Advertisement

Environmental Science and Pollution Research

, Volume 24, Issue 26, pp 21283–21297 | Cite as

Short-duration hydrothermal fermentation of food waste: preparation of soil conditioner for amending organic-matter-impoverished arable soils

  • Jiaqi Hou
  • Mingxiao LiEmail author
  • Beidou XiEmail author
  • Wenbing Tan
  • Jie Ding
  • Yan Hao
  • Dongming Liu
  • Hongliang Liu
Research Article
  • 316 Downloads

Abstract

Soil conditioners can be used to compensate for the insufficient soil nutrition and organic matter (OM) of arable soils. However, the traditional preparation method for soil conditioners is lengthy and requires facilities that occupy large tracts of land. In this study, a short-duration hydrothermal fermentation (SHF) method was developed for the preparation of soil conditioners from food waste. The SHF method required only 18 h to produce soil conditioners with physicochemical characteristics that were similar to those of soil conditioners obtained through traditional fermentation (TF), which takes 20 days to complete. Inoculation and dynamic SHF significantly affected the distribution of different molecular weight fractions in the prepared soil conditioners. The results of spectral analysis revealed that a large amount of soluble microbial byproducts and carbohydrate C formed in the SHF soil conditioner. This effect indicated that the SHF soil conditioner supplied not only immediately available nutrients, which can stimulate the growth of soil microbial communities, but also provided sustained-release nutrients for the long-term cultivation of crops on OM-impoverished soils. Cyanobacteria were present in the SHF soil conditioner at a relative abundance of 6.29%, which was 28.6 and 314.5 times those in the raw material and TF soil conditioner, respectively. Amending OM-impoverished soil with the SHF soil conditioner enhanced the carbon pool management index of the resulting SHF soil by 1.50 and 1.12 times those of unfertilized soil and TF soil, respectively. These results indicated that the SHF soil exhibited a high capacity to supply nutrients for crop growth.

Keywords

Short-duration hydrothermal fermentation (SHF) Traditional fermentation (TF) Food waste Soil conditioner Carbon pool management index (CPMI) 

Notes

Acknowledgments

This work was supported by the National Natural Science Foundation of China (Grant No. 51408572) and China National Funds for Distinguished Young Scientists (No. 51325804).

