Advertisement

Enhanced adsorption for Pb(II) and Cd(II) of magnetic rice husk biochar by KMnO4 modification

  • Chen Sun
  • Tong ChenEmail author
  • Qunxing Huang
  • Jun Wang
  • Shengyong Lu
  • Jianhua Yan
Research Article
  • 18 Downloads

Abstract

Novel KMnO4-treated magnetic biochar (FMBC) was successfully synthesized by addition of Fe(NO3)3 during carbonization and KMnO4 treatment following for Pb(II) and Cd(II) adsorption. SEM-EDS, XPS, and ICP-AES were used to evaluate the FMBC and magnetic biochar (FBC) on surface morphology, surface chemistry characteristics, surface functional groups, and Pb(II) and Cd(II) adsorption behavior. Results showed that the Langmuir maximum adsorption quantity of FMBC reached 148 mg/g for Pb(II) and 79 mg/g for Cd(II), nearly 7 times of that of FBC. The enhancement of FMBC for heavy metal adsorption was due to the successful load of manganese oxides and the increased oxygen functional groups consistent with XPS and FTIR results. The adsorption capacities of FMBC were maintained over 95% when the pH value was higher than 2.5 and 3.5 for Pb(II) and Cd(II), respectively. The adsorption performances of both heavy metals by FMBC were hardly influenced by ionic strength and humid acid. The adsorption capacities of FMBC could maintain over 50% and 87% after four cycles for Pb(II) and Cd(II), respectively. The saturation magnetization of FMBC was about 11.5 emu/g, which did not change after adsorption. This work proposed a new method to fabricate a magnetic biochar with high adsorption capacities of heavy metals Pb(II) and Cd(II).

Keywords

Magnetic biochar KMnO4 Pb(II) Cd(II) Adsorption 

Notes

Funding information

This work was supported by The National Key Research and Development Program of China (2016YFD0801104), the Fundamental Research Funds for the Central Universities (No. 2016XZZX002-02, No. 2017FZA4013), National Natural Science Foundation of China (Grant No. 51621005).

Supplementary material

11356_2019_4321_MOESM1_ESM.docx (24 kb)
ESM 1 (DOCX 24 kb)

