Environmental Science and Pollution Research

, Volume 22, Issue 10, pp 7237–7247 | Cite as

Hygienization performances of innovative sludge treatment solutions to assure safe land spreading

  • C. Levantesi
  • C. Beimfohr
  • A. R. Blanch
  • A. Carducci
  • A. Gianico
  • F. Lucena
  • M. C. Tomei
  • G. Mininni
Effective management of sewage sludge

Abstract

The present research aims at the evaluation of the hygienization performances of innovative sludge treatment processes applied for the separated treatment of secondary sludge. Namely, two digestion pretreatments (sonication and thermal hydrolysis) and two sequential biological processes (mesophilic/thermophilic and anaerobic/aerobic digestion) were compared to the mesophilic (MAD) and thermophilic anaerobic digestion (TAD). Microbial indicators (Escherichia coli, somatic coliphages and Clostridium perfringens spores) and pathogens (Salmonella and enteroviruses), which show different resistances to treatment processes, were monitored in untreated and treated sludge. Overall, microbial load in secondary sludge was shown to be similar or lower than previously reported in literature for mixed sludge. Notably, the anaerobic/aerobic digestion process increased the removal of E. coli and somatic coliphages compared to the simple MAD and always achieved the hygienization requirement (2-log-unit removal of E. coli) proposed by EU Commission in the 3rd Working Document on sludge (April 2000) for the use of treated sludges in agriculture with restriction on their application. The microbial quality limits for the unrestricted use of sludge in agriculture (no Salmonella in 50 g wet weight (WW) and E. coli <500 CFU/g) were always met when thermal digestion or pretreatment was applied; however, the required removal level (6-log-unit removal of E. coli) could not be assessed due to the low level of this microorganism in raw sludge. Observed levels of indicator removal showed a higher resistance of viral particles to thermal treatment compared with bacterial cells and confirmed the suitability of somatic coliphages as indicators in thermal treatment processes.

Keywords

Sewage sludge Anaerobic digestion Aerobic stabilization Pretreatments Sludge hygienization Somatic coliphages C. perfringens Salmonella Enterovirus 

