Green technology of liquid biphasic flotation for enzyme recovery utilizing recycling surfactant and sorbitol

  • Revathy Sankaran
  • Pau Loke Show
  • Yee Jiun Yap
  • Yang Tao
  • Tau Chuan Ling
  • Katsuda Tomohisa
Original Paper
  • 39 Downloads

Abstract

Liquid biphasic flotation (LBF) system has been recognized as an efficient, green, economically sustainable and biocompatible technique for biomolecules separation and purification. The main drawbacks of the conventional process of biomolecules separation are expensive production cost, utilization of phase components that are inefficiently recycled and global pollution due to high chemical consumption and wastage. In this paper, a novel approach of LBF system for lipase recovery utilizing recycling phase components comprising surfactant and xylitol was investigated. The scope of this study focuses on pollution prevention as well as clean and environmentally friendly process for enzyme extraction via LBF. The green process proposed in this study uses phase-forming components that have recovery and recycling abilities for minimal use of chemicals for enzyme extraction. This novel method utilized Triton X-100 and xylitol for lipase extraction from Burkholderia cepacia. A few parameters were optimized to obtain high lipase separation efficiency and yield. Based on the ideal conditions of LBF, the average lipase separation efficiency and yield are 86.46 and 87.49%, correspondingly. Phase components recycling were proposed in order to reduce the chemicals consumption in LBF system. Upscaling of the recycling study exhibited consistent result with the laboratory scale. It was found that 97.20 and 98.67% of Triton X-100 and xylitol were recovered after five times of recycling and that a total of 75.87% of lipase separation efficiency was obtained. Recovery and recycling of phase components in the extraction process are established as the principal green chemistry method, which yields high separation efficiency and is economically feasible on an industrial scale.

Keywords

Liquid biphasic flotation Green Recycling phase components Surfactant Xylitol 

Notes

Acknowledgements

This study is supported by the Fundamental Research Grant Scheme (Malaysia, FRGS/1/2015/SG05/UNIM/03/1), the Ministry of Science and Technology (MOSTI 02-02-12-SF0256), the Prototype Research Grant Scheme (PRGS/2/2015/SG05/UNIM/03/1) and SATU Joint Research Scheme (RU022E-2014 and RU018-2015).

