Advertisement

The effect of Sn on electrical performance of zinc oxide based thin film transistor

  • Serif Ruzgar
  • Mujdat CaglarEmail author
Article
  • 184 Downloads

Abstract

In this study, we have effectively fabricated undoped and Sn-doped zinc oxide thin film transistors (ZTO TFTs) with the back-gate structure on commercially purchased p-type Si with a thermally grown SiO2 layer (thickness = 100 nm). The ZTO TFTs were prepared via low-cost solution based spin coating method. We investigated the structural and morphological properties of thin films and the effect of Sn doping on the electrical performance of ZnO TFTs. It has been found that the electrical parameters of the ZnO based transistors have highly affected by Sn doping. The field-effect mobility and on/off ratio of doped TFT increased ~ 40 and 106 times by comparison with undoped TFT, respectively. The best results were obtained from 10% Sn doped ZTO TFT with 3.83 cm2 V−1 s−1 the field effect mobility (µsat), 1 V/dec subthreshold slope (SS), 9 V threshold voltage (Vth), 3 × 108 Ion/Ioff ratio and a high on-current of 1.3 mA.

Notes

Acknowledgements

This work was supported by Anadolu University Commission of Scientific Research Project under Grant No. 1706F385.

References

  1. 1.
    M.K. Ryu et al., High performance thin film transistor with cosputtered amorphous Zn–In–Sn–O channel: combinatorial approach. Appl. Phys. Lett. 95(7), 072104 (2009)CrossRefGoogle Scholar
  2. 2.
    F. Liu et al., Solution-processed lithium-doped zinc oxide thin-film transistors at low temperatures between 100 and 300 °C. Appl. Phys. A 122(4), 311 (2016)CrossRefGoogle Scholar
  3. 3.
    S.-J. Seo et al., High performance solution-processed amorphous zinc tin oxide thin film transistor. J. Phys. D 42(3), 035106 (2009)CrossRefGoogle Scholar
  4. 4.
    W.-S. Kim et al., Improvement in the negative bias temperature stability of ZnO based thin film transistors by Hf and Sn doping. Thin Solid Films 519(20), 6849–6852 (2011)CrossRefGoogle Scholar
  5. 5.
    D.-H. Lee et al., Inkjet printed high-mobility indium zinc tin oxide thin film transistors. J. Mater. Chem. 19(20), 3135–3137 (2009)CrossRefGoogle Scholar
  6. 6.
    Y. Zhao et al., Impacts of Sn precursors on solution-processed amorphous zinc–tin oxide films and their transistors. RSC Adv. 2(12), 5307–5313 (2012)CrossRefGoogle Scholar
  7. 7.
    X. Yu, T.J. Marks, A. Facchetti, Metal oxides for optoelectronic applications. Nat. Mater. 15(4), 383–396 (2016)CrossRefGoogle Scholar
  8. 8.
    S.-J. Seo, Y.H. Hwang, B.-S. Bae, Postannealing process for low temperature processed sol–gel zinc tin oxide thin film transistors. Electrochem. Solid-State Lett. 13(10), H357 (2010)CrossRefGoogle Scholar
  9. 9.
    D. Han et al., Fully transparent flexible tin-doped zinc oxide thin film transistors fabricated on plastic substrate. Sci. Rep. 6, 38984 (2016)CrossRefGoogle Scholar
  10. 10.
    Y.-Y. Chen et al., Effects of growth temperature and annealing on properties of Zn3Sn2O7 thin films and application in TFTs. J. Electron. Mater. 42(8), 2459–2463 (2013)CrossRefGoogle Scholar
  11. 11.
    S.-J. Lee et al., Characterization of ZnO–SnO2 nanocomposite thin films deposited by pulsed laser ablation and their field effect electronic properties. Mater. Lett. 122, 94–97 (2014)CrossRefGoogle Scholar
  12. 12.
    J. Joo et al., Effect of sintering time at low temperature on the properties of IGZO TFTs fabricated by using the sol-gel process. J Korean Phys. Soc. 57(6), 1836–1841 (2010)CrossRefGoogle Scholar
  13. 13.
    H.-C. You, Effects of doped stannum in the fabrication of zinc-oxide thin-film transistors. Int. J. Electrochem. Sci. 11, 3383–3392 (2016)CrossRefGoogle Scholar
  14. 14.
    D.-H. Lee et al., Effect of Ag doping on the performance of ZnO thin film transistor. Thin Solid Films 520(3), 1160–1164 (2011)CrossRefGoogle Scholar
  15. 15.
    Y.Y. Lin et al., Stable and high-performance flexible ZnO thin-film transistors by atomic layer deposition. ACS Appl. Mater. Interfaces 7(40), 22610–22617 (2015)CrossRefGoogle Scholar
  16. 16.
    J. Joo et al., Fabrication and comparison of the properties of SnInZnO and InZnO TFTs processed by using the sol-gel method. J. Korean Phys. Soc. 57(6(1), 1847–1851 (2010)CrossRefGoogle Scholar
  17. 17.
    Y. Caglar et al., Crystalline structure and morphological properties of undoped and Sn doped ZnO thin films. Superlattices Microstruct. 46(3), 469–475 (2009)CrossRefGoogle Scholar
  18. 18.
    S. Aksoy et al., Sol–gel derived Li–Mg co-doped ZnO films: preparation and characterization via XRD, XPS, FESEM. J. Alloys Compd. 512(1), 171–178 (2012)CrossRefGoogle Scholar
