Advertisement

Facile Fabrication of a Novel and Reusable 3D Laccase Reactor for Efficient Removal of Pollutants from Wastewater

  • Yulin Zou
  • Fanpeng Ran
  • Qiangwei Huang
  • Xiaoyan Liu
  • Haixia ZhangEmail author
Article
  • 14 Downloads

Abstract

Abstract

An ultra simple 3D bioreactor was prepared via Fe3+ linking to primary amines of melamine sponge (MeS) for cooperative complex formation with enzyme. Laccase worked as a model of enzyme and no chemical modification was employed during the material preparation. The 3D structure of MeS can enhance the enzyme loading amount up to 180 µg/mg, albeit MeS as monolithic material for enzyme immobilization is rather unexplored. The 3D bioreactor (MeS@Fe3+@laccase) also improved the catalytic efficiency and showed excellent reusability, stability, and reproducibility. In this study, the as-prepared bioreactor (10 mg) was successfully applied to the degradation of dyes and micropollutants, which has shown higher efficiency than free laccase in the large-scale decolorization of dyes and showed up to almost 100% removal of 2,4,6-trichlorophenol (2,4,6-TCP) and sulfisoxazole. Therefore, the MeS@Fe3+ with low cost, good stability and easy separation can be employed as a new enzyme carrier such as trypsin and lipase in biotechnological applications.

Graphical Abstract

Keywords

Enzyme immobilization Laccase Melamine sponge Dye Sulfonamides 2,4,6-TCP 

Notes

Acknowledgements

This work was financially supported by the National Natural Science Foundation of China (21575055).

Compliance with Ethical Standards

Conflict of interest

The authors declare that there is no conflict of interests regarding the publication of this paper.

Supplementary material

10562_2019_2732_MOESM1_ESM.doc (9.8 mb)
Supplementary material 1 (DOC 10017 KB)