References

  1. Ahmad SR, Reynolds DM (1999) Monitoring of water quality using fluorescence technique: prospect of on-line process control. Water Res 33(9):2069–2074CrossRefGoogle Scholar
  2. Aoyama M, Nozawa T (1993) Microbial biomass nitrogen and mineralization-immobilization processes of nitrogen in soils incubated with various organic materials. Soil Science and Plant Nutrition 39(1):23–32CrossRefGoogle Scholar
  3. Benson DR, Silvester WB (1993) Biology of Frankiastrains, actinomycete symbionts of actinorhizal plants. Microbiol Rev 57(2):293–319Google Scholar
  4. Blair GJ, Lefroy RDB, Lisle L (1995) Soil carbon fractions based on their degree of oxidation, and the development of a carbon management index for agricultural systems. Crop and Pasture Science 46(7):1459–1466CrossRefGoogle Scholar
  5. Blair N, Faulkner RD, Till AR, Poulton PR (2006) Long-term management impactions on soil C:N and physical fertility. Part I: Broadbalk experiment. Soil Tillage Res 91(1):30–38CrossRefGoogle Scholar
  6. Bourgoin L-H, Tremblay L (2010) Bacterial reworking of terrigenous and marine organic matter in estuarine water columns and sediments. Geochim Cosmochim Acta 74:5593–5609CrossRefGoogle Scholar
  7. Cha JY, Kim TW, Choi JH, Jang KS, Khaleda L, Kim WY, Jeon JR (2017) Fungal laccase-catalyzed oxidation of naturally occurring phenols for enhanced germination and salt tolerance of Arabidopsis thaliana: a green route for synthesizing humic-like fertilizers. J Agric Food Chem 65(6):1167–1177CrossRefGoogle Scholar
  8. Chen W, Westerhoff P, Leenheer JA, Booksh K (2003) Fluorescence excitation-emission matrix regional integration to quantify spectra for dissolved organic matter. Environmental Science & Technology 37(24):5701–5710CrossRefGoogle Scholar
  9. Chen Y, Yu F, Liang S, Wang Z, Liu Z, Xiong Y (2014) Utilization of solar energy in sewage sludge composting: fertilizer effect and application. Waste Manag 34(11):2014–2021CrossRefGoogle Scholar
  10. Chiew YL, Spångberg J, Baky A, Hansson PA, Jönsson H (2015) Environmental impact of recycling digested food waste as a fertilizer in agriculture—a case study. Resour Conserv Recycl 95:1–14CrossRefGoogle Scholar
  11. Coelho C, Cavani L, Halle AT, Guyot G, Ciavatta C, Richard C (2011) Rates of production of hydroxyl radical and singlet oxygen from irradiated compost. Chemosphere 85:630–636CrossRefGoogle Scholar
  12. Deacon JW (1997) Modern mycology. Blackwell Science, Oxford Chapter 7 Google Scholar
  13. Derrien D, Marol C, Balabane M, Balesdent J (2006) The turnover of carbohydrate carbon in a cultivated soil estimated by 13C natural abundances. Eur J Soil Sci 57(4):547–557CrossRefGoogle Scholar
  14. Diekow J, Mielniczuk J, Knicker H, Bayer C, Dick DP, Kögel-Knabner I (2005) Carbon and nitrogen stocks in physical fractions of a subtropical acrisol as influenced by long term no-till cropping systems and N fertilization. Plant Soil 268:319–328CrossRefGoogle Scholar
  15. Dignac M-F, Bahri H, Rumpel C, Rasse DP, Bardoux G, Balesdent J et al (2005) Carbon-13 natural abundance as a tool to study the dynamics of lignin monomers in soil: an appraisal at the Closeaux experimental field (France). Geoderma 128(1):3–17CrossRefGoogle Scholar
  16. Gabhane J, William SP, Bidyadhar R, Bhilawe P, Anand D, Vaidya AN, Wate SR (2012) Additives aided composting of green waste: effects on organic matter degradation, compost maturity, and quality of the finished compost. Bioresour Technol 114:382–388CrossRefGoogle Scholar
  17. García AC, de Souza LGA, Pereira MG, Castro RN, García-Mina JM, Zonta E, Berbara RLL (2016) Structure-property-function relationship in humic substances to explain the biological activity in plants. Sci Rep 6:20798CrossRefGoogle Scholar
  18. Gelaw AM, Singh BR, Lal R (2014) Soil organic carbon and total nitrogen stocks under different land uses in a semi-arid watershed in Tigray, Northern Ethiopia. Agric Ecosyst Environ 188(15):256–263CrossRefGoogle Scholar
