Skip to main content
SpringerLink
Log in

N-doped and Fe-, N-codoped carbon: tuning of porous structures for highly efficient oxygen reduction reaction

  • Energy materials
  • Published:
Journal of Materials Science Aims and scope Submit manuscript

Abstract

The various heteroatom-doped carbons have emerged as a type of promising oxygen reduction reaction (ORR) catalysts to replace the expensive Pt-based ones. Normally, the carbon catalysts are constructed into porous structures, with one purpose to increase the specific surface areas and another to provide mass transfer channels, while, although the extensive reports on the porous structures, there is still deficient of a systematic investigation on the influence of detailed porous structures on the ORR performances. In this work, we prepared three different doped carbon materials, N-doped dual-porosity carbon, Fe-, N-codoped dual-porosity carbon, and Fe-, N-codoped macroporous carbon, to study this issue. Although some previous reports indicated that the mesopores may have negative effect to the electrochemical performance due to the complex tortuosity, our work elucidated their important contribution to the additional active sites. Simultaneously, increasing the macropore sizes of the catalysts from 100 to 500 nm would not make distinct performance enhancement, and the macropores with 100-nm sizes can basically satisfy the requirement of mass transfer. These results indeed supply a nice guidance for further design of highly efficient carbon-based ORR catalysts.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Figure 1
Figure 2
Figure 3
Figure 4
Figure 5
Figure 6
Figure 7

Similar content being viewed by others

References

  1. Wu G, Zelenay P (2013) Nanostructured nonprecious metal catalysts for oxygen reduction reaction. Acc. Chem. Res 46:1878–1889

    Article  Google Scholar 

  2. Cheng F-Y, Chen J (2012) Metal-air batteries: from oxygen reduction electrochemistry to cathode catalysts. Chem Soc Rev 41:2172–2192

    Article  Google Scholar 

  3. Wu JB, Yang H (2013) Platinum-based oxygen reduction catalysts. Acc Chem Res 46:1848–1857

    Article  Google Scholar 

  4. Bing Y, Liu H, Zhang L, Ghosh D, Zhang J (2010) Nanostructured Pt-alloy electrocatalysts for PEM fuel cell oxygen reduction reaction. Chem Soc Rev 39:2184–2202

    Article  Google Scholar 

  5. Sarapuu A, Kibena-Põldsepp E, Borghei M, Tammeveski K (2018) Electrocatalysis of oxygen reduction on heteroatom-doped nanocarbons and transition metal-nitrogen-carbon catalysts for alkaline membrane fuel cells. J Mater Chem A 6:776–804

    Article  Google Scholar 

  6. Tammeveski K, Kibena-Põldsepp E (2018) Electrocatalysis of oxygen reduction on pristine and heteroatom-doped graphene materials. In: Wandelt K (ed) Encyclopedia of interfacial chemistry: surface science and electrochemistry. Elsevier, New York, pp 497–506

    Google Scholar 

  7. Lefevre M, Dodelet JP, Bertrand P (2000) O2 reduction in PEM fuel cells: activity and active site structural information for catalysts obtained by the pyrolysis at high temperature of Fe precursors. J Phys Chem B 104:11238–11247

    Article  Google Scholar 

  8. Jaouen F, Lefevre M, Dodelet JP, Cai M (2006) Heat-treated Fe/N/C catalysts for O2 electroreduction: are active sites hosted in micropores? J Phys Chem B 110:5553–5558

    Article  Google Scholar 

  9. Ziegelbauer JM, Olson TS, Pylypenko S, Alamgir F, Jaye C, Atanassov P et al (2008) Direct spectroscopic observation of the structural origin of peroxide generation from Co-based pyrolyzed porphyrins for ORR applications. J Phys Chem C 112:8839–8849

    Article  Google Scholar 

  10. Koslowski UI, Abs-Wurmbach I, Fiechter S, Bogdanoff P (2008) Nature of the catalytic centers of porphyrin-based electrocatalysts for the ORR: a correlation of kinetic current density with the site density of Fe–N4 centers. J Phys Chem C 112:15356–15366

    Article  Google Scholar 

  11. Kramm UI, Herranz J, Larouche N, Arruda TM, Lefevre M, Jaouen F et al (2012) Structure of the catalytic sites in Fe/N/C-catalysts for O2-reduction in PEM fuel cells. Phys Chem Chem Phys 14:11673–11688