References

  1. Ahmad M, Rajapaksha AU, Lim JE, Zhang M, Bolan N, Mohan D, Vithanage M, Lee SS, Ok YS (2014) Biochar as a sorbent for contaminant management in soil and water: a review. Chemosphere 99:19–33CrossRefGoogle Scholar
  2. Ahn SY, Eom SY, Rhie YH, Sung YM, Moon CE, Choi GM, Kim DJ (2013) Utilization of wood biomass char in a direct carbon fuel cell (DCFC) system. Appl Energy 105:207–216CrossRefGoogle Scholar
  3. Al-Rashdi BAM, Johnson DJ, Hilal N (2013) Removal of heavy metal ions by nanofiltration. Desalination 315:2–17CrossRefGoogle Scholar
  4. Ayoub A, Venditti RA, Pawlak JJ, Salam A, Hubbe MA (2013) Novel hemicellulose–chitosan biosorbent for water desalination and heavy metal removal. ACS Sustain Chem Eng 1(9):1102–1109CrossRefGoogle Scholar
  5. Cao Y, Huang J, Peng X, Cao D, Galaska A, Qiu S, Liu J, Khan MA, Young DP, Ryu JE, Feng H, Yerra N, Guo Z (2017) Poly(vinylidene fluoride) derived fluorine-doped magnetic carbon nanoadsorbents for enhanced chromium removal. Carbon 115:503–514CrossRefGoogle Scholar
  6. Cui X, Fang S, Yao Y, Li T, Ni Q, Yang X, He Z (2016) Potential mechanisms of cadmium removal from aqueous solution by Canna indica derived biochar. Sci Total Environ 562:517–525CrossRefGoogle Scholar
  7. Da̧browski A, Hubicki Z, Podkościelny P, Robens E (2004) Selective removal of the heavy metal ions from waters and industrial wastewaters by ion-exchange method. Chemosphere 56(2):91–106CrossRefGoogle Scholar
  8. Edathil AA, Shittu I, Hisham Zain J, Banat F, Haija MA (2018) Novel magnetic coffee waste nanocomposite as effective bioadsorbent for Pb(II) removal from aqueous solutions. J Environ Chem Eng 6(2):2390–2400CrossRefGoogle Scholar
  9. Faheem, Yu, H., Liu, J., Shen, J., Sun, X., Li, J., Wang, L. 2016a. Preparation of MnO x -loaded biochar for Pb 2+ removal: adsorption performance and possible mechanism. J Taiwan Inst Chem Eng, 66, 313–320Google Scholar
  10. Faheem YH, Liu J, Shen J, Sun X, Li J, Wang L (2016b) Preparation of MnOx-loaded biochar for Pb2+ removal: adsorption performance and possible mechanism. J Taiwan Inst Chem Eng 66:313–320CrossRefGoogle Scholar
  11. Faria PCC, Orfao JJM, Pereira MFR (2004) Adsorption of anionic and cationic dyes on activated carbons with different surface chemistries. Water Research 38(8):2043–2052CrossRefGoogle Scholar
  12. Goh KH, Lim TT, Dong Z (2008) Application of layered double hydroxides for removal of oxyanions: a review. Water Res 42(6–7):1343–1368CrossRefGoogle Scholar
  13. Han R, Zou W, Zhang Z, Shi J, Yang J (2006) Removal of copper(II) and lead(II) from aqueous solution by manganese oxide coated sand. J Hazard Mater 137(1):384–395CrossRefGoogle Scholar
  14. Han Z, Sani B, Mrozik W, Obst M, Beckingham B, Karapanagioti HK, Werner D (2015) Magnetite impregnation effects on the sorbent properties of activated carbons and biochars. Water Res 70:394–403CrossRefGoogle Scholar
  15. Hao W, Björkman E, Lilliestråle M, Hedin N (2013) Activated carbons prepared from hydrothermally carbonized waste biomass used as adsorbents for CO2. Appl Energy 112:526–532CrossRefGoogle Scholar
  16. Ho YS, Mckay G (1999) Pseudo-second order model for sorption processes. Process Biochem 34(5):451–465CrossRefGoogle Scholar
  17. Hu X-j, Wang J-s, Liu Y-g, Li X, Zeng G-m, Bao Z-l, Zeng X-x, Chen A-w, Long F (2011) Adsorption of chromium (VI) by ethylenediamine-modified cross-linked magnetic chitosan resin: isotherms, kinetics and thermodynamics. J Hazard Mater 185(1):306–314CrossRefGoogle Scholar
