Advertisement

Bioleaching of heavy metals from harbor sediment using sulfur-oxidizing microflora acclimated from native sediment and exogenous soil

  • Chia-Yuan Chang
  • Shen-Yi ChenEmail author
  • Phakchira Klipkhayai
  • Chart Chiemchaisri
Research Article
  • 57 Downloads

Abstract

The harbor sediment containing high concentration of heavy metals may pose serious impacts on the marine ecosystem and environmental quality. The bioleaching process has been considered as an environmentally friendly and cost-effective alternative for removing heavy metals from contaminated sediments. In this study, a series of experiments were performed to investigate the feasibility of bioleaching process for removing heavy metals from the contaminated harbor sediments. The performance of the bioleaching process inoculated with sulfur-oxidizing microflora acclimated from the native harbor sediment was compared with that acclimated from the exogenous soil. In the bioleaching experiment with inoculants from native sediment, the efficiency of Zn, Cu, Cr, Pb, and Ni (30 days) reached 39–100%, 21–94%, 8–63%, 5–74%, and 19–77%, respectively. While 59–100% of Zn, 22–100% of Cu, 0–95% of Cr, 0–100% of Pb, and 22–100% of Ni were respectively removed in the bioleaching experiment with inoculants from exogenous soil after 30 days of reaction time. The results show that the rate and efficiency of metal removal in the bioleaching process decreased with an increase of sediment solid content from 10 to 40 g/L. The efficiency of metal removal in the bioleaching process with inoculants from the native sediment was lower than those from the exogenous soil due to the bacterial activity. By the fractionation of metal in the harbor sediment, exchangeable, carbonate-bound, and Fe/Mn oxide-bound metals (mobile fractions) were found to be apparently reduced and even organic matter/sulfide-bound and residual metals (stable fractions) were slightly removed after the bioleaching experiment.