References

  1. 1.
    Saito T, Hong P, Kato K et al (2003) Purification and characterization of an extracellular laccase of a fungus (family Chaetomiaceae) isolated from soil. Enzyme Microb Technol 33:520–526CrossRefGoogle Scholar
  2. 2.
    Baldrian P (2006) Fungal laccases - occurrence and properties. Fems Microbiol Rev 30:215–242CrossRefGoogle Scholar
  3. 3.
    Tavares APM, Gamelas JAF, Gaspar AR et al (2004) A novel approach for the oxidative catalysis employing polyoxometalate–laccase system: application to the oxygen bleaching of kraft pulp. Catal Commun 5:485–489CrossRefGoogle Scholar
  4. 4.
    Singh AD, Kumar SR (2010) Ligninolytic fungal laccases and their biotechnological applications. Appl Biochem Biotechnol 160:1760–1788CrossRefGoogle Scholar
  5. 5.
    Ghaly A, Ananthashankar R, Alhattab M et al (2014) Production, characterization and treatment of textile effluents: a critical review. J Chem Eng Process Technol 5:1–19Google Scholar
  6. 6.
    Jiang B, Li A et al. (2014) Biodegradation and metabolic pathway of sulfamethoxazole by Pseudomonas psychrophila HA-4, a newly isolated cold-adapted sulfamethoxazole-degrading bacterium. Appl Microb Biotechnol 98:4671–4681CrossRefGoogle Scholar
  7. 7.
    Tütem E, Apak R, Ünal Ç (1998) Adsorptive removal of chlorophenols from water by bituminous shale. Water Res 32:2315–2324CrossRefGoogle Scholar
  8. 8.
    Margot J, Kienle C, Magnet A et al (2013) Treatment of micropollutants in municipal wastewater: Ozone or powdered activated carbon? Sci Total Environ 461–462:480–498CrossRefGoogle Scholar
  9. 9.
    Petrie B, Barden R, Kasprzyk-Hordern B (2015) A review on emerging contaminants in wastewaters and the environment: Current knowledge, understudied areas and recommendations for future monitoring. Water Res 72:3–27CrossRefGoogle Scholar
  10. 10.
    Zhuo R, Yuan P, Yang Y et al (2016) Induction of laccase by metal ions and aromatic compounds in Pleurotus ostreatus HAUCC 162 and decolorization of different synthetic dyes by the extracellular laccase. Biochem Eng J 117:62–72CrossRefGoogle Scholar
  11. 11.
    Jin X, Yu X, Zhu G et al (2016) Conditions optimizing and application of Laccase-mediator System (LMS) for the laccase-catalyzed pesticide degradation. Sci Rep 6:35787–35793CrossRefGoogle Scholar
  12. 12.
    Margot J, Copin PJ, Gunten UV et al (2015) Sulfamethoxazole and isoproturon degradation and detoxification by a laccase-mediator system: Influence of treatment conditions and mechanistic aspects. Biochem Eng J 103:47–59CrossRefGoogle Scholar
  13. 13.
    Patel SK, Choi SH, Kang YC et al (2016) Eco-friendly composite of Fe3O4-reduced grapene oxide particles for efficient enzyme immobilization. ACS Appl Mater interfaces 9:2213–2222CrossRefGoogle Scholar
  14. 14.
    Samui A, Chowdhuri AR, Mahto TK et al (2016) Fabrication of a magnetic nanoparticle embedded NH2-MIL-88B MOF hybrid for highly efficient covalent immobilization of lipase. RSC Adv 6:66385–66393CrossRefGoogle Scholar
  15. 15.
    Fernandes RA, Daniel-Da-Silva AL, Tavares APM et al (2017) EDTA-Cu(II) chelating magnetic nanoparticles as a support for laccase immobilization. Chem Eng Sci 158:599–605CrossRefGoogle Scholar
  16. 16.
    Zhao M, Zhang X, Deng C (2015) Rational synthesis of novel recyclable Fe3O4@MOF nanocomposites for enzymatic digestion. Chem Commun 51:8116–8119CrossRefGoogle Scholar
  17. 17.
    Liu WL, Lo SH, Singco B et al (2013) Novel trypsin-FITC@MOF bioreactor efficiently catalyzes protein digestion. J Mater Chem B 1:928–932CrossRefGoogle Scholar
  18. 18.
    Ueda EK, Gout PW, Morganti L (2003) Current and prospective applications of metal ion–protein binding. J Chromatogr A 988:1–23CrossRefGoogle Scholar
  19. 19.
    Cao Y, Wu Z, Wang T et al (2016) Immobilization of Bacillus subtilis lipase on a Cu-BTC based hierarchically porous metal-organic framework material: a biocatalyst for esterification. Dalton Trans 45:6998–7003CrossRefGoogle Scholar
  20. 20.