    Article  Google Scholar 

  12. Ferrandon M, Kropf AJ, Myers DJ, Artyushkova K, Kramm U, Bogdanoff P et al (2012) Multitechnique characterization of a polyaniline–iron–carbon oxygen reduction catalyst. J Phys Chem C 116:16001–16013

    Article  Google Scholar 

  13. Grumelli D, Wurster B, Stepanow S, Kern K (2013) Bio-inspired nanocatalysts for the oxygen reduction reaction. Nat Commun 4:2904

    Article  Google Scholar 

  14. Ramaswamy N, Tylus U, Jia Q, Mukerjee S (2013) Activity descriptor identification for oxygen reduction on nonprecious electrocatalysts: linking surface science to coordination chemistry. J Am Chem Soc 135:15443–15449

    Article  Google Scholar 

  15. Tylus U, Jia Q, Strickland K, Ramaswamy N, Serov A, Atanassov P et al (2014) Elucidating oxygen reduction active sites in pyrolyzed metal–nitrogen coordinated non-precious-metal electrocatalyst systems. J Phys Chem C 118:8999–9008

    Article  Google Scholar 

  16. Wang Q, Zhou Z-Y, Lai Y-J, You Y, Liu J-G, Wu X-L et al (2014) Phenylenediamine-based FeNx/C catalyst with high activity for oxygen reduction in acid medium and its active-site probing. J Am Chem Soc 136:10882–10885

    Article  Google Scholar 

  17. Asazawa K, Kishi H, Tanaka H, Matsumura D, Tamura K, Nishihata Y et al (2014) In situ XAFS and HAXPES analysis and theoretical study of cobalt polypyrrole incorporated on carbon (CoPPyC) oxygen reduction reaction catalysts for anion-exchange membrane fuel cells. J Phys Chem C 118:25480–25486

    Article  Google Scholar 

  18. Zhu Y, Zhang B, Liu X, Wang D-W, Su DS (2014) Unravelling the structure of electrocatalytically active Fe–N complexes in carbon for the oxygen reduction reaction. Angew Chem Int Ed 53:10673–10677

    Article  Google Scholar 

  19. Zitolo A, Goellner V, Armel V, Sougrati M-T, Mineva T, Stievano L et al (2015) Identification of catalytic sites for oxygen reduction in iron- and nitrogen-doped graphene materials. Nat Mater 14:937

    Article  Google Scholar 

  20. Jia Q, Ramaswamy N, Hafiz H, Tylus U, Strickland K, Wu G et al (2015) Experimental observation of redox-induced Fe–N switching behavior as a determinant role for oxygen reduction activity. ACS Nano 9:12496–12505

    Article  Google Scholar 

  21. Artyushkova K, Serov A, Rojas-Carbonell S, Atanassov P (2015) Chemistry of multitudinous active sites for oxygen reduction reaction in transition metal–nitrogen–carbon electrocatalysts. J Phys Chem C 119:25917–25928

    Article  Google Scholar 

  22. Jiang W-J, Gu L, Li L, Zhang Y, Zhang X, Zhang L-J et al (2016) Understanding the high Activity of Fe–N–C electrocatalysts in oxygen reduction: fe/Fe3C nanoparticles boost the activity of Fe–Nx. J Am Chem Soc 138:3570–3578

    Article  Google Scholar 

  23. Liu XJ, Zou SZ, Chen SW (2016) Ordered mesoporous carbons codoped with nitrogen and iron as effective catalysts for oxygen reduction reaction. Nanoscale 8:19249–19255

    Article  Google Scholar 

  24. Liang J, Zhou RF, Chen XM, Tang YH, Qiao SZ (2014) Fe-N decorated hybrids of CNTs grown on hierarchically porous carbon for high-performance oxygen reduction. Adv Mater 26:6074–6079

    Article  Google Scholar 

  25. Joo SH, Lee HI, You DJ, Kwon K, Kim JH, Choi YS et al (2008) Ordered mesoporous carbons with controlled particle sizes as catalyst supports for direct methanol fuel cell cathodes. Carbon 46:2034–2045

    Article  Google Scholar 

  26. Shui J, Chen C, Grabstanowicz L, Zhao D, Liu D-J (2015) Highly efficient nonprecious metal catalyst prepared with metal–organic framework in a continuous carbon nanofibrous network. Proc Natl Acad Sci USA 112:10629–10634

    Article  Google Scholar 

  27. Stober W, Fink A (1968) Controlled growth of monodisperse silica spheres in the micron size range. J Colloid Interface Sci 26:62–69