References

  1. Aitken MD, Sobsey MD, Shehee M, Blauth KE, Hill VR, Farrell JB, Nappier SP, Walters GW, Crunk PL, van Abel N (2005) Laboratory evaluation of thermophilic/anaerobic digestion to produce Class A biosolids. Inactivation of pathogens and indicator organisms in a continuous-flow reactor followed by batch treatment. Water Environ Res 77:3028–3036CrossRefGoogle Scholar
  2. Anon (2003) USEPA 625 ⁄ R-92 ⁄ 013. Control of Pathogens and Vector Attraction in Sewage Sludge. Cincinnati, OH: UnitedStates Environmental Protection AgencyGoogle Scholar
  3. Astals S, Venegas C, Peces M, Jofre J, Lucena F, Mata-Alvarez J (2012) Balancing hygienization and anaerobic digestion of raw sewage sludge. Water Res 46(19):6218–27CrossRefGoogle Scholar
  4. Berg G (1973) Removal of viruses from sewage, effluents, and waters I. A review. Bull World Health Organ 49(5):451–60Google Scholar
  5. Berman D, Berg G, Safferman S (1981) A method for recovering viruses from sludge. J Virol Methods 3:283–291CrossRefGoogle Scholar
  6. Bolzonella D, Pavan P, Battistoni P, Cecchi F (2005) Mesophilic anaerobic digestion of waste activated sludge: influence of the solid retention time in the wastewater treatment process. Process Biochem 40:1453–1460Google Scholar
  7. Braguglia CM, Gagliano MC, Rossetti S (2012) High frequency ultrasound pretreatment for sludge anaerobic digestion: effect on floc structure and microbial population. Bioresour Technol 110:43–49CrossRefGoogle Scholar
  8. Braguglia CM, Coors A, Gallipoli A, Gianico A, Guillon E, Kunkel U, Mascolo G, Richter E, Tomei MC, Ternes TA, Mininni G (2014) Quality assessment of digested sludge produced by advanced stabilization processes. Environ Sci Pollut Res: submitted to this special issueGoogle Scholar
  9. Bufton AW (1959) A note on the enumeration of thermophilic sulphite-reducing bacteria. J Appl Bacteriol 22:278–280CrossRefGoogle Scholar
  10. Carballa M, Omil F, Lema JM (2009) Influence of different pretreatments on anaerobically digested sludge characteristics: suitability for final disposal. Water Air Soil Pollut 199:311–321CrossRefGoogle Scholar
  11. Carrington EG, Pike EB, Auty D, Morris R (1991) Destruction of faecal bacteria, enteroviruses and ova of parasites in wastewater sludge by aerobic thermophilic and anaerobic mesophilic digestion. Water Sci Technol 24:377–380Google Scholar
  12. Chen Y, Fu B, Wang Y, Jiang Q, Liu H (2012) Reactor performance and bacterial pathogen removal in response to sludge retention time in a mesophilic anaerobic digester treating sewage sludge. Bioresour Technol 106:20–26CrossRefGoogle Scholar
  13. Dahab MF, Surampalli RY (2002) Effects of aerobic and anaerobic digestion systems on pathogen and pathogen indicator reduction in municipal sludge. Water Sci Technol 46:181–187Google Scholar
  14. de la Rubia MA, Perez M, Romero LI, Sales D (2006) Effect of solids retention time (SRT) on pilot scale anaerobic thermophilic sludge digestion. Process Biochem 41:79–86CrossRefGoogle Scholar
  15. Duran M, Speece RE (1997) Temperature-staged anaerobic processes. Environ Technol 18:747–753CrossRefGoogle Scholar
  16. Environment DG, EU, (2000). Working Document on Sludge 3rd Draft, Brussels, 27 April 2000, ENV.E.3/LM.http://ec.europa.eu/environment/waste/sludge/pdf/sludge_en.pdf. Accessed 18 March 2014
  17. European Commission: Council Directive 86/278/EEC of 12 June 1986 on the protection of the environment, and in particular of the soil, when sewage sludge is used in agricultureGoogle Scholar
  18. Forster-Carneiro T, Riau V, Perez M (2010) Mesophilic anaerobic digestion of sewage sludge to obtain Class B biosolids: microbiological methods development. Bioresour Technol 20Google Scholar
  19. Gantzer C, Gaspard P, Galvez L, Huyard A, Domouthier N, Schwartzbrod J (2001) Monitoring of bacterial and parasitological contamination during various treatment of sludge. Water Res 35(16):3763–3770CrossRefGoogle Scholar
  20. Ge H, Jensen PD, Batstone DJ (2010) Pre-treatment mechanisms during thermophilic–mesophilic temperature phased anaerobic digestion of primary sludge. Water Res 44:123–130CrossRefGoogle Scholar