References

  1. Amid M, Manap MY, Hussin M, Mustafa S (2015a) A novel aqueous two phase system composed of surfactant and xylitol for the purification of lipase from pumpkin (Cucurbita moschata) seeds and recycling of phase components. Molecules 20:11184–11201.  https://doi.org/10.3390/molecules200611184 CrossRefGoogle Scholar
  2. Amid M, Murshid FS, Manap MY, Hussin M (2015b) A novel aqueous micellar two-phase system composed of surfactant and sorbitol for purification of pectinase enzyme from psidium guajava and recycling phase components. Biomed Res Int.  https://doi.org/10.1155/2015/815413 Google Scholar
  3. Andualema B, Gessesse A (2012) Microbial lipase and their industrial applications: review. Biotechnology 11:100–118CrossRefGoogle Scholar
  4. Antov MG (2004) Partitioning of pectinase produced by Polyporus squamosus in aqueous two-phase system polyethylene glycol 4000/crude dextran at different initial pH values. Carbohydr Polym 56:295–300.  https://doi.org/10.1016/j.carbpol.2003.12.008 CrossRefGoogle Scholar
  5. Bi PY, Li DQ, Dong HR (2009) A novel technique for the separation and concentration of penicillin G from fermentation broth: aqueous two-phase flotation. Sep Purif Technol 69:205–209.  https://doi.org/10.1016/j.seppur.2009.07.019 CrossRefGoogle Scholar
  6. Bi PY, Chang L, Mu YL et al (2013) Separation and concentration of baicalin from Scutellaria Baicalensis Georgi extract by aqueous two-phase flotation. Sep Purif Technol 116:454–457.  https://doi.org/10.1016/j.seppur.2013.06.024 CrossRefGoogle Scholar
  7. da Padilha GS, Santana JCC, Alegre RM, Tambourgi EB (2012) Extraction of lipase from Burkholderia cepacia by PEG/Phosphate ATPS and its biochemical characterization. Braz Arch Biol Technol 55:7–19.  https://doi.org/10.1590/S1516-89132012000100002 CrossRefGoogle Scholar
  8. De Albuquerque TL, Da Silva IJ, De MacEdo GR, Rocha MVP (2014) Biotechnological production of xylitol from lignocellulosic wastes: a review. Process Biochem 49:1779–1789.  https://doi.org/10.1016/j.procbio.2014.07.010 CrossRefGoogle Scholar
  9. Diaz JCM, Cordova J, Baratti J et al (2007) Effect of nonionic surfactants on Rhizopus homothallicus lipase activity: a comparative kinetic study. Mol Biotechnol 35:205–214.  https://doi.org/10.1007/s12033-007-9000-0 CrossRefGoogle Scholar
  10. Dos Prazeres JN, Cruz JAB, Pastore GM (2006) Characterization of alkaline lipase from Fusarium oxysporum and the effect of different surfactants and detergents on the enzyme activity. Braz J Microbiol 37:505–509.  https://doi.org/10.1590/S1517-83822006000400019 CrossRefGoogle Scholar
  11. Glogauer A, Martini VP, Faoro H et al (2011) Identification and characterization of a new true lipase isolated through metagenomic approach. Microb Cell Fact 10:54.  https://doi.org/10.1186/1475-2859-10-54 CrossRefGoogle Scholar
  12. Granström TB, Izumori K, Leisola M (2007) A rare sugar xylitol. Part II: biotechnological production and future applications of xylitol. Appl Microbiol Biotechnol 74:273–276.  https://doi.org/10.1007/s00253-006-0760-4 CrossRefGoogle Scholar
  13. Gupta R, Gupta N, Rathi P (2004) Bacterial lipases: an overview of production, purification and biochemical properties. Appl Microbiol Biotechnol 64:763–781.  https://doi.org/10.1007/s00253-004-1568-8 CrossRefGoogle Scholar
  14. Gururaj P, Ramalingam S, Nandhinidevi G, Gautam P (2016) Process optimization for production and purification of a thermostable, organic solvent tolerant lipase from Acinetobacter sp. AU07. Braz J Microbiol 47:647–657.  https://doi.org/10.1016/j.bjm.2015.04.002 CrossRefGoogle Scholar
  15. Han J, Wang Y, Yu C et al (2011) Separation, concentration and determination of chloramphenicol in environment and food using an ionic liquid/salt aqueous two-phase flotation system coupled with high-performance liquid chromatography. Anal Chim Acta 685:138–145.  https://doi.org/10.1016/j.aca.2010.11.033 CrossRefGoogle Scholar
  16. Ishimoto R, Sugimoto M, Kawai F (2001) Screening and characterization of trehalose-oleate hydrolyzing lipase. FEMS Microbiol Lett 195:231–235.  https://doi.org/10.1016/S0378-1097(01)00016-7 CrossRefGoogle Scholar
  17. Iyer PV, Ananthanarayan L (2008) Enzyme stability and stabilization–Aqueous and non-aqueous environment. Process Biochem 43:1019–1032.  https://doi.org/10.1016/j.procbio.2008.06.004 CrossRefGoogle Scholar
  18. Kaushik JK, Bhat R (1998) Thermal stability of proteins in aqueous polyol solutions: role of the surface tension of water in the stabilizing effect of polyols. J Phys Chem B 102:7058–7066.  https://doi.org/10.1021/jp981119l CrossRefGoogle Scholar
  19. Kaushik V, Roos YH (2007) Limonene encapsulation in freeze-drying of gum Arabic–sucrose–gelatin systems. LWT—Food Sci Technol 40:1381–1391.  https://doi.org/10.1016/j.lwt.2006.10.008 Google Scholar
  20. Ketnawa S, Benjakul S, Ling TC et al (2013) Enhanced recovery of alkaline protease from fish viscera by phase partitioning and its application. Chem Cent J 7:79.  https://doi.org/10.1186/1752-153X-7-79 CrossRefGoogle Scholar
  21. Ketnawa S, Rungraeng N, Rawdkuen S (2017) Phase partitioning for enzyme separation: an overview and recent applications. Int Food Res 24:1–24Google Scholar