  19. 19.
    M. Nakata, C. Zhao, J. Kanicki, DC sputtered amorphous In–Sn–Zn–O thin-film transistors: electrical properties and stability. Solid-State Electron. 116, 22–29 (2016)CrossRefGoogle Scholar
  20. 20.
    M. Ahmad et al., SnO2/ZnO composite structure for the lithium-ion battery electrode. J. Solid State Chem. 196, 326–331 (2012)CrossRefGoogle Scholar
  21. 21.
    M. Kwoka et al., XPS study of the surface chemistry of L-CVD SnO2 thin films after oxidation. Thin Solid Films 490(1), 36–42 (2005)CrossRefGoogle Scholar
  22. 22.
    S.S. Shinde et al., Influence of tin doping onto structural, morphological, optoelectronic and impedance properties of sprayed ZnO thin films. J. Alloys Compd. 551, 688–693 (2013)CrossRefGoogle Scholar
  23. 23.
    S.Y. Li et al., Effect of Sn dopant on the properties of ZnO nanowires. J. Phys. D 37(16), 2274–2282 (2004)CrossRefGoogle Scholar
  24. 24.
    J.-H. Lee, B.-O. Park, Transparent conducting ZnO: Al, In and Sn thin films deposited by the sol–gel method. Thin Solid Films 426(1–2), 94–99 (2003)CrossRefGoogle Scholar
  25. 25.
    W. Yu et al., High-performance calcium-doped zinc oxide thin-film transistors fabricated on glass at low temperature. Jpn. J. Appl. Phys. 55(4S), 04EK05 (2016)CrossRefGoogle Scholar
  26. 26.
    S.R. Thomas, G. Adamopoulos, T.D. Anthopoulos, Be-doped ZnO thin-film transistors and circuits fabricated by spray pyrolysis in air. J. Disp. Technol. 9(9), 688–693 (2013)CrossRefGoogle Scholar
  27. 27.
    K.M. Niang et al., Optimisation of amorphous zinc tin oxide thin film transistors by remote-plasma reactive sputtering. J. Appl. Phys. 120(8), 085312 (2016)CrossRefGoogle Scholar
  28. 28.
    S. Jeong, Y. Jeong, J. Moon, Solution-processed zinc tin oxide semiconductor for thin-film transistors. J. Phys. Chem. C 112(30), 11082–11085 (2008)CrossRefGoogle Scholar
  29. 29.
    I. Noviyana et al., High mobility thin film transistors based on amorphous indium zinc tin oxide. Materials 10(7), 702 (2017)CrossRefGoogle Scholar
  30. 30.
    Y.J. Chang et al., High-performance, spin-coated zinc tin oxide thin-film transistors. Electrochem. Solid-State Lett. 10(5), H135 (2007)CrossRefGoogle Scholar
  31. 31.
    S. Ruzgar, M. Caglar, Use of bilayer gate insulator to increase the electrical performance of pentacene based transistor. Synth. Met. 232, 46–51 (2017)CrossRefGoogle Scholar
  32. 32.
    S. Parthiban, J.-Y. Kwon, Role of dopants as a carrier suppressor and strong oxygen binder in amorphous indium-oxide-based field effect transistor. J. Mater. Res. 29(15), 1585–1596 (2014)CrossRefGoogle Scholar
  33. 33.
    J.H. Shim et al., Fabrication and comparison of the properties of SnInZnO and InZnO TFTs processed by using the sol-gel method. J. Korean Phys. Soc. 57(6), 1847–1851 (2010)Google Scholar
  34. 34.
    C. Brox-Nilsen et al., Sputtered ZnO thin-film transistors with carrier mobility over 50 cm2/Vs. IEEE Trans. Electron Devices 60(10), 3424–3429 (2013)CrossRefGoogle Scholar
  35. 35.
    W.-S. Kim et al., Copper source/drain electrode contact resistance effects in amorphous indium-gallium-zinc-oxide thin film transistors. Phys. Status Solidi (RRL) 3(7–8), 239–241 (2009)CrossRefGoogle Scholar
  36. 36.
    K. Pernstich et al., Threshold voltage shift in organic field effect transistors by dipole monolayers on the gate insulator. J. Appl. Phys. 96(11), 6431–6438 (2004)CrossRefGoogle Scholar
  37. 37.
    J. Veres et al., Gate insulators in organic field-effect transistors. Chem. Mater. 16(23), 4543–4555 (2004)CrossRefGoogle Scholar
  38. 38.
    S. Maitra, Study of the variation of the threshold voltage with the doping concentration and channel length. In Devices for Integrated Circuit (DevIC), IEEE, 2017Google Scholar
  39. 39.
    P.K. Nayak et al., Effects of Li doping on the performance and environmental stability of solution processed ZnO thin film transistors. Appl. Phys. Lett. 95(19), 193503 (2009)CrossRefGoogle Scholar
  40. 40.
    L.-C. Liu et al., Variation of oxygen deficiency in solution-processed ultra-thin zinc-tin oxide films to their transistor characteristics. ECS J. Solid State Sci. Technol. 2(4), Q59–Q64 (2013)CrossRefGoogle Scholar

Copyright information

© Springer Science+Business Media, LLC, part of Springer Nature 2018

Authors and Affiliations

  1. 1.Department of Opticianry Program, Vocational School Of Health ServicesBatman UniversityBatmanTurkey
  2. 2.Department of Physics, Faculty of ScienceEskişehir Technical UniversityEskisehirTurkey

Personalised recommendations