  21. Gianico A, Braguglia CM, Cesarini R, Mininni G (2013) Reduced temperature hydrolysis at 134 °C before thermophilic anaerobic digestion of waste activated sludge at increasing organic load. Bioresour Technol 143:96–103CrossRefGoogle Scholar
  22. Gianico A, Braguglia CM, Gallipoli A, Mininni G (2014) Innovative two-stage mesophilic/thermophilic anaerobic degradation of sonicated sludge: performances and energy balance. Environ Sci Pollut Res: submitted to this special issueGoogle Scholar
  23. Guzmán C, Jofre J, Montemayor M, Lucena F (2007a) Occurrence and levels of indicators and selected pathogens in different sludges and biosolids. J Appl Microbiol 103(6):2420–2429CrossRefGoogle Scholar
  24. Guzmán C, Jofre J, Blanch AR, Lucena F (2007b) Development of a feasible method to extract somatic coliphages from sludge, soil and treated biowaste. J Virol Methods 144:41–48CrossRefGoogle Scholar
  25. Han Y, Li YY, Ren YX, Yan F (2007) Thermophilic anaerobic digestion of thermal pretreated WWTP sludge. Acta Sci Circum 27(7):1174–1180Google Scholar
  26. Harwood VJ, Levine AD, Scott TM, Chivukula V, Lukasik J, Farrah SR, Rose JB (2005) Validity of the indicator organism paradigm for pathogen reduction in reclaimed water and public health protection. Appl Environ Microbiol 71(6):3163–3170CrossRefGoogle Scholar
  27. Hejkal TW, Wellings FM, Lewis AL, LaRock PA (1981) Distribution of viruses associated with particles in waste water. Appl Environ Microbiol 41(3):628–634Google Scholar
  28. Horan NJ, Fletcher L, Betmal SM, Wilks SA, Keevil CW (2004) Die-off of enteric bacterial pathogens during mesophilic anaerobic digestion. Water Res 38(5):1113–1120CrossRefGoogle Scholar
  29. Katzenelson E, Fattal B, Hostovesky T (1976) Organic flocculation: an efficient second-step concentration method for the detection of viruses in tap water. Appl Environ Microbiol 32(4):638–639Google Scholar
  30. Kumar N, Novak JT, Murthy S (2006) Effect of secondary aerobic digestion on properties of anaerobic digested biosolids. Water Environmental Federation 79th Annual Technical Exhibition and Conference, Dallas, 6806–6829Google Scholar
  31. Lewis MA, Nath MW, Johnson JC (1983) A multiple extraction-centrifugation method for the recovery of viruses from wastewater treatment plant effluents and sludges. Can J Microbiol 29:1661–1670CrossRefGoogle Scholar
  32. Lv W, Schanbacher FL, Yu Z (2010) Putting microbes to work in sequence: recent advances in temperature-phased anaerobic digestion processes. Bioresour Technol 101(24):9409–94014CrossRefGoogle Scholar
  33. Mandilara G, Mavridou A, Lambiri M, Vatopoulos A, Rigas F (2006) The use of bacteriophages for monitoring the microbiological quality of sewage sludge. Environ Technol 27:367–370CrossRefGoogle Scholar
  34. Mininni G, Braguglia CM, Ramadori R, Tomei MC (2004) An innovative sludge management system based on separation of primary and secondary sludge treatment. Water Sci Technol 50(9):145–153Google Scholar
  35. Moce’-Llivina L, Muniesa M, Pimenta-Vale H, Lucena F, Jofre J (2003) Survival of bacterial indicator species and bacteriophages after thermal treatment of sludge and sewage. Appl Environ Microbiol 69(3):1452–1456CrossRefGoogle Scholar
  36. Monpoeho S, Dehee A, Mignotte B, Schwartzbrod L, Marechal V, Nicolas JC, Billaudel S, Ferre V (2000) Quantification of enterovirus RNA in sludge samples using single tube real-time RT-PCR. Biotechniques 29:88–93Google Scholar
  37. Monpoeho A, Maul C, BonninL PS, Ranarijaona S, Billaudel S, Ferré V (2004) Clearance of human-pathogenic viruses from sludge: study of four stabilization processes by real-time reverse transcription-PCR and cell culture. Appl Environ Microbiol 70(9):5434–5440CrossRefGoogle Scholar
  38. Moore BE, Funderburg SL, Sagik BP, Malina JF (1974) Application of viral concentration techniques to field sampling. In: Malina JF, Sagik BP (eds) Virus survival in water and wastewater systems. University of Texas, Austin, Center for Research in Water Resources, pp 3–15Google Scholar