Keywords

Bioleaching Bioremediation Harbor sediment Heavy metal Inoculants Speciation 

Notes

References

  1. Akinci G, Duyusen EG (2011) Bioleaching of heavy metals contaminated sediment by pure and mixed cultures of Acidithiobacillus spp. Desalination 268:221–226CrossRefGoogle Scholar
  2. APHA (2005) Standard methods for examination of water and wastewater, 21th edn. American Public Health Association, Washington, DCGoogle Scholar
  3. Bond PL, Banfield JF (2001) Design and performance of rRNA targeted oligonucleotide probes for in situ detection and phylogenetic identification of microorganisms inhabiting acid mine drainage environments. Microb Ecol 41:149–161Google Scholar
  4. Bosecker K (1997) Bioleaching: metal solubilization by microorganisms. FEMS Microbiol Rev 20:591–604Google Scholar
  5. Chau JF, Bagtzoglou AC, Willig MR (2011) The effect of soil texture on richness and diversity of bacterial communities. Environ Forensic 12:333–341CrossRefGoogle Scholar
  6. Chen CF, Dong CD, Chen CW (2013) Evaluation of sediment toxicity in Kaohsiung Harbor, Taiwan. Soil Sediment Contam 22:301–314CrossRefGoogle Scholar
  7. Chen CW, Kao CM, Chen CF, Dong CD (2007) Distribution and accumulation of heavy metals in the sediments of Kaohsiung Harbor, Taiwan. Chemosphere 66:1431–1440CrossRefGoogle Scholar
  8. Chen SY, Chen WH (2013) Thermophilic bioleaching of heavy metals from waste sludge using response surface methodology. J Environ Sci Heal A 48:1094–1104CrossRefGoogle Scholar
  9. Chen SY, Chou LC (2016) Relationship between microbial community dynamics and process performance during thermophilic sludge bioleaching. Environ Sci Pollut Res 23:16006–16,014CrossRefGoogle Scholar
  10. Chen SY, Huang QY (2014) Heavy metals recovery from wastewater sludge of printed circuit board industry by thermophilic bioleaching process. J Chem Technol Biotechnol 89:158–164CrossRefGoogle Scholar
  11. Chen SY, Lin JG (2001) Bioleaching of heavy metals from sediment: significance of pH. Chemosphere 44:1093–1102CrossRefGoogle Scholar
  12. Chen SY, Lin JG (2004) Bioleaching of heavy metals from contaminated sediment by indigenous sulfur-oxidizing bacteria in an airlift bioreactor: effects of sulfur concentration. Water Res 38:3205–3214CrossRefGoogle Scholar
  13. Chen SY, Lin JG (2009) Enhancement of metal bioleaching from contaminated sediment using silver ion. J Hazard Mater 161:893–899CrossRefGoogle Scholar
  14. Chen SY, Lin PL (2010) Optimization of operating parameters for the metal bioleaching process of contaminated soil. Sep Purif Technol 71:178–185CrossRefGoogle Scholar
  15. Chen SY, Pan SH (2010) Simultaneous metal leaching and sludge digestion by thermophilic microorganisms: effect of solids content. J Hazard Mater 15:340–347CrossRefGoogle Scholar
  16. Chong N, Karamanev G, Margaritis A (2002) Effect of particle-particle shearing on the bioleaching of sulfide minerals. Biotechnol Bioeng 80:349–357CrossRefGoogle Scholar
  17. Cordoba EM, Munoz JA, Blazquez ML, Gonzalez F, Ballester A (2009) Passivation of chalcopyrite during its chemical leaching with ferric ion at 68oC. Min Eng 22:229–235CrossRefGoogle Scholar
  18. Deng XH, Chai LY, Yang ZH, Shi Y, Tong HX, Wang ZX (2012) Preliminary bioleaching of heavy metals from contaminated soil employing indigenous Penicillium Chrysogenum strain F1. J Cent South Univ 19:1973–1979Google Scholar
  19. Fang D, Zhang R, Zhou L, Li J (2011) A combination of bioleaching and bioprecipitation for deep removal of contaminating metals from dredged sediment. J Hazard Mater 192:226–233Google Scholar
  20. Fedotov PS, Mirò M (2008) Fractionation and mobility of trace elements in soils and sediments. In: Violante A, Huang PM, Gadd GM (eds) Biophysico-chemical processes of heavy metals and metalloids in soil environments, vol 1. John Wiley and Sons, New York, pp 467–520Google Scholar
  21. Fonti V, Dell’Anno A, Beolchini F (2013) Influence of biogeochemical interactions on metal bioleaching performance in contaminated marine sediment. Water Res 47:5139–5152CrossRefGoogle Scholar
  22. Fonti V, Dell’Anno A, Beolchini F (2016) Does bioleaching represent a biotechnological strategy for remediation of contaminated sediments? Sci Total Environ 563:302–319CrossRefGoogle Scholar
  23. Förstner U, Calmano W (1998) Characterization of dredged materials. Water Sci Technol 38:149–157CrossRefGoogle Scholar
