Advertisement

Experiments in Fluids

, 60:140 | Cite as

Control of droplet movement on a plate with micro-wrinkle by difference of wettability

  • Kenji KatohEmail author
  • Eriko Sato
  • Shin’ya Yoshioka
  • Tatsuro Wakimoto
Research Article

Abstract

In this study, we consider the control of a liquid droplet movement rolling down on an inclined plate with gravitational force using a micro-wrinkle on a wall. The micro-wrinkle was manufactured by the buckling of a thin polymer film (poly(N-vinylcarbazole), PVK) on a base polymer (poly(vinyl chloride), PVC). The PVC was stretched once and then PVK (~ 100-nm thickness) was spin-coated on the surface of the base polymer at ambient temperature. When the strain was released in a thermostatic chamber heated above the glass transition temperature of PVC, a two-dimensional micro-wrinkle having a wavelength of several micrometers was formed on the surface. The advancing and receding contact angles were measured in directions parallel and perpendicular to the wrinkle. It was observed that there were several degrees of contact angle anisotropy. When the droplet was set on the wrinkle surface inclined at 45° to the gravitational force, the direction of droplet movement could be changed by ~ 20° from the gravitational direction. The deflection angle was estimated from a theoretical model with the principle of minimum work of the contact line.

Graphic abstract

The micro-wrinkle was manufactured by the buckling of a thin polymer film (poly(N-vinylcarbazole), PVK) on a base polymer (poly(vinyl chloride), PVC). It was observed that there were several degrees of contact angle anisotropy dependent on the direction in normal and parallel to the wrinkle. When the droplet was set on the oblique wrinkle, the direction of droplet sliding movement could be changed by ~20° from the gravitational direction in the plane as shown in the figure below. The deflection angle β can be roughly estimated from a theoretical model with the principle of minimum work of the droplet.

List of symbols

Roman symbols

E

Energy change of droplet per unit length [J/m]

EP

Potential energy change of droplet per unit length [J/m]

FPS

Drag of surface tension parallel to wrinkle [N]

FVS

Drag of surface tension perpendicular to wrinkle [N]

g

Gravitational acceleration [m/s2]

r

Coordinate in radial direction

Ra

Arithmetic average roughness [m]

s

Coordinate along contact line [m]

V

Liquid volume [m3]

W

Droplet width [m]

z

Coordinate in the upward direction from top of droplet [m]

Greek symbols

α

Oblique angle of micro-wrinkle [°]

β

Deflection angle of moving droplet [°]

η

Azimuthal angle on contact line [°]

θ

Local contact angle [°]

ρ

Liquid density [kg/m3]

σ

Surface tension [N/m]

φ

Critical sliding angle of droplet [°]

Subscripts

A

Advancing

P

Parallel to wrinkle

V

Perpendicular to wrinkle

R

Receding

Notes

Acknowledgements

The authors are grateful to Mr. Ryohei Tanino for his effort in the experimental measurements.