  18. Ibrahim M, Hameed AJ, Jalbout A (2008) Molecular spectroscopic study of River Nile sediment in the greater Cairo region. Appl Spectrosc 62(3):306–311CrossRefGoogle Scholar
  19. Jayalakshmi A, Rajesh S, Senthilkumar S, Mohan D (2012) Epoxy functionalized poly(ether-sulfone) incorporated cellulose acetate ultrafiltration membrane for the removal of chromium ions. Sep Purif Technol 90(18):120–132CrossRefGoogle Scholar
  20. Jha, M.K., Kumar, V., Jeong, J., Lee, J.-c. 2012. Review on solvent extraction of cadmium from various solutions. Hydrometallurgy, 111, 1–9Google Scholar
  21. Jiménez-Cedillo MJ, Olguín MT, Fall C, Colin-Cruz A (2013) As(III) and as(V) sorption on iron-modified non-pyrolyzed and pyrolyzed biomass from Petroselinum crispum (parsley). J Environ Manag 117:242–252CrossRefGoogle Scholar
  22. Karunanayake AG, Todd OA, Crowley M, Ricchetti L, Pittman CU, Anderson R, Mohan D, Mlsna T (2018) Lead and cadmium remediation using magnetized and nonmagnetized biochar from Douglas fir. Chem Eng J 331:480–491CrossRefGoogle Scholar
  23. Kastner JR, Miller J, Geller DP, Locklin J, Keith LH, Johnson T (2012) Catalytic esterification of fatty acids using solid acid catalysts generated from biochar and activated carbon. Catal Today 190(1):122–132CrossRefGoogle Scholar
  24. Kavak D (2013) Removal of lead from aqueous solutions by precipitation: statistical analysis and modeling. Desalination Water Treat 51(7–9):1720–1726CrossRefGoogle Scholar
  25. Klüpfel L, Keiluweit M, Kleber M, Sander M (2014) Redox properties of plant biomass-derived black carbon (biochar). Environ Sci Technol 48(10):5601–5611CrossRefGoogle Scholar
  26. Kushwaha JP, Srivastava VC, Mall ID (2010) Organics removal from dairy wastewater by electrochemical treatment and residue disposal. Sep Purif Technol 76(2):198–205CrossRefGoogle Scholar
  27. Lehmann J, Rillig MC, Thies J, Masiello CA, Hockaday WC, Crowley D (2011) Biochar effects on soil biota – a review. Soil Biol Biochem 43(9):1812–1836CrossRefGoogle Scholar
  28. Liu J, Ge X, Ye X, Wang G, Zhang H, Zhou H, Zhang Y, Zhao H (2016) 3D graphene/δ-MnO2 aerogels for highly efficient and reversible removal of heavy metal ions. J Mater Chem A 4(5):1970–1979CrossRefGoogle Scholar
  29. Lu J, Fu F, Ding Z, Li N, Tang B (2017) Removal mechanism of selenite by Fe3O4-precipitated mesoporous magnetic carbon microspheres. J Hazard Mater 330:93–104CrossRefGoogle Scholar
  30. Mohan D, Kumar S, Srivastava A (2014) Fluoride removal from ground water using magnetic and nonmagnetic corn Stover biochars. Ecol Eng 73:798–808CrossRefGoogle Scholar
  31. Mohan D, Singh P, Sarswat A, Steele PH, Pittman CU (2015) Lead sorptive removal using magnetic and nonmagnetic fast pyrolysis energy cane biochars. J Colloid Interface Sci 448:238–250CrossRefGoogle Scholar
  32. O'Reilly SE, Hochella MF (2003) Lead sorption efficiencies of natural and synthetic Mn and Fe-oxides. Geochim Cosmochim Acta 67(23):4471–4487CrossRefGoogle Scholar
  33. O'Reilly SE, Jr MFH (2003) Lead sorption efficiencies of natural and synthetic Mn and Fe-oxides. Geochim Cosmochim Acta 67(23):4471–4487CrossRefGoogle Scholar
  34. Ouyang D, Yan J, Qian L, Chen Y, Han L, Su A, Zhang W, Ni H, Chen M (2017) Degradation of 1,4-dioxane by biochar supported nano magnetite particles activating persulfate. Chemosphere 184:609–617CrossRefGoogle Scholar