  24. Gan M, Jie S, Li M, Zhu J, Liu X (2015) Bioleaching of multiple metals from contaminated sediment by moderate thermophiles. Mar Pollut Bull 97:47–55CrossRefGoogle Scholar
  25. Gee GW, Bauder JM (1986) Partical-size analysis. Methods of soil analysis, part 1, physical and mineralogical methods, agronomy monogroph no. 9, 2nd edn. American Society of Agronomy, Madison, WI, pp 383–411Google Scholar
  26. He ZB, Liao T, Liu YG, Xiao Y, Li TT, Wang H (2012) Influence of sulfur addition/soilds content ratio on metal removal of heavy metals from mine tailings by bioleaching. J Cent South Univ 19:3540–3545CrossRefGoogle Scholar
  27. Ip CCM, Li XD, Zhang G, Wai OWH, Li YS (2007) Trace metal distribution in sediments of the Pearl River Estuary and the surrounding coastal area, South China. Environ Pollut 147:311–323CrossRefGoogle Scholar
  28. Kabala C, Singh BR (2001) Fractionation and mobility of copper, lead, and zinc in soil profiles in the vicinity of a copper smelter. J Environ Qual 30:485–492CrossRefGoogle Scholar
  29. Kumar RN, Nagendran R (2007) Influence of initial pH on bioleaching of heavy metals from contaminated soil employing indigenous Acidithiobacillus thiooxidans. Chemosphere 66:1775–1781CrossRefGoogle Scholar
  30. Li X, Mercado R, Kernan T, West AC, Banta S (2014) Addition of citrate to Acidithiobacillus ferrooxidans cultures enables precipitate-free growth at elevated pH and reduces ferric inhibition. Biotechnol Bioeng 111:1940–1948CrossRefGoogle Scholar
  31. Lin JG, Chen CY, Chen SY (1999) Effects of pH on metals specification in contaminated sediment. J Chinese Inst Environ Eng 9:49–56Google Scholar
  32. Liu F, Zhou L, Zhou J, Song X, Wang D (2012) Improvement of sludge dewaterability and removal of sludge-borne metals by bioleaching at optimum pH. J Hazard Mater 221:170–177CrossRefGoogle Scholar
  33. Liu G, Yin J, Cong W (2007) Effect of fluid shear and particles collision on the oxidation of ferrous iron by Acidithiobacillus ferrooxidans. Min Eng 20:1227–1231CrossRefGoogle Scholar
  34. Luna GM, Manini E, Danovaro R (2002) Large fraction of dead and inactive bacteria in coastal marine sediments: comparison of protocols for determination and ecological significance. Appl Environ Microbiol 68:3509–3513CrossRefGoogle Scholar
  35. Meruane G, Vargas T (2003) Bacterial oxidation of ferrous ion by Acidithiobacillus ferrooxidans in the pH range 2.5-7.0. Hydrometallurgy 71:149–158CrossRefGoogle Scholar
  36. Mousavi SM, Yaghmaei S, Vossoughi M, Jafari A, Roostaazad R, Turunen I (2007) Bacterial leaching of low-grade ZnS concentrate using indigenous mesophilic and thermophilic strains. Hydrometallurgy 85:59–65CrossRefGoogle Scholar
  37. Nguyen VK, Lee MH, Park HJ, Lee JU (2015) Bioleaching of arsenic and heavy metals from mine tailings by pure and mixed cultures of Acidithiobacillus spp. J Ind Eng Chem 21:451–458CrossRefGoogle Scholar
  38. Peccia J, Marchand EA, Silverstein J, Hernandez M (2000) Development and application of small-subunit rRNA probes for assessment of selected Thiobacillus species and members of the genus Acidiphilium. Appl Environ Microbiol 66:3065–3072Google Scholar
  39. Petrova E (2012) Assessment of the Influence of Ca2+ and pH on bacterial growth of Acidithiobacillus ferrooxidans. Biotechnol Biotechnol Equip 26:3260–3266CrossRefGoogle Scholar
  40. Pittarello M, Busato JG, Carletti P, Dobbss LB (2017) Possible developments for ex situ phytoremediation of contaminated sediments, in tropical and subtropical regions - review. Chemosphere 182:707–719CrossRefGoogle Scholar
  41. Robertson LA, Kuenen JG (2006) The genus Thiobacillus. In: Dworkin M, Falkow S, Rosenberg E, Scheifer KH, Stackebrandt E (eds) The prokaryotes. Springer, Berlin, pp 812–827CrossRefGoogle Scholar
  42. Sharifi Z, Renella G (2015) Assessment of a particle size fractionation as a technology for reducing heavy metal, salinity and impurities from compost produced by municipal solid waste. Waste Manag 38:95–101CrossRefGoogle Scholar
  43. Styriakova I, Styriak I, Balestrazzi A (2016) Metal leaching and reductive dissolution of iron from contaminated soil and sediment samples by indigenous bacteria and bacillus isolates. Soil Sediment Contam 25:519–535CrossRefGoogle Scholar
  44. Sun SY, Fan SL, Shen KX, Lin S, Nie XQ, Liu MX, Dong FQ, Li J (2017) Laboratory assessment of bioleaching of shallow eutrophic sediment by immobilized photosynthetic bacteria. Environ Sci Pollut Res 24:22143–22151CrossRefGoogle Scholar