References

  1. Abdelgawad M, Park P, Wheeler R (2009) Optimization of device geometry in single-plate digital microfluidics. J Applied Phys 105:094506.  https://doi.org/10.1063/1.3117216 CrossRefGoogle Scholar
  2. Abgrall P, Gué AM (2007) Lab-on-chip technologies: making a microfluidic network and coupling it into a complete microsystem—a review. J Micromech Microeng 17:R15–R49.  https://doi.org/10.1088/0960-1317/17/5/R01 CrossRefGoogle Scholar
  3. Adamson AW (1990) Physical chemistry of surfaces, vol 5. Wiley, New York, pp 1–52Google Scholar
  4. Bhaumik SK, Das S, Chakraborty S, Das Gupta S (2014) Droplet Transport through dielectrophoretic actuation using line electrode. Microfluid Nanofluidics 16:597–603.  https://doi.org/10.1007/s10404-013-1242-5 CrossRefGoogle Scholar
  5. Bowden N, Brittain S, Evans AG, Hutchinson JW, Whitesides M (1998) Spontaneous formation of ordered structures in thin films of metals supported on an elastomeric polymer. Nature 393:146–149.  https://doi.org/10.1038/30193 CrossRefGoogle Scholar
  6. Carre A, Shanahan M (1995) Drop motion on an inclined plane and evaluation of hydrophobic treatments to glass. J Adhes 49:177–185.  https://doi.org/10.1080/00218469508014354 CrossRefGoogle Scholar
  7. Chen JZ, Troian SM, Darhuber AA, Wagner S (2005) Effect of contact angle hysteresis on thermocapillary droplet actuation. J Appl Phys 97:014906.  https://doi.org/10.1063/1.1819979 CrossRefGoogle Scholar
  8. Chung JY, Youngbloodb JP, Stafford CMI (2007) Anisotropic wetting on tunable micro-wrinkled surfaces. Soft Matter 3:1163–1169.  https://doi.org/10.1039/B705112C CrossRefGoogle Scholar
  9. Daniel S, Chaudhury MK, Chen JC (2001) Fast drop movements resulting from the phase change on a gradient surface. Science 291(5504):633–636.  https://doi.org/10.1126/science.291.5504.633 CrossRefGoogle Scholar
  10. Darhuber AA, Troian SM (2005) Principles of microfluidic actuation by modulation of surface stresses. Annu Rev Fluid Mech 37:425–455.  https://doi.org/10.1146/annurev.fluid.36.050802.122052 MathSciNetCrossRefzbMATHGoogle Scholar
  11. Datta S, Das AK, Das PK (2015) Uphill movement of sessile droplets by electrostatic actuation. Langmuir 31:10190–10197.  https://doi.org/10.1021/acs.langmuir.5b02184 CrossRefGoogle Scholar
  12. Datta S, Ma YB, Das AK, Das PK (2019) Investigation of droplet coalescence propelled by dielectrophoresis. AICHE J 65(2):829–839.  https://doi.org/10.1002/aic.16457 CrossRefGoogle Scholar
  13. Dussan VEB and Chow RTP (1983) On the ability of drops or bubbles to stick to non-horizontal surfaces of solids. J Fluid Mech 137:1–29.  https://doi.org/10.1017/S002211208300227X CrossRefzbMATHGoogle Scholar
  14. Fobel R, Fobel C, Wheeler AR (2013) Dropbot: an open-source digital microfluidic control system with precise control of electrostatic driving force and instantaneous drop velocity measurement. Appl Phys Lett 102:193513.  https://doi.org/10.1063/1.4807118 CrossRefGoogle Scholar
  15. Furmidge CGI (1962) Studies at phase interfaces, 1. The sliding of liquid drops on solid surfaces and a theory for spray retention. J Colloid Sci 17:309–324.  https://doi.org/10.1016/0095-8522(62)90011-9 CrossRefGoogle Scholar
  16. Guan Y, Li BY, Xing L (2018) Numerical investigation of electrowetting-based droplet splitting in closed digital microfluidic system: dynamics, mode, and satellite droplet. Phys Fluids 30(11):112001.  https://doi.org/10.1063/1.5049511 CrossRefGoogle Scholar
  17. Gupta S, Ramesh K, Ahmed S, Kakkar V (2016) Lab-on-chip technology: a review on design trends and future scope in biomedical applications. Int J Bio-Sci Bio-Technol 5:311–322.  https://doi.org/10.14257/ijbsbt.2016.8.5.28 CrossRefGoogle Scholar
  18. Hutama TJ, Oleschuk RD (2017) Magnetically manipulated droplet splitting on a 3D-printed device to carry out a complexometric assay. Lab Chip 17:2640–2649.  https://doi.org/10.1039/C7LC00629B CrossRefGoogle Scholar
  19. Islam MA, Tong AY (2018) A numerical study on electrowetting-induced droplet detachment from hydrophobic surface. J Heat Trans Trans ASME 140(5):052003.  https://doi.org/10.1115/1.4038540 CrossRefGoogle Scholar
  20. Jain V, Devarasetty V, Patrikar R (2017) Effect of electrode geometry on droplet velocity in open EWOD based device for digital microfluidics applications. J Electrost 87:11–18.  https://doi.org/10.1016/j.elstat.2017.02.006 CrossRefGoogle Scholar