  19. Gonzales HB, Sakashita H, Nakano Y, Nishijma W, Okada M (2010) Food waste mineralization and accumulation in biological solubilization and composting process. Chemosphere 79:238–241CrossRefGoogle Scholar
  20. González-Fernández C, Ballesteros M (2012) Linking microalgae and cyanobacteria culture conditions and key-enzymes for carbohydrate accumulation. Biotechnol Adv 30(6):1655–1661CrossRefGoogle Scholar
  21. He L, Huang GH, Lu H (2011) Greenhouse gas emissions control in integrated waste management through mixed integer bilevel decision-making. J Hazard Mater 193:112–119CrossRefGoogle Scholar
  22. He XS, Xi BD, Li X, Pan HW, An D, Bai SG, Cui DY (2013) Fluorescence excitation–emission matrix spectra coupled with parallel factor and regional integration analysis to characterize organic matter humification. Chemosphere 93(9):2208–2215Google Scholar
  23. He XS, Xi BD, Gao RT, Zhang H, Dang QL, Li D, Huang CH (2016) Insight into the composition and degradation potential of dissolved organic matter with different hydrophobicity in landfill leachates. Chemosphere 144:75–80CrossRefGoogle Scholar
  24. Institute of Soil Science, Chinese Academy of Sciences (ISSCAS) (1978) Soil physical and chemical analysis, vol 62. Shanghai Science and Technology Press, Shanghai, p 132 (in Chinese) Google Scholar
  25. Jaiswal P, Prasanna R, Nayak S, Sood A, Suseela MR (2008) Characterization of rhizo-cyanobacteria and their associations with wheat seedlings. Egypt J Biol 10:20–27Google Scholar
  26. Jiang Y, Ju M, Li W, Ren Q, Liu L, Chen Y, Yang Q, Hou Q, Liu Y (2015) Rapid production of organic fertilizer by dynamic high-temperature aerobic fermentation (DHAF) of food waste. Bioresour Technol 197:7–14CrossRefGoogle Scholar
  27. Jindo K, Martim SA, Navarro EC, Pérez-Alfocea F, Hernandez T, Garcia C, Aguiar NO, Canellas LP (2012) Root growth promotion by humic acids from composted and non-composted urban organic wastes. Plant Soil 353(1–2):209–220CrossRefGoogle Scholar
  28. Karthikeyan N, Prasanna R, Sood A, Jaiswal P, Nayak S, Kaushik BD (2009) Physiological characterization and electron microscopic investigations of cyanobacteria associated with wheat rhizosphere. Folia Microbiol 54:43–51CrossRefGoogle Scholar
  29. Kim MH, Kim JW (2010) Comparison through a LCA evaluation analysis of food waste disposal options from the perspective of global warming and resource recovery. Sci Total Environ 408(19):3998–4006CrossRefGoogle Scholar
  30. Kuo W-C, Cheng K-Y (2007) Use of respirometer in evaluation of process and toxicity of thermophilic anaerobic digestion for treating kitchen waste. Bioresour Technol 98(9):1805–1811CrossRefGoogle Scholar
  31. Lai ZY, Ma XQ, Tang YT, Lin H (2011) A study on municipal solid waste (MSW) combustion in N2/O2 and CO2/O2 atmosphere from the perspective of TGA. Energy 36(2):819–824CrossRefGoogle Scholar
  32. Lashermes G, Barriuso E, Houot S (2012) Dissipation pathways of organic pollutants during the composting of organic wastes. Chemosphere 87:137–143CrossRefGoogle Scholar
  33. Li Z, Lu H, Ren L, He L (2013) Experimental and modeling approaches for food waste composting: a review. Chemosphere 93(7):1247–1257CrossRefGoogle Scholar
  34. Lin C (2008) A negative-pressure aeration system for composting food waste. Bioresour Technol 99:7651–7656CrossRefGoogle Scholar
  35. Lu YJ, Wu XW, Guo JF (2009) Characteristics of municipal solid waste and sewage sludge co-composting. Waste Manag 29:1152–1157CrossRefGoogle Scholar
  36. Lv B, Xing M, Yang J, Qi W, Lu Y (2013) Chemical and spectroscopic characterization of water extractable organic matter during vermicomposting of cattle dung. Bioresour Technol 132:320–326CrossRefGoogle Scholar
  37. Mao J, Olk DC, Fang X, He Z, Schmidt-Rohr K (2008) Influence of animal manure application on the chemical structures of soil organic matter as investigated by advanced solid-state NMR and FT-IR spectroscopy. Geoderma 146(1):353–362CrossRefGoogle Scholar
