Advertisement

Granular Matter

, 20:51 | Cite as

Effect of sand and clay fouling on the shear strength of railway ballast for different ballast gradations

  • Akbar Danesh
  • Massoud Palassi
  • Ali Asghar Mirghasemi
Original Paper
  • 69 Downloads

Abstract

Ballast contamination by fine materials such as sand and clay in railway track at arid regions is an important issue that causes track instability problems and settlement due to reduction of shear strength of ballast. In this paper, the results of direct shear box test conducted on clean ballast, sand-fouled ballast and clay-fouled ballast for different ballast gradations are reported and discussed. For this purpose, three different fouling amounts according to fouling index are added to clean ballast. Test results show that by increasing the fouling percentage, the ballast shear strength always decreases both for sand and clay fouled ballast. However, the amount of shear strength reduction is low at high normal stresses. Clay contamination has more adverse effect on the shear strength of ballast compared with sand contamination. Also, the results of tests for evaluation of gradation effect on shear strength of fouled ballast which are conducted on various gradations according to American Railway Engineering and Maintenance-of-Way Association, show that the maximum particle size as well as uniformity coefficient affect the shear strength of ballast. Also, an empirical equation is presented to observe the effect of ballast gradation on reduction of shear strength with regard to amount of fouling material and normal stress.

Keywords

Ballast shear strength Fouling materials Ballast gradation Direct shear box test 

Notes

Compliance with ethical standards

Conflict of interest

The authors declare that they have no conflict of interest.