  39. Novak JT, Sadler MS, Murthy SN (2003) Mechanism of floc destruction during anaerobic and aerobic digestion and the effect on conditioning and dewatering of biosolids. Water Res 37:3136–3144CrossRefGoogle Scholar
  40. Pepper IL, Brooks JP, Sinclair RG, Gurian PL, Gerba CP (2010) Pathogens and indicators in United States Class B biosolids: national and historic distributions. J Environ Qual 39(6):2185–2190CrossRefGoogle Scholar
  41. Pourcher AM, Morand P, Picard-Bonnaud F, Billaudel S, Monpoeho S, Federighi M, Ferré V, Moguedet G (2005) Decrease of enteric micro-organisms from rural sewage sludge during their composting in straw mixture. Appl Microbiol 99(3):528–539CrossRefGoogle Scholar
  42. Riau V, De la Rubia MA, Pérez M (2010) Temperature-phased anaerobic digestion (TPAD) to obtain Class A biosolids: a semi-continuous study. Bioresour Technol 101:2706–2712CrossRefGoogle Scholar
  43. Sahlström L (2003) A review of survival of pathogenic bacteria in organic waste used in biogas plants. Bioresour Technol 87:161–166CrossRefGoogle Scholar
  44. Sahlström L, Aspan A, Bagge E, Danielsson-Tham ML, Albihn A (2004) Bacterial pathogen incidences in sludge from Swedish sewage treatment plants. Water Res 38(8):1989–1994CrossRefGoogle Scholar
  45. Sidhu JPS, Toze SG (2009) Human pathogens and their indicators in sludge: a literature review. Environ Int 35:187–201CrossRefGoogle Scholar
  46. Subramanian S, Kumar N, Murthy SN, Novak JT (2007) Effect of anaerobic digestion and anaerobic/aerobic digestion processes on sludge dewatering. J Residuals Sci Technol 4:17–23Google Scholar
  47. Tandoi V, Levantesi C, Toze S, Böckelmann U, Divizia M, Ayuso-Gabella N, Salgot M, La Mantia R, Grohmann E (2012) Water quality analysis—microbiological hazards. In: Kazner C, Wintgens T, Dillon P (eds) Water reclamation technologies for safe managed aquifer recharge. IWA Publishing, London, European Commission, pp 171–196Google Scholar
  48. Tomei MC, Carozza N (2014) Sequential anaerobic/anaerobic digestion for enhanced sludge stabilization: comparison of the process performance for mixed and waste sludge. Environ Sci Pollut Res: submitted to this special issueGoogle Scholar
  49. Toreci I, Kennedy KJ, Droste RL (2009) Evaluation of continuous mesophilic anaerobic sludge digestion after high temperature microwave pretreatment. Water Res 43:1273–1284CrossRefGoogle Scholar
  50. Vesilind PA, Spinosa L (2001) Production and regulations. In: Spinosa L, Vesilind PA (eds) Sludge into biosolids—processing, disposal. Utilization. IWA Publishing, London, pp 3–18Google Scholar
  51. Viau E, Peccia J (2009) Survey of wastewater indicators and human pathogen genomes in biosolids produced by Class A and Class B stabilization treatments. Appl Environ Microbiol 75(1):164–74CrossRefGoogle Scholar
  52. Wellings FM, Lewis AL, Mountain CW (1976) Demonstration of solids-associated virus in wastewater and sludge. Appl Microbiol 31:354–358Google Scholar
  53. WHO (2003) Assessing microbial safety of drinking water: improving approaches and methods. In: Dufour A, Snozzi M, Koster W, Bartram J, Ronchi E, Fewtrell L (eds) Published on behalf of the World Health Organization and the Organisation for Economic Co-operation and Development. IWA Publishing Alliance, LondonGoogle Scholar
  54. WHO (2008) Guidelines for Drinking-water quality Third edition Incorporating the first and second Addenda Volume 1 Recommendations World Health Organisation, GenevaGoogle Scholar
  55. Wong K, Onan BM, Xagoraraki I (2010) Quantification of enteric viruses, pathogen indicators, and salmonella bacteria in Class B anaerobically digested biosolids by culture and molecular methods. Appl Environ Microbiol 76(19):6441–6448CrossRefGoogle Scholar

Copyright information

© Springer-Verlag Berlin Heidelberg 2014

Authors and Affiliations

  • C. Levantesi
    • 1
  • C. Beimfohr
    • 2
  • A. R. Blanch
    • 3
  • A. Carducci
    • 1
  • A. Gianico
    • 1
  • F. Lucena
    • 3
  • M. C. Tomei
    • 1
  • G. Mininni
    • 1
  1. 1.CNR – Water Research InstituteRomeItaly
  2. 2.vermicon AGMunichGermany
  3. 3.Department of MicrobiologyUniversity of BarcelonaBarcelonaSpain

Personalised recommendations