  35. Pehlivan E, Yanık BH, Ahmetli G, Pehlivan M (2008) Equilibrium isotherm studies for the uptake of cadmium and lead ions onto sugar beet pulp. Bioresour Technol 99(9):3520–3527CrossRefGoogle Scholar
  36. Polat H, Erdogan D (2007) Heavy metal removal from waste waters by ion flotation. J Hazard Mater 148(1):267–273CrossRefGoogle Scholar
  37. Qiu B, Gu H, Yan X, Guo J, Wang Y, Sun D, Wang Q, Khan M, Zhang X, Weeks BL, Young DP, Guo Z, Wei S (2014) Cellulose derived magnetic mesoporous carbon nanocomposites with enhanced hexavalent chromium removal. J Mater Chem A 2(41):17454–17462CrossRefGoogle Scholar
  38. Rajapaksha AU, Chen SS, Tsang DCW, Zhang M, Vithanage M, Mandal S, Gao B, Bolan NS, Ok YS (2016) Engineered/designer biochar for contaminant removal/immobilization from soil and water: potential and implication of biochar modification. Chemosphere 148:276–291CrossRefGoogle Scholar
  39. Reddy DHK, Lee SM (2014) Magnetic biochar composite: facile synthesis, characterization, and application for heavy metal removal. Colloids & Surfaces A Physicochemical & Engineering Aspects 454(1):96–103CrossRefGoogle Scholar
  40. Sheng G, Wang S, Hu J, Lu Y, Li J, Dong Y, Wang X (2009) Adsorption of Pb(II) on diatomite as affected via aqueous solution chemistry and temperature. Colloids & Surfaces A Physicochemical & Engineering Aspects 339(1):159–166CrossRefGoogle Scholar
  41. Son E-B, Poo K-M, Chang J-S, Chae K-J (2018) Heavy metal removal from aqueous solutions using engineered magnetic biochars derived from waste marine macro-algal biomass. Sci Total Environ 615:161–168CrossRefGoogle Scholar
  42. Song Z, Lian F, Yu Z, Zhu L, Xing B, Qiu W (2014) Synthesis and characterization of a novel MnOx-loaded biochar and its adsorption properties for Cu2+ in aqueous solution. Chem Eng J 242:36–42CrossRefGoogle Scholar
  43. Tan X-f, Liu S-b, Liu Y-g, Gu Y-l, Zeng G-m, Hu X-j, Wang X, Liu S-h, Jiang L-h (2017) Biochar as potential sustainable precursors for activated carbon production: multiple applications in environmental protection and energy storage. Bioresour Technol 227:359–372CrossRefGoogle Scholar
  44. Tan X-f, Liu Y-g, Gu Y-l, Xu Y, Zeng G-m, Hu X-j, Liu S-b, Wang X, Liu S-m, Li J (2016) Biochar-based nano-composites for the decontamination of wastewater: a review. Bioresour Technol 212(Supplement C):318–333CrossRefGoogle Scholar
  45. Tan X, Liu Y, Zeng G, Wang X, Hu X, Gu Y, Yang Z (2015) Application of biochar for the removal of pollutants from aqueous solutions. Chemosphere 125:70–85CrossRefGoogle Scholar
  46. Tang W, Wu X, Li D, Wang Z, Liu G, Liu H, Chen Y (2014) Oxalate route for promoting activity of manganese oxide catalysts in total VOCs' oxidation: effect of calcination temperature and preparation method. J Mater Chem A 2(8):2544–2554CrossRefGoogle Scholar
  47. Tiwari D, Laldanwngliana C, Choi C-H, Lee SM (2011) Manganese-modified natural sand in the remediation of aquatic environment contaminated with heavy metal toxic ions. Chem Eng J 171(3):958–966CrossRefGoogle Scholar
  48. Tripathy SS, Kanungo SB (2005) Adsorption of Co2+, Ni2+, Cu2+ and Zn2+ from 0.5 M NaCl and major ion sea water on a mixture of δ-MnO2 and amorphous FeOOH. J Colloid Interface Sci 284(1):30–38CrossRefGoogle Scholar