    Article  Google Scholar 

  28. Meng YY, Voiry D, Goswami A, Zou XX, Huang XX, Chhowalla M, Liu ZW, Asefa T (2014) N-, O-, and S-tridoped nanoporous carbons as selective catalysts for oxygen reduction and alcohol oxidation reactions. J. Am. Chem. Soc. 136:13554–13557

    Article  Google Scholar 

  29. Liang HW, Zhuang XD, Bruller S, Feng XL, Mullen K (2014) Hierarchically porous carbons with optimized nitrogen doping as highly active electrocatalysts for oxygen reduction. Nat Commun 5:4973

    Article  Google Scholar 

  30. Wang Y, Chen W, Nie Y, Peng LS, Lu LJ, Chen SG et al (2018) Rational engineering of the nanoarchitecture of Fe, N-co-doped carbon to achieve a marvelous activity towards oxygen reduction reaction. J Mater Chem A 6:8405–8412

    Article  Google Scholar 

  31. Han P, Yue Y, Zhang L, Xu H, Liu Z, Zhang K et al (2012) Nitrogen-doping of chemically reduced mesocarbon microbead oxide for the improved performance of lithium ion batteries. Carbon 50:1355–1362

    Article  Google Scholar 

  32. Liang J, Jiao Y, Jaroniec M, Qiao SZ (2012) Sulfur and nitrogen dual-doped mesoporous graphene electrocatalyst for oxygen reduction with synergistically enhanced performance. Angew Chem Int Ed 51:11496–11500

    Article  Google Scholar 

  33. Niu WH, Li L, Liu XJ, Wang N, Liu J, Zhou WJ et al (2015) Mesoporous N-doped carbons prepared with thermally removable nanoparticle templates: an efficient electrocatalyst for oxygen reduction reaction. J Am Chem Soc 137:5555–5562

    Article  Google Scholar 

  34. Mao ZX, Wang CY, Shan QY, Wang MJ, Zhang YX, Ding W, Chen SG, Li L, Li J, Wei ZD (2018) An unusual low-surface-area nitrogen doped carbon for ultrahigh gravimetric and volumetric capacitances. J Mater Chem A 6:8868–8873

    Article  Google Scholar 

  35. Ren H, Wang Y, Yang Y, Tang X, Peng Y, Peng H, Xiao L, Lu J, Abruña HD, Zhuang L (2017) Fe/N/C nanotubes with atomic Fe sites: a highly active cathode catalyst for alkaline polymer electrolyte fuel cells. ACS Catal 7:6485–6492

    Article  Google Scholar 

  36. Liang Y, Li Y, Wang H, Zhou J, Wang J, Regier T, Dai H (2011) Co3O4 nanocrystals on graphene as a synergistic catalyst for oxygen reduction reaction. Nat Mater 10:780–786

    Article  Google Scholar 

  37. Zhou RF, Zheng Y, Jaroniec M, Qiao S-Z (2016) Determination of the electron transfer number for the oxygen reduction reaction: from theory to experiment. ACS Catal 6:4720–4728

    Article  Google Scholar 

  38. Masa J, Batchelor-McAuley C, Schuhmann W, Compton RG (2014) Koutecky–Levich analysis applied to nanoparticle modified rotating disk electrodes: electrocatalysis or misinterpretation? Nano Res 7:71–78

    Article  Google Scholar 

Download references

Acknowledgements

This work was financially supported by the National Key Research and Development Program of China (2016YFB0101202) and the NSFC of China (Grant Nos. 91534205 and 21436003). Jing Li thanks Chongqing University for start-up financial support.

Author information

Authors and Affiliations

  1. School of Chemistry and Chemical Engineering, Chongqing University, Chongqing, 400044, China

    Lu Xiao, Qianqian Yang, Min Jie Wang, Zhan Xin Mao, Jing Li & Zidong Wei

Authors
  1. Lu Xiao
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Qianqian Yang
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Min Jie Wang
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Zhan Xin Mao
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Jing Li
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Zidong Wei
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding authors

Correspondence to Jing Li or Zidong Wei.

Ethics declarations

Conflict of interest

The authors declare that they have no conflict of interest.

Electronic supplementary material

Below is the link to the electronic supplementary material.

Supplementary material 1 (DOC 3957 kb)

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Xiao, L., Yang, Q., Wang, M.J. et al. N-doped and Fe-, N-codoped carbon: tuning of porous structures for highly efficient oxygen reduction reaction. J Mater Sci 53, 15246–15256 (2018). https://doi.org/10.1007/s10853-018-2683-8

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10853-018-2683-8

Keywords

Search

Navigation