  38. Mao J, Tremblay L, Gagné JP (2011) Structural changes of humic acids from sinking organic matter and surface sediments investigated by advanced solid-state NMR: insights into sources, preservation and molecularly uncharacterized components. Geochim Cosmochim Acta 75(24):7864–7880CrossRefGoogle Scholar
  39. Marhuenda-Egea FC, Martínez-Sabater E, Jordá J, Moral R, Bustamante MA, Paredes C, Pérez-Murcia MD (2007) Dissolved organic matter fractions formed during composting of winery and distillery residues: evaluation of the process by fluorescence excitation–emission matrix. Chemosphere 68(2):301–309CrossRefGoogle Scholar
  40. Marshall B, Boag B, McNicol JW, Neilson R (1998) A comparison of the spatial distribution of three plant-parasitic nematode species at three different scales. Nematologica 44:303–320CrossRefGoogle Scholar
  41. Martens DA, Loeffelmann KL (2002) Improved accounting of carbohydrate carbon from plants and soils. Soil Biol Biochem 34(10):1393–1399CrossRefGoogle Scholar
  42. Mulvaney RL (1996) Nitrogen-inorganic forms. In: Sparks DL (ed) Method of soil analysis. Part 3. Chemical methods. American Society of Agronomy and Soil Science Society of America, Madison, pp 1123–1200Google Scholar
  43. Nain L, Rana A, Joshi M, Jadhav SD, Kumar D, Shivay YS, Paul S, Prasanna R (2010) Evaluationof synergistic effects of bacterial and cyanobacterial strains as biofertilizers for wheat. Plant Soil 331:217–230CrossRefGoogle Scholar
  44. Nelson DW, Sommers L (1982) Total carbon, organic carbon, and organic matter. Methods of soil analysis. Part 2. Chemical and microbiological properties. Amer Soc Agron No 9, 539–579Google Scholar
  45. Prasanna R, Joshi M, Rana A, Shivay YS, Nain L (2012) Influence of co-inoculation of bacteria-cyanobacteria on crop yield and C–N sequestration in soil under rice crop. World J Microbiol Biotechnol 28(3):1223–1235CrossRefGoogle Scholar
  46. Prasanna R, Chaudhary V, Gupta V, Babu S, Kumar A, Singh R, Nain L (2013) Cyanobacteria mediated plant growth promotion and bioprotection against fusarium wilt in tomato. Eur J Plant Pathol 136(2):337–353CrossRefGoogle Scholar
  47. Richard TL, Hamelers HVM, Veeken A, Silva T (2002) Moisture relationships in composting processes. Compost Science & Utilization 10(4):286–302CrossRefGoogle Scholar
  48. Said-Pullicino D, Erriquens FG, Gigliotti G (2007) Changes in the chemical characteristics of water-extractable organic matter during composting and their influence on compost stability and maturity. Bioresour Technol 98:1822–1831CrossRefGoogle Scholar
  49. Schrempf H (2001) Recognition and degradation of chitin by streptomycetes. Antonie Van Leeuwenhoek 79(3–4):285–289CrossRefGoogle Scholar
  50. Sinha RK, Agarwal S, Chauhan K, Valani D (2010) The wonders of earthworms & its vermicompost in farm production: Charles Darwin’s ‘friends of farmers’, with potential to replace destructive chemical fertilizers. Agric Sci 1(02):76Google Scholar
  51. Song C, Li M, Xi B, Wei Z, Zhao Y, Jia X, Qi H, Zhu C (2015) Characterisation of dissolved organic matter extracted from the bio-oxidative phase of co-composting of biogas residues and livestock manure using spectroscopic techniques. International Biodeterioration & Biodegradation 103:38–50CrossRefGoogle Scholar
  52. Stach JE, Maldonado LA, Ward AC, Goodfellow M, Bull AT (2003) New primers for the class Actinobacteria: application to marine and terrestrial environments. Environ Microbiol 5(10):828–841CrossRefGoogle Scholar
  53. Strom PF (1985) Effect of temperature on bacterial species diversity in thermophilic solid-waste composting. Appl Environ Microbiol 50(4):899–905Google Scholar
  54. Sundberg C, Smårs S, Jönsson H (2004) Low pH as an inhibiting factor in the transition from mesophilic to thermophilic phase in composting. Bioresour Technol 95(2):145–150CrossRefGoogle Scholar
  55. Tang JC, Inoue Y, Yasuta T, Yoshida S, Katayama A (2003) Chemical and microbial properties of various compost products. Soil Science and Plant Nutrition 49(2):273–280CrossRefGoogle Scholar
  56. Tirol-Padre A, Ladha JK (2004) Assessing the reliability of permanganate-oxidizable carbon as an index of soil labile carbon. Soil Sci Soc Am J 68(3):969–978CrossRefGoogle Scholar