  45. Sundareshwar PV, Morris JT (1999) Phosphorus sorption characteristics of intertidal marsh sediments along an estuarine salinity gradient. Limnol Oceanogr 44:1693–1701CrossRefGoogle Scholar
  46. Takeuchi TL, Suzuki I (1997) Cell hydrophobicity and sulfur adhesion of Thiobacillus thiooxidans. Appl Environ Microbiol 63:2058–2061Google Scholar
  47. Treves DS, Xia B, Zhou J, Tiedje JM (2003) A two-species test of the hypothesis that spatial isolation influences microbial diversity in soil. Microb Ecol 45:20–28CrossRefGoogle Scholar
  48. USEPA (2007) Microwave assisted acid digestion of sediments, sludges, soils and oils. Test methods for evaluating solid waste, Method 3051A, USAGoogle Scholar
  49. Villar LD, Garcia O Jr (2006) Effect of anaerobic digestion and initial pH on metal bioleaching from sewage sludge. J Environ Sci Health A 41:211–222CrossRefGoogle Scholar
  50. Vlasceanu L, Popa R, Kinkle BK (1997) Characterization of Thiobacillus thioparus LV43 and its distribution in a chemoautotrophically based groundwater ecosystem. Appl Environ Microbiol 63:3123–3127Google Scholar
  51. Wang B, Yuan X, Han L, Wang X, Zhang L (2015) Release and bioavailability of heavy metals in three typical mafic tailings under the action of Bacillus mucilaginosus and Thiobacillus ferrooxidans. Environ Earth Sci 74:5087–5096CrossRefGoogle Scholar
  52. Wen YM, Wang QP, Tang CX, Chen ZL (2012) Bioleaching of heavy metals from sewage sludge by Acidithiobacillus thiooxidans-a comparative study. J Soils Sediments 12:900–908CrossRefGoogle Scholar
  53. Wu G, Pan L, Wei Q, Guo L (2015) Decreased mobility of heavy metals in Haihe River sediments: the possible role of tide gate. J Geochem Explor 157:92–99CrossRefGoogle Scholar
  54. Xia L, Uribe P, Liu X, Yu C, Chai L, Liu J, Qiu W, Qiu G (2013) Comparison of chalcopyrite bioleaching after different microbial enrichment in shake flasks. World J Microbiol Biotechnol 29:275–280CrossRefGoogle Scholar
  55. Xin B, Jiang W, Aslam H, Zhang K, Liu C, Wang R, Wang Y (2012) Bioleaching of zinc and manganese from spent Zn–Mn batteries and mechanism exploration. Bioresour Technol 106:147–153CrossRefGoogle Scholar
  56. Zeng XF, Wei SH, Sun LN, Jacques DA, Tang JX, Lian MH, Ji ZH, Wang J, Zhu JY, Xu ZX (2015) Bioleaching of heavy metals from contaminated sediments by the Aspergillus niger strain SY1. J Soils Sediments 15:1029–1038CrossRefGoogle Scholar
  57. Zhang P, Zhu Y, Zhang G, Zou S, Zeng G, Wu Z (2009) Sewage sludge bioleaching by indigenous sulfur-oxidizing bacteria: effects of ratio of substrate dosage to solid content. Bioresour Technol 100:1394–1398CrossRefGoogle Scholar
  58. Zhou HB, Zeng WM, Yang ZF, Xie YJ, Qiu GZ (2009) Bioleaching of chalcopyrite concentrate by a moderately thermophilic culture in a stirred tank reactor. Bioresour Technol 100:515–520CrossRefGoogle Scholar
  59. Zhou J, Xia B, Huang H, Palumbo AV, Tiedje JM (2004) Microbial diversity and heterogeneity in sandy subsurface soils. Appl Environ Microbiol 70:1723–1734CrossRefGoogle Scholar
  60. Zhou Q, Gao J, Li Y, Zhu S, He L, Nie W, Zhang R (2017) Bioleaching in bath tests for improving sludge dewaterability and metal removal using Acidithiobacillus ferrooxidans and Acidithiobacillus thiooxidans after cold acclimation. Water Sci Technol 76:1347–1359CrossRefGoogle Scholar
  61. Zhou SG, Zhou LX, Wang SM, Fang D (2006) Removal of Cr from tannery sludge by bioleaching method. J Environ Sci 18:885–890CrossRefGoogle Scholar
  62. Zhu YJ, Zhang XJ, Li Q, Han T, Hu HY, Liu DX, Qin QW, Chai YL, Qiu ZG (2014) Bioleaching of heavy metals from contaminated alkaline sediment by auto- and heterotrophic bacteria in stirred tank reactor. Nonferrous Met Soc China 24:2969–2975CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  • Chia-Yuan Chang
    • 1
  • Shen-Yi Chen
    • 2
    Email author
  • Phakchira Klipkhayai
    • 1
    • 3
  • Chart Chiemchaisri
    • 3
  1. 1.Department of Environmental Engineering and ScienceChia Nan University of Pharmacy and ScienceTainanTaiwan
  2. 2.Department of Safety, Health and Environmental EngineeringNational Kaohsiung University of Science and TechnologyKaohsiungTaiwan
  3. 3.Department of Environmental Engineering, Faculty of EngineeringKasetsart UniversityBangkokThailand

Personalised recommendations