    Wu X, Yang C, Ge J et al (2015) Polydopamine tethered enzyme/metal-organic framework composites with high stability and reusability. Nanoscale 7:18883–18886CrossRefGoogle Scholar
  21. 21.
    Huang WC, Wang W, Xue C et al (2018) Effective enzyme immobilization onto a magnetic chitin nanofiber composite. ACS Sustain Chem Eng 6:8118–8124CrossRefGoogle Scholar
  22. 22.
    Marciello M, Bolivar JM, Filice M et al (2013) Preparation of lipase-coated, stabilized, hydrophobic magnetic particles for reversible conjugation of biomacromolecules. Biomacromol 14:602–607CrossRefGoogle Scholar
  23. 23.
    Rong J, Zhang T, Qiu F et al (2017) Preparation of efficient, stable and reusable laccase-Cu3(PO4)2 hybrid microspheres based on copper foil for decolouration of Congo red. ACS Sustain Chem Eng 5:4468–4477CrossRefGoogle Scholar
  24. 24.
    Lonappan L, Liu Y, Rouissi T et al (2018) Covalent immobilization of laccase on citric acid functionalized micro-biochars derived from different feedstock and removal of diclofenac. Chem Eng J 351:985–994CrossRefGoogle Scholar
  25. 25.
    Kalantari M, Kazemeini M, Tabandeh F et al (2012) Lipase immobilisation on magnetic silica nanocomposite particles: effects of the silica structure on properties of the immobilised enzyme. J Mater Chem 22:8385–8393CrossRefGoogle Scholar
  26. 26.
    Kong L, Mume E, Triani G et al (2013) Optimizing radiolabeling amine-functionalized silica nanoparticles using SarAr-NCS for applications in imaging and radiotherapy. Langmuir 29:5609–5616CrossRefGoogle Scholar
  27. 27.
    Patel SKS, Anwar MZ, Kumar A et al (2018) Fe2O3 yolk-shell particle-based laccase biosensor for efficient detection of 2,6-dimethoxyphenol. Biochem Eng J 132:1–8CrossRefGoogle Scholar
  28. 28.
    Rouhani S, Rostami A, Salimi A et al (2018) Graphene oxide/CuFe2O4 nanocomposite as a novel scaffold for the immobilization of laccase and its application as a recyclable nanobiocatalyst for the green synthesis of arylsulfonyl benzenediols. Biochem Eng J 133:1–11CrossRefGoogle Scholar
  29. 29.
    Wang B, Shangguan L, Wang S et al (2016) Preparation and application of immobilized enzymatic reactors for consecutive digestion with two enzymes. J Chromatogr A 1477:22–29CrossRefGoogle Scholar
  30. 30.
    Arica MY, Salih B, Celikbicak O et al (2017) Immobilization of laccase on the fibrous polymer grafted film and studies of textile dyes degradation by MALDI-TOF-MS. Chem Eng Res Des 128:107–119CrossRefGoogle Scholar
  31. 31.
    Xu R, Cui J, Li F et al (2017) Removal of 2,4,6-trichlorophenol by laccase immobilized on nano-copper incorporated electrospun fibrous membrane-high efficiency, stability and reusability. Chem Eng J 326:647–655CrossRefGoogle Scholar
  32. 32.
    Linsha V, Shuhailath KA, Mahesh KV et al (2016) Biocatalytic conversion efficiency of steapsin lipase immobilized on hierarchically porous biomorphic aerogel supports. ACS Sustain Chem Eng 4:4692–4703CrossRefGoogle Scholar
  33. 33.
    Ruan C, Ai K, Li X et al (2014) A superhydrophobic sponge with excellent absorbency and flame retardancy. Angew Chem Int Ed 53:5556–5560CrossRefGoogle Scholar
  34. 34.
    Lei Z, Zhang G et al (2017) Thermo-responsive melamine sponges with switchable wettability by interface-initiated atom transfer radical polymerization for oil/water separation. ACS Appl Mater Interfaces 9:8967–8974CrossRefGoogle Scholar
  35. 35.
    Ding Y, Xu W, Ying Y et al (2018) One-step preparation of highly hydrophobic and oleophilic melamine sponges via metal-ion-induced wettability transition. ACS Appl Mater Interfaces 10:6652–6660CrossRefGoogle Scholar
  36. 36.
    Pham VH, Dickerson JH (2014) Superhydrophobic silanized melamine sponges as high efficiency oil absorbent materials. ACS Appl Mater Interfaces 6:14181–14188CrossRefGoogle Scholar
  37. 37.
    Lei Z, Deng Y, Wang C (2016) Ambient-temperature fabrication of melamine-based sponges coated with hydrophobic lignin shells by surface dip adsorbing for oil/water separation. RSC Adv 6:106928–106934CrossRefGoogle Scholar
