phosphorus in environmental technologies: principles and applications. IWA Publishing, LondonGoogle Scholar
  86. Vaneeckhaute C, Lebuf V, Michels E, Belia E, Vanrolleghem PA, Tack FMG, Meers E (2017) Nutrient recovery from digestate: systematic technology review and product classification. Waste Biomass Valoriz 8:21–40.  https://doi.org/10.1007/s12649-016-9642-x CrossRefGoogle Scholar
  87. Xavier LD, Cammarota MC, Yokoyama L, Volschan I (2014) Study of the recovery of phosphorus from struvite precipitation in supernatant line from anaerobic digesters of sludge. Water Sci Technol Water Supply 14:751–757.  https://doi.org/10.2166/ws.2014.033 CrossRefGoogle Scholar
  88. Ye ZL, Chen SH, Lu M, Shi JW, Lin LF, Wang SM (2011) Recovering phosphorus as struvite from the digested swine wastewater with bittern as a magnesium source. Water Sci Technol 64:334–340.  https://doi.org/10.2166/wst.2011.720 CrossRefGoogle Scholar
  89. Ye X, Ye Z-L, Lou Y, Pan S, Wang X, Wang MK, Chen S (2016) A comprehensive understanding of saturation index and upflow velocity in a pilot-scale fluidized bed reactor for struvite. Powder Technol 295:16–26.  https://doi.org/10.1016/j.powtec.2016.03.022 CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  1. 1.Department of Civil EngineeringThe University of British ColumbiaVancouverCanada
  2. 2.Department of Civil EngineeringEast West UniversityDhakaBangladesh

Personalised recommendations