Advertisement

Effect of cobalt on the activity of dual phase “(Gd0.6Sr0.4)0.99Fe1-xCoxO3-δ” SOFC cathodes

  • K. Kammer HansenEmail author
  • R. Sazinas
Original Paper
  • 11 Downloads

Abstract

The effect of the amount of cobalt in (Gd0.6Sr0.4)0.99Fe1-xCoxO3-δ solid oxide fuel cell (SOFC) cathodes (x = 0.00, 0.05, 0.10, 0.15, 0.20 and 0.25) was studied by powder X-ray diffraction (XRD), scanning electron microscopy (SEM), dilatometry, four-point DC conductivity measurements, cone-shaped electrodes, and electrochemical impedance spectroscopy (EIS). XRD and scanning electron microscopy revealed two phases: a cubic phase and an orthorhombic phase. One phase has a small particle size (cubic phase), and the other phase (orthorhombic) has a larger particle size. Dilatometry indicated that the thermal expansion coefficient increased with increasing Co content. The electrical conductivity maximum for the Co-rich compound was found to have a value of 82 S cm−1 at approximately 300 °C. It was shown that the activity of the cathodes was strongly dependent on the amount of cobalt. The highest activity was found for the cobalt-rich compound (Gd0.6Sr0.4)0.99Fe0.75Co0.25O3-δ with an area-specific resistance of 0.9 Ωcm2 at 600 °C, measured on a cone-shaped electrode in air.

Notes

References

  1. 1.
    Minh NQ, Takahashi T (1995) Science and technology of ceramic fuel cells. Elsevier Science B.V., AmsterdamGoogle Scholar
  2. 2.
    Minh NQ (1993) Ceramic Fuel Cells. J Am Ceram Soc 76(3):563–588Google Scholar
  3. 3.
    Ralph JM, Rossignol C, Kumar R (2003) Cathode Materials for Reduced-Temperature SOFCs. J Electrochem Soc 150(11):A1518Google Scholar
  4. 4.
    Hansen KK (2006) Studies of Fe–Co based perovskite cathodes with different A-site cations. Solid State Ionics 177:1047Google Scholar
  5. 5.
    Fabry P, Kleitz M (1974) Influence of metal and electrolyte-composition on characteristics of oxygen electrode-reaction on solid oxide electrolyte. Electroanal Chem Interfac Electrochem 57(2):165–177Google Scholar
  6. 6.
    Newman J (1966) Resistance for Flow of Current to a Disk. J Electrochem Soc 113(5):501Google Scholar
  7. 7.
    Hansen KK, Søgaard M, Mogensen M (2007) Gd0.6Sr0.4Fe0.8Co0.2O3-d: A Novel type of SOFC Cathode. Electrochem Solid-State Lett 10(8):B119–B121Google Scholar
  8. 8.
    Hansen KK, Hansen KV, Mogensen M (2010) High Performance Fe-Co based SOFC Cathodes. J Solid State Electrochem 14(11):2107–2112Google Scholar
  9. 9.
    Hansen KK (2018) Studies of A-site deficient (Gd0.6Sr0.4)1-sFe0.8Co0.2O3-d cathodes in SOFCs. Fuel Cells 18(1):96–100Google Scholar
  10. 10.
    Hansen KK (2017) Cone-Shaped Gd1-xSrxFe0.8Co0.2O3-d Electrodes for SOFC Cathodes. Int J Electrochem Sci 12:11540–11545Google Scholar
  11. 11.
    Chick LA, Pederson LR, Maupin GD, Bates JL, Thomas LE, Exarhos GJ (1990) Glycine nitrate combustion synthesis of oxide ceramic powders. Mater Lett 10(1-2):6–12Google Scholar
  12. 12.
    Juhl M, Mogensen M, Jacobsen T, Zachau-Christiansen B, Thorup N, Skou E (1986) Electrochemical Characterization of Cathode Materials with Pointed Electrodes. In solid oxide fuel cells IV, PV-95-1, 554, the electrochemical society proceedings series, Pennington, NJ (1995)Google Scholar
  13. 13.
    Boukamp BA (1986) A nonlinear least squares fit procedure for analysis of immittance data of electrochemical systems. Solid State Ionics 20(1):31–44Google Scholar
  14. 14.
    Wimmer JM, Bransky I (1971) Chapter in Tallan NM (ed) Electrical conductivity in ceramics and glass. Pergamon Press, New YorkGoogle Scholar
  15. 15.
    Siebert E, Hammouche A, Kleitz M (1995) Impedance spectroscopy analysis of La1 − xSrxMnO3-yttria-stabilized zirconia electrode kinetics. Electrochim Acta 40(11):1741–1753Google Scholar
  16. 16.
    Robertson NL, Michaels JN (1991) Double layer capacitance of porous platinum electrodes in zirconia electrochemical cells. J Electrochem Soc 138(5):1494Google Scholar
  17. 17.
    Torres-Garibay C, Kovar D, Manthiram A (2009) Ln(0.6)Sr(0.4)Co(1-y)Fe(y)O(3-delta) (Ln = La and Nd; y=0 and 0.5) cathodes with thin yttria-stabilized zirconia electrolytes for intermediate temperature solid oxide fuel cells. J Power Sources 187(2):480–486Google Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  1. 1.Department of Energy Conversion and StorageTechnical University of DenmarkRoskildeDenmark

Personalised recommendations