References

  1. 1.
    Selig, E.T., Waters, J.M.: Track Geotechnology and Substructure Management. Thomas Telford Services, London (1994)CrossRefGoogle Scholar
  2. 2.
    Ovalle, C., Frossard, E., Dano, C., Hu, W., Maiolino, S., Hicher, P.Y.: The effect of size on the strength of coarse rock aggregates and large rockfill samples through experimental data. Acta Mech. 225(8), 2199–2216 (2014)CrossRefMATHGoogle Scholar
  3. 3.
    Guo, P., Su, X.: Shear strength, interparticle locking, and dilatancy of granular materials. Can. Geotech. J. 44(5), 579–591 (2007)CrossRefGoogle Scholar
  4. 4.
    Alshibli, K.A., Sture, S.: Shear band formation in plane strain experiments of sand. J. Geotech. Geoenviron. Eng. 126(6), 495–503 (2000)CrossRefGoogle Scholar
  5. 5.
    Mair, K., Frye, K.M., Marone, C.: Influence of grain characteristics on the friction of granular shear zones. J. Geophys. Res. Solid Earth 107(B10), 2219 (2002)CrossRefADSGoogle Scholar
  6. 6.
    Dai, B.B., Yang, J., Zhou, C.Y.: Observed effects of interparticle friction and particle size on shear behavior of granular materials. Int. J. Geomech. 16(1), 04015011 (2015)CrossRefGoogle Scholar
  7. 7.
    Marsal, R.J.: Large-scale testing of rockfill materials. J. Soil Mech. Found. Div. 93(2), 27–43 (1967)Google Scholar
  8. 8.
    Marschi, N.D., Chan, C.K., Seed, H.B.: Evaluation of properties of rockfill materials. J. Soil Mech. Found. Div. 98(1), 95–114 (1972)Google Scholar
  9. 9.
    Charles, J.A., Watts, K.S.: The influence of confining pressure on the shear strength of compacted rockfill. Geotechnique 30(4), 353–367 (1980)CrossRefGoogle Scholar
  10. 10.
    Kokusho, T., Hara, T., Hiraoka, R.: Undrained shear strength of granular soils with different particle gradations. J. Geotech. Geoenviron. Eng. 130(6), 621–629 (2004)CrossRefGoogle Scholar
  11. 11.
    Hamidi, A., Azini, E., Masoudi, B.: Impact of gradation on the shear strength-dilation behavior of well graded sand–gravel mixtures. Sci. Iran. 19(3), 393–402 (2012)CrossRefGoogle Scholar
  12. 12.
    Richefeu, V., Youssoufi, M.S., Radjai, F.: Shear strength properties of wet granular materials. Phys. Rev. E 73(5), 051304 (2006)CrossRefADSGoogle Scholar
  13. 13.
    Trinh, V.N., Tang, A.M., Cui, Y.J., Dupla, J.C., Canou, J., Calon, N., Lambert, L., Robinet, A., Schoen, O.: Mechanical characterisation of the fouled ballast in ancient railway track substructure by large-scale triaxial tests. Soils Found. 52(3), 511–523 (2012)CrossRefGoogle Scholar
  14. 14.
    Ebrahimi, A., Tinjum, J.M., Edil, T.B.: Large-scale cyclic triaxial testing of rail ballast. In: Proceedings of the AREMA Annual Conference, Orlando, Florida (2010)Google Scholar
  15. 15.
    Qian, Y., Mishra, D., Tutumluer, E., Kazmee, H.A.: Characterization of geogrid reinforced ballast behavior at different levels of degradation through triaxial shear strength test and discrete element modeling. Geotext. Geomembr. 43(5), 393–402 (2015)CrossRefGoogle Scholar
  16. 16.
    Han, X., Selig, E.T.: Effects of fouling on ballast settlement. In: Proceeding of 6th International Heavy Haul Railway Conference, Cape Town. South Africa (1997)Google Scholar
  17. 17.
    Salim, M.W.: Deformation and degradation aspects of ballast and constitutive modeling under cyclic loading. Thesis (Ph.D.). University of Wollongong (2004)Google Scholar
  18. 18.
    Shi, X.: Prediction of permanent deformation in railway track. Thesis (Ph.D.), University of Nottingham (2009)Google Scholar
  19. 19.
    Tutumluer, E., Dombrow, W., Huang, H.: Laboratory characterization of coal dust fouled ballast. In: AREMA 2008 Annual Conference and Exhibition, Salt Lake City, UT (2008)Google Scholar
  20. 20.
    Nimbalkar, S.S., Indraratna, B., Rujikiatkamjorn, C., Martin, M.: Effect of coal fines on the shear strength and deformation characteristics of ballast. In: Proceeding of 11th Australia–New Zealand Conference on Geomechanics, Melbourne, Australia (2012)Google Scholar
  21. 21.
    Huang, H., Tutumluer, E., Dombrow, W.: Laboratory characterization of fouled railway ballast behavior. Transp. Res. Rec. J. Transp. Res. Board 2117, 93–101 (2009)CrossRefGoogle Scholar
  22. 22.
    Tennakoon, N., Indraratna, B., Rujikiatkamjorn, C.: Effect of ballast contamination on the behavior of track substructure. Aust. Geomech. J. 49, 113–123 (2014)Google Scholar
  23. 23.
    Qian, Y., Tutumluer, E., Hashash, Y.M., Ghaboussi, J.: Effects of ballast degradation on permanent deformation behavior from large-scale triaxial tests. In: Proceeding of the 2014 Joint Rail Conference, Colorado Springs, USA (2014)Google Scholar
  24. 24.
    Danesh, A., Palassi, M., Mirghasemi, A.A.: Evaluating the influence of ballast degradation on its shear behaviour. Int. J. Rail. Transp. 1, 1–18 (2017).  https://doi.org/10.1080/23248378.2017.1411212 Google Scholar
  25. 25.
    Babic, B., Prager, A., Rukavina, T.: Effect of fine particles on some characteristics of granular base courses. Mater. Struct. 33(7), 419–424 (2000)CrossRefGoogle Scholar
  26. 26.
    Vallejo, L.E.: Interpretation of the limits in shear strength in binary granular mixtures. Can. Geotech. J. 38, 1097–1104 (2001)CrossRefGoogle Scholar
  27. 27.
    Salgado, R., Bandini, P., Karim, A.: Shear strength and stiffness of silty sand. J. Geotech. Geoenviron. Eng. 126(5), 451–462 (2000)CrossRefGoogle Scholar
  28. 28.