  49. Wang H, Gao B, Wang S, Fang J, Xue Y, Yang K (2015a) Removal of Pb(II), cu(II), and cd(II) from aqueous solutions by biochar derived from KMnO4 treated hickory wood. Bioresour Technol 197:356–362CrossRefGoogle Scholar
  50. Wang S, Gao B, Li Y, Mosa A, Zimmerman AR, Ma LQ, Harris WG, Migliaccio KW (2015b) Manganese oxide-modified biochars: preparation, characterization, and sorption of arsenate and lead. Bioresour Technol 181:13–17CrossRefGoogle Scholar
  51. Wang S, Gao B, Zimmerman AR, Li Y, Ma L, Harris WG, Migliaccio KW (2015c) Removal of arsenic by magnetic biochar prepared from pinewood and natural hematite. Bioresour Technol 175:391–395CrossRefGoogle Scholar
  52. Wang Z, Liu G, Zheng H, Li F, Ngo HH, Guo W, Liu C, Chen L, Xing B (2015d) Investigating the mechanisms of biochar’s removal of lead from solution. Bioresour Technol 177:308–317CrossRefGoogle Scholar
  53. Weng S (2016) Fourier transform infrared spectroscopy 3rd edition, 2016.4 Chemical Industry Press, (P 495)Google Scholar
  54. Woolf D, Amonette JE, Street-Perrott FA, Lehmann J, Joseph S (2010) Sustainable biochar to mitigate global climate change. Nat Commun 1:9CrossRefGoogle Scholar
  55. Wu J, Huang D, Liu X, Meng J, Tang C, Xu J (2018) Remediation of as(III) and cd(II) co-contamination and its mechanism in aqueous systems by a novel calcium-based magnetic biochar. J Hazard Mater 348:10–19CrossRefGoogle Scholar
  56. Yeo J, Kim D-h, Bokare AD, Choi W (2012) Photochemical removal of hexavalent chromium through iodide oxidation under 254nm irradiation. Sep Purif Technol 91:18–22CrossRefGoogle Scholar
  57. Zhang C, Shan B, Tang W, Zhu Y (2017a) Comparison of cadmium and lead sorption by Phyllostachys pubescens biochar produced under a low-oxygen pyrolysis atmosphere. Bioresour Technol 238:352–360CrossRefGoogle Scholar
  58. Zhang C, Shan B, Tang W, Zhu Y (2017b) Comparison of cadmium and lead sorption by Phyllostachys pubescens biochar produced under a low-oxygen pyrolysis atmosphere. Bioresour Technol 238:352–360CrossRefGoogle Scholar
  59. Zhang J, Han J, Wang M, Guo R (2017c) Fe3O4/PANI/MnO2 core–shell hybrids as advanced adsorbents for heavy metal ions. J Mater Chem A 5(8):4058–4066CrossRefGoogle Scholar
  60. Zhang S, Dong Q, Zhang L, Xiong Y, Liu X, Zhu S (2015a) Effects of water washing and torrefaction pretreatments on rice husk pyrolysis by microwave heating. Bioresour Technol 193:442–448CrossRefGoogle Scholar
  61. Zhang YJ, Ou JL, Duan ZK, Xing ZJ, Wang Y (2015b) Adsorption of Cr(VI) on bamboo bark-based activated carbon in the absence and presence of humic acid. Colloids & Surfaces A Physicochemical & Engineering Aspects 481:108–116CrossRefGoogle Scholar
  62. Zhao D, Yang X, Zhang H, Chen C, Wang X (2010) Effect of environmental conditions on Pb(II) adsorption on β-MnO2. Chem Eng J 164(1):49–55CrossRefGoogle Scholar
  63. Zhou L, Huang Y, Qiu W, Sun Z, Liu Z, Song Z (2017) Adsorption properties of Nano-MnO2-biochar composites for copper in aqueous solution. Molecules 22(1):173CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  • Chen Sun
    • 1
  • Tong Chen
    • 1
    Email author
  • Qunxing Huang
    • 1
  • Jun Wang
    • 2
  • Shengyong Lu
    • 1
  • Jianhua Yan
    • 1
  1. 1.State Key Laboratory of Clean Energy UtilizationZhejiang UniversityHangzhouChina
  2. 2.Everbright Envirotech (China) Ltd. Institute of Incineration TechnologyNanjingChina

Personalised recommendations