  38. 38.
    Liu Q, Meng K, Ding K et al (2015) A superhydrophobic sponge with hierarchical structure as an efficient and recyclable oil absorbent. Chempluschem 80:1435–1439CrossRefGoogle Scholar
  39. 39.
    Zheng W, Li Q, Su L et al (2006) Direct electrochemistry of multi-copper oxidases at carbon nanotubes noncovalently functionalized with cellulose derivatives. Electroanalysis 18:587–594CrossRefGoogle Scholar
  40. 40.
    Nguyen TA, Fu CC, Juang RS (2016) Effective removal of sulfur dyes from water by biosorption and subsequent immobilized laccase degradation on crosslinked chitosan beads. Chem Eng J 304:313–324CrossRefGoogle Scholar
  41. 41.
    Bradford M (1976) A rapid and sensitive method for quantitation of microgram quantities of protein utilizing the principle of proteindye binding. Anal Biochem 72:248–254CrossRefGoogle Scholar
  42. 42.
    Bourbonnais R, Paice MG (1992) Demethylation and delignification of kraft pulp by Trametes versicolor laccase in the presence of 2,2′-azinobis-(3-ethylbenzthiazoline-6-sulphonate). Appl Microbiol Biotechnol 36:823–827CrossRefGoogle Scholar
  43. 43.
    Kadam AA, Jang J, Lee DS (2017) Supermagnetically tuned halloysite nanotubes functionalized with aminosilane for covalent laccase immobilization. ACS Appl Mater Interfaces 9:15492–15501CrossRefGoogle Scholar
  44. 44.
    Chao C, Liu J, Wang J et al (2013) Surface modification of halloysite nanotubes with dopamine for enzyme immobilization. ACS Appl Mater Interfaces 5:10559–10564CrossRefGoogle Scholar
  45. 45.
    Li Y, Lei X, Bo X et al (2017) Cellulose sponge supported palladium nanoparticles as recyclable cross-coupling catalysts. ACS Appl Mater Interfaces 9:17155–17162CrossRefGoogle Scholar
  46. 46.
    Papinutti VL, Forchiassin F (2010) Modification of malachite green by Fomes sclerodermeus and reduction of toxicity to Phanerochaete chrysosporium. Fems Microbiol Lett 231:205–209CrossRefGoogle Scholar
  47. 47.
    Kudanga T, Nyanhongo GS, Guebitz GM et al (2011) Potential applications of laccase-mediated coupling and grafting reactions: a review. Enzyme Microb Technol 48:195–208CrossRefGoogle Scholar
  48. 48.
    Chivukula M, Renganathan V (1996) Phenolic azo dye oxidation by laccase from Pyricularia oryzae. Appl Environ Microbiol 61:4374–4377Google Scholar
  49. 49.
    Telke AA, Joshi SM, Jadhav SU et al (2010) Decolorization and detoxification of Congo red and textile industry effluent by an isolated bacterium Pseudomonas sp. SU-EBT Biodegrad 21:283–296CrossRefGoogle Scholar
  50. 50.
    Sarma R, Islam MS, Miller AF et al (2017) Layer-by-layer assembled laccase enzyme on stimuli-responsive membranes for chloroorganics degradation. ACS Appl Mater Interfaces 9:14858–14867CrossRefGoogle Scholar
  51. 51.
    Zhu Y, Rong J, Zhang T et al (2017) Facile and controlled fabrication of Cu–Al layered double hydroxide nanosheets/laccase hybrid films: a route to efficient biocatalytic removal of congo red from aqueous solutions. ACS Appl Nano Mater 1:284–292CrossRefGoogle Scholar
  52. 52.
    Wang S, Chen W, He S et al (2014) Mesosilica-coated ultrafine fibers for highly efficient laccase encapsulation. Nanoscale 6:6468–6472CrossRefGoogle Scholar
  53. 53.
    Lin J, Fan L, Miao R et al (2015) Enhancing catalytic performance of laccase via immobilization on chitosan/CeO2 microspheres. Int J Biol Macromol 78:1–8CrossRefGoogle Scholar
  54. 54.
    Li G, Nandgaonkar AG, Wang Q et al (2017) Laccase-immobilized bacterial cellulose/TiO2 functionalized composite membranes: Evaluation for photo- and bio-catalytic dye degradation. J Membr Sci 525:89–98CrossRefGoogle Scholar

Copyright information

© Springer Science+Business Media, LLC, part of Springer Nature 2019

Authors and Affiliations

  1. 1.State Key Laboratory of Applied Organic Chemistry, College of Chemistry and Chemical EngineeringLanzhou UniversityLanzhouChina

Personalised recommendations