  57. Vandenbroucke M, Largeau C (2007) Kerogen origin, evolution and structure. Org Geochem 38(5):719–833CrossRefGoogle Scholar
  58. Vandermeersch T, Alvarenga RAF, Ragaert P, Dewulf J (2014) Environmental sustainability assessment of food waste valorization options. Resour Conserv Recycl 87:57–64CrossRefGoogle Scholar
  59. Verma SL, Marschner P (2013) Compost effects on microbial biomass and soil P pools as affected by particle size and soil properties. J Soil Sci Plant Nutr 13(2):313–328Google Scholar
  60. Vieira FCB, Bayer C, Zanatta JA, Dieckow J, Mielniczuk J, He ZL (2007) Carbon management index based on physical fractionation of soil organic matter in an Acrisol under long-term no-till cropping systems. Soil Tillage Res 96(1):195–204CrossRefGoogle Scholar
  61. Wang Y, Sheng HF, He Y, Wu JY, Jiang YX, Tam NFY, Zhou HW (2012) Comparison of the levels of bacterial diversity in freshwater, intertidal wetland, and marine sediments by using millions of illumina tags. Appl Environ Microbiol 78(23):8264–8271CrossRefGoogle Scholar
  62. Wang K, Li W, Gong X, Li Y, Wu C, Ren N (2013) Spectral study of dissolved organic matter in biosolid during the composting process using inorganic bulking agent: UV-vis, GPC, FTIR and EEM. International Biodeterioration & Biodegradation 85:617–623CrossRefGoogle Scholar
  63. Wang X, Yang H, Liu J, Wu J, Chen W, Wu J, Zhu L, Bian X (2015a) Effects of ditch-buried straw return on soil organic carbon and rice yields in a rice–wheat rotation system. Catena 127:56–63CrossRefGoogle Scholar
  64. Wang W, Lai DYF, Wang C, Pan T, Zeng C (2015b) Effects of rice straw incorporation on active soil organic carbon pools in a subtropical paddy field. Soil Tillage Res 152:8–16CrossRefGoogle Scholar
  65. Wang X, Selvam A, Wong JW (2016) Influence of lime on struvite formation and nitrogen conservation during food waste composting. Bioresour Technol 217:227–232CrossRefGoogle Scholar
  66. Wei Z, Zhang X, Wei Y, Wen X, Shi J, Wu J, Zhao Y, Xi B (2014) Fractions and biodegradability of dissolved organic matter derived from different composts. Bioresour Technol 161:179–185CrossRefGoogle Scholar
  67. Wei Z, Wang X, Zhao X, Xi B, Wei Y, Zhang X, Zhao Y (2016) Fluorescence characteristics of molecular weight fractions of dissolved organic matter derived from composts. International Biodeterioration & Biodegradation 113:187–194CrossRefGoogle Scholar
  68. Xu M, Lou Y, Sun X, Wang W, Baniyamuddin M, Zhao K (2011) Soil organic carbon active fractions as early indicators for total carbon change under straw incorporation. Biol Fertil Soils 47(7):745–752CrossRefGoogle Scholar
  69. Yan N, Marschner P, Cao W, Zuo C, Qin W (2015) Influence of salinity and water content on soil microorganisms. International Soil and Water Conservation Research 3(4):316–323CrossRefGoogle Scholar
  70. Zaher U, Higgins S, Carpenter-Boggs L (2016) Interactive life cycle assessment framework to evaluate agricultural impacts and benchmark emission reduction credits from organic management. J Clean Prod 115:182–190CrossRefGoogle Scholar
  71. Zhang S, Chen Z, Wen Q, Ma J, He Z (2016) Assessment of maturity during co-composting of penicillin mycelial dreg via fluorescence excitation-emission matrix spectra: characteristics of chemical and fluorescent parameters of water-extractable organic matter. Chemosphere 155:358–366CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany 2017

Authors and Affiliations

  • Jiaqi Hou
    • 1
    • 2
  • Mingxiao Li
    • 2
    Email author
  • Beidou Xi
    • 1
    • 2
    Email author
  • Wenbing Tan
    • 2
  • Jie Ding
    • 2
  • Yan Hao
    • 2
  • Dongming Liu
    • 2
  • Hongliang Liu
    • 1
    • 2
  1. 1.State Key Laboratory of Water Environment Simulation, School of EnvironmentBeijing Normal UniversityBeijingChina
  2. 2.State Key Laboratory of Environmental Criteria and Risk AssessmentChinese Research Academy of Environmental SciencesBeijingChina

Personalised recommendations