    Georgiannou, V.N., Burland, J.B., Hight, D.W.: The undrained behaviour of clayey sands in triaxial compression and extension. Geotechnique 40(3), 431–449 (1990)CrossRefGoogle Scholar
  29. 29.
    Kumar, G.V., Wood, M.D.: Fall cone and compression tests on clay–gravel mixtures. Geotechnique 49(6), 727–739 (1999)CrossRefGoogle Scholar
  30. 30.
    Vallejo, L.E., Mawby, R.: Porosity influence on the shear strength of granular material–clay mixtures. Eng. Geol. 58, 125–136 (2000)CrossRefGoogle Scholar
  31. 31.
    Kim, D., Sagong, M., Lee, Y.: Effects of fine aggregate content on the mechanical properties of the compacted decomposed granitic soils. Constr. Build. Mater. 19(3), 189–196 (2005)CrossRefGoogle Scholar
  32. 32.
    Tutumluer, E., Huang, H., Hashash, Y.M.A., Ghaboussi, J.: Laboratory characterization of coal dust fouled ballast behaviour. In: Proceedings of the AREMA Annual Conference, UT, Salt Lake City (2008)Google Scholar
  33. 33.
    Indraratna, B., Lackenby, J., Christie, D.: Effect of confining pressure on the degradation of ballast under cyclic loading. Geotechnique 55(4), 325–328 (2005)CrossRefGoogle Scholar
  34. 34.
    Koohmishi, M., Palassi, M.: Effect of particle size distribution and subgrade condition on degradation of railway ballast under impact loads. Granul. Matter 19(3), 63 (2017)CrossRefGoogle Scholar
  35. 35.
    Nålsund, R.: Effect of grading on degradation of crushed-rock railway ballast and on permanent axial deformation. Transp. Res. Rec. J. Transp. Res. Board 2154, 149–155 (2010)CrossRefGoogle Scholar
  36. 36.
    Indraratna, B., Sun, Y., Nimbalkar, S.: Laboratory assessment of the role of particle size distribution on the deformation and degradation of ballast under cyclic loading. J. Geotech. Geoenviron. Eng. 142(7), 04016016 (2016)CrossRefGoogle Scholar
  37. 37.
    Dombrow, D., Huang, H., Tutumluer, E.: Comparison of coal dust fouled railroad ballast behavior—granite vs. limestone. In: Tutumluer, A.-Q. (ed.) Bearing Capacity of Roads, Railways and Airfields, pp. 1349–1357. Taylor and Francis Group, Milton Park (2009)Google Scholar
  38. 38.
    Arslan, H., Baykal, G., Sture, S.: Analysis of the influence of crushing on the behavior of granular materials under shear. Granul. Matter 11(2), 87–97 (2009)CrossRefGoogle Scholar
  39. 39.
    Arulrajah, A., Rahman, M.A., Piratheepan, J., Bo, M.W., Imteaz, M.A.: Evaluation of interface shear strength properties of geogrid-reinforced construction and demolition materials using a modified large scale direct shear testing apparatus. J. Mater. Civil. Eng. 26(5), 974–982 (2013)CrossRefGoogle Scholar
  40. 40.
    Biabani, M.M., Indraratna, B.: An evaluation of the interface behaviour of rail subballast stabilised with geogrids and geomembranes. Geotext. Geomembr. 43(3), 240–249 (2015)CrossRefGoogle Scholar
  41. 41.
    Norbury, D., Hencher, S., Cripps, J., Lumsden, A.: The description and classification of weathered rocks for engineering purposes. Q. J. Eng. Geol. 28, 207–242 (1995)CrossRefGoogle Scholar
  42. 42.
    Stahl, M., Konietzky, H.: Discrete element simulation of ballast and gravel under special consideration of grain-shape, grain-size and relative density. Granul. Matter 13(4), 417–428 (2011)CrossRefGoogle Scholar
  43. 43.
    Mishra, D., Mahmud, S.N.: Effect of particle size and shape characteristics on ballast shear strength, a numerical study using the direct shear test. In: Proceeding of the 2017 Joint Rail Conference, Philadelphia, USA (2017)Google Scholar
  44. 44.
    Wang, P., Liu, J., Tian, Z., Li, X.: Experimental study on mechanical and degradation characteristics of crushed rock aggregate. Transp. Res. Rec. J. Transp. Res. Board 2578, 38–46 (2016)CrossRefGoogle Scholar
  45. 45.
    Liu, J., Wang, P., Liu, J.: Macro-and micro-mechanical characteristics of crushed rock aggregate subjected to direct shearing. Transp. Geotech. 2, 10–19 (2015)CrossRefGoogle Scholar
  46. 46.
    Ngo, N.T., Indraratna, B., Rujikiatkamjorn, C.: DEM simulation of the behaviour of geogrid stabilised ballast fouled with coal. Comput. Geotech. 55, 224–231 (2014)CrossRefGoogle Scholar
  47. 47.
    Dash, S.K., Shivadas, A.S.: Performance improvement of railway ballast using geocells. Indian Geotech. J. 42(3), 186–193 (2012)CrossRefGoogle Scholar
  48. 48.
    Wang, Z., Jing, G., Yu, Q., Yin, H.: Analysis of ballast direct shear tests by discrete element method under different normal stress. Measurement 63, 17–24 (2015)CrossRefGoogle Scholar
  49. 49.
    Bagherzadeh-Khalkhali, A., Mirghasemi, A.A.: Numerical and experimental direct shear tests for coarse-grained soils. Particuology 7(1), 83–91 (2009)CrossRefGoogle Scholar
  50. 50.
    Yan, W.M., Dong, J.: Effect of particle grading on the response of an idealized granular assemblage. Int. J. Geomech. 11(4), 276–285 (2011)CrossRefGoogle Scholar
  51. 51.
    Esmaeili, M., Zakeri, J.A., Mosayebi, S.A.: Effect of sand-fouled ballast on train-induced vibration. Int. J. Pavement Eng. 15(7), 635–644 (2014)CrossRefGoogle Scholar
  52. 52.
    Indraratna, B., Ngo, N.T., Rujikiatkamjorn, C.: Behavior of geogrid-reinforced ballast under various level of fouling. Geotext. Geomembr. 29(3), 313–322 (2011)CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  1. 1.School of Civil Engineering, College of EngineeringUniversity of TehranTehranIran

Personalised recommendations