  22. Lee SY, Khoiroh I, Ling TC, Show PL (2016) Aqueous two-phase flotation for the recovery of biomolecules. Sep Purif Rev 45:81–92.  https://doi.org/10.1080/15422119.2015.1007147 CrossRefGoogle Scholar
  23. Li M, Dong H (2010) The investigation on the aqueous two-phase floatation of lincomycin. Sep Purif Technol 73:208–212.  https://doi.org/10.1016/j.seppur.2010.04.002 CrossRefGoogle Scholar
  24. Lin YK, Show PL, Yap YJ et al (2015) Direct recovery of cyclodextringlycosyltransferase from Bacillus cereus using aqueous two-phase flotation. J Biosci Bioeng 120:684–689.  https://doi.org/10.1016/j.jbiosc.2015.04.013 CrossRefGoogle Scholar
  25. Mathiazakan P, Shing SY, Ying SS et al (2016) Pilot scale aqueous two-phase floatation for direct recovery of lipase derived from Burkholderia cepacia strain ST8. Sep Purif Technol 171:206–213.  https://doi.org/10.1016/j.seppur.2016.07.017 CrossRefGoogle Scholar
  26. Md Sidek NL, Tan JS, Abbasiliasi S et al (2016) Aqueous two-phase flotation for primary recovery of bacteriocin-like inhibitory substance (BLIS) from Pediococcus acidilactici Kp10. J Chromatogr B 1027:81–87.  https://doi.org/10.1016/j.jchromb.2016.05.024 CrossRefGoogle Scholar
  27. Nfor BK, Ahamed T, van Dedem GW et al (2008) Design strategies for integrated protein purification processes: challenges, progress and outlook. J Chem Technol Biotechnol 83:124–132.  https://doi.org/10.1002/jctb.1815 CrossRefGoogle Scholar
  28. Ooi CW, Tey BT, Hii SL et al (2009a) Purification of lipase derived from Burkholderia pseudomallei with alcohol/salt-based aqueous two-phase systems. Process Biochem 44:1083–1087.  https://doi.org/10.1016/j.procbio.2009.05.008 CrossRefGoogle Scholar
  29. Ooi CW, Tey BT, Hii SL et al (2009b) Direct purification of Burkholderia Pseudomallei lipase from fermentation broth using aqueous two-phase systems. Biotechnol Bioprocess Eng 14:811–818.  https://doi.org/10.1007/s12257-008-0306-y CrossRefGoogle Scholar
  30. Ooi CW, Hii SL, Kamal SMM et al (2011) Extractive fermentation using aqueous two-phase systems for integrated production and purification of extracellular lipase derived from Burkholderia pseudomallei. Process Biochem 46:68–73.  https://doi.org/10.1016/j.procbio.2010.07.014 CrossRefGoogle Scholar
  31. Ramakrishnan V, Goveas LC, Suralikerimath N et al (2016) Extraction and purification of lipase from Enterococcus faecium MTCC5695 by PEG/phosphate aqueous-two phase system (ATPS) and its biochemical characterization. Biocatal Agric Biotechnol 6:19–27.  https://doi.org/10.1016/j.bcab.2016.02.005 Google Scholar
  32. Salabat A, Moghadam ST, Far MR (2010) Liquid-liquid equilibria of aqueous two-phase systems composed of TritonX-100 and sodium citrate or magnesium sulfate salts. Calphad-Comput Coupling Phase Diagr Thermochem 34:81–83.  https://doi.org/10.1016/j.calphad.2009.12.004 CrossRefGoogle Scholar
  33. Salameh MA, Wiegel J (2010) Effects of detergents on activity, thermostability and aggregation of two alkalithermophilic lipases from Thermosyntropha lipolytica. Open Biochem J 4:22–28.  https://doi.org/10.2174/1874091X01004010022 CrossRefGoogle Scholar
  34. Sankaran R, Show PL, Lee SY et al (2018) Integration process of fermentation and liquid biphasic flotation for lipase separation from Burkholderia cepacia. Bioresour Technol 250:306–316.  https://doi.org/10.1016/j.biortech.2017.11.050 CrossRefGoogle Scholar
  35. Sharma R, Chisti Y, Chand U (2001) Production, purification, characterization, and applications of lipases. Biotechnol Adv 19:627–662.  https://doi.org/10.1016/S0734-9750(01)00086-6 CrossRefGoogle Scholar
  36. Show PL, Tan CP, Anuar MS et al (2011) Direct recovery of lipase derived from Burkholderia cepacia in recycling aqueous two-phase flotation. Sep Purif Technol 80:577–584.  https://doi.org/10.1016/j.seppur.2011.06.013 CrossRefGoogle Scholar
  37. Show PL, Ooi CW, Anuar MS et al (2013) Recovery of lipase derived from Burkholderia cenocepacia ST8 using sustainable aqueous two-phase flotation composed of recycling hydrophilic organic solvent and inorganic salt. Sep Purif Technol 110:112–118.  https://doi.org/10.1016/j.seppur.2013.03.018 CrossRefGoogle Scholar
  38. Show P, Ling T, Lan JC et al (2015) Review of microbial lipase purification using aqueous two-phase systems. Curr Org Chem 19:19–29CrossRefGoogle Scholar
  39. Tan JS, Abbasiliasi S, Lin YK et al (2014) Primary recovery of thermostable lipase 42 derived from recombinant Escherichia coli BL21 in aqueous two-phase flotation. Sep Purif Technol 133:328–334.  https://doi.org/10.1016/j.seppur.2014.06.048 CrossRefGoogle Scholar
  40. Wingfield P (1998) Protein precipitation using ammonium sulfate. In: Current protocols in protein science. Wiley, Hoboken, pp A.3F.1–A.3F.8Google Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  1. 1.Department of Chemical and Environmental Engineering, Faculty of EngineeringUniversity of Nottingham Malaysia CampusSemenyihMalaysia
  2. 2.Department of Applied Mathematics, Faculty of EngineeringUniversity of Nottingham Malaysia CampusSemenyihMalaysia
  3. 3.College of Food Science and TechnologyNanjing Agricultural UniversityNanjingChina
  4. 4.Faculty of Science, Institute of Biological SciencesUniversity of MalayaKuala LumpurMalaysia
  5. 5.Department of Chemical Science and EngineeringKobe UniversityKobeJapan

Personalised recommendations