  21. Karapetsas G, Chamakos NT, Papathanasiou AG (2017) Thermocapillary droplet actuation: effect of solid structure and wettability. Langmuir 33:10838–10850.  https://doi.org/10.1021/acs.langmuir.7b02762 CrossRefGoogle Scholar
  22. Katoh K, Higashine M, Nakamoto N, Azuma T (2006) On the sliding down of liquid drops on inclined plates (1st report, Critical inclination angle of plates). Trans Jpn Soc Mech Eng Ser B 72:1287–1294.  https://doi.org/10.1299/kikaib.72.1287 CrossRefGoogle Scholar
  23. Katoh K, Tamura H, Sato E, Wakimoto T (2018) Control of droplet movement on an inclined wall with sawtoothed wettability pattern by applying ultrasonic vibration. Exp Fluids 59:141.  https://doi.org/10.1007/s00348-018-2592-2 CrossRefGoogle Scholar
  24. Khang DH, Jiang H, Huang Y, Rogers JA (2006) A stretchable form of single-crystal silicon for high-performance electronics on rubber substrates. Science 311(5758):208–212.  https://doi.org/10.1126/science.1121401 CrossRefGoogle Scholar
  25. Krasovitski B, Marmur A (2005) Drops down the hill: theoretical study of limiting contact angles and the hysteresis range on a tilted plane. Langmuir 21:3881–3885.  https://doi.org/10.1021/la0474565 CrossRefGoogle Scholar
  26. Lahoon S, Rio OI, Cheng P, Neumann AW (1996) In: Neumann AW, Spelt JK (eds) Axisymmetric drop shape analysis (ADSA). Applied surface thermodynamics surfactant science series, vol 63. CRC Press, Boca Raton, pp 441–508Google Scholar
  27. Lee JL, Lee S, Kang KH (2012) Droplet jumping by electrowetting and its application to the three-dimensional digital microfluidics. Appl Phys Lett 100:081604.  https://doi.org/10.1063/1.3688487 CrossRefGoogle Scholar
  28. Lu HW, Glasner K, Bertozzi AL, Kim CJ (2007) A diffuse interface model for electrowetting drops in a Hele-Shaw cell. J Fluid Mech 590:411–435.  https://doi.org/10.1017/S0022112007008154 CrossRefzbMATHGoogle Scholar
  29. Moumen N, Subramanian RS, McLaughlin JB (2006) Experiments on the motion of drops on a horizontal solid surface due to a wettability gradient. Langmuir 22:2682–2690.  https://doi.org/10.1021/la053060x CrossRefGoogle Scholar
  30. Nahar MM, Nikapitiya JB, You SM, Moon H (2016) Droplet velocity in an electrowetting on dielectric digital microfluidic device. Micromachines 7(71):1–16.  https://doi.org/10.3390/mi7040071 CrossRefGoogle Scholar
  31. Ohozono T, Suzuki K, Yamaguchi T, Fukuda N (2013) Tunable optical diffuser based on deformable wrinkles. Adv Opt Mater 1(5):374–380.  https://doi.org/10.1002/adom.201300128 CrossRefGoogle Scholar
  32. Parihar V, Bandyopadhyay S, Das S, Dasgupta S (2018) Anisotropic electrowetting on wrinkled surfaces: enhanced wetting and dependency on initial wetting state. Langmuir 34(5):1844–1854.  https://doi.org/10.1021/acs.langmuir.7b03467 CrossRefGoogle Scholar
  33. Park SR, Kwon OJ, Shin D, Song S-H, Lee H-S, Choi HY (2007) Grating micro-dot patterned light guide plates for LED backlights. Opt Express 15:2888–2899.  https://doi.org/10.1364/OE.15.002888 CrossRefGoogle Scholar
  34. Pratap V, Moumen N, Subramanian RS (2008) Thermocapillary motion of a liquid drop on a horizontal solid surface. Langmuir 24:5185–5193.  https://doi.org/10.1021/la7036839 CrossRefGoogle Scholar
  35. Rigoni C, Ferraro D, Carlassara M, Filippi D, Varagnolo S, Pierno M, Talbot D, Abou-Hassan A, Mistura G (2018) Dynamics of ferrofluid drops on magnetically patterned surfaces. Langmuir 34(30):8917–8922.  https://doi.org/10.1021/acs.langmuir.8b01520 CrossRefGoogle Scholar
  36. Rodriguez-Hernandez J (2015) Wrinkled interfaces: taking advantage of surface instabilities to pattern polymer surfaces. Prog Polym Sci 42:1–41.  https://doi.org/10.1016/j.progpolymsci.2014.07.008 CrossRefGoogle Scholar
  37. Seerha PPS, Kumar P, Das AK, Mitra SK (2017) Proposition of stair climb of a drop using chemical wettability gradient. Phys Fluids 29(7):072103.  https://doi.org/10.1063/1.4985213 CrossRefGoogle Scholar
  38. Suzuki K, Homma H, Murayama T, Fukuda S, Takanobu H, Miura H (2010) Electrowetting-based actuation of liquid droplets for micro transportation systems. J Adv Mech Des Syst 4:365–372.  https://doi.org/10.1299/jamdsm.4.365 CrossRefGoogle Scholar
  39. Volynskii AL, Bazhenov S, Lebedeva OV, Bakeev NF (2000) Mechanical buckling instability of thin coatings deposited on soft polymer substrates. J Mater Sci 35:547–554.  https://doi.org/10.1023/A:1004707906821 CrossRefGoogle Scholar
  40. Xi HD, Zheng H, Guo W, Gañán-Calvo AM, Ai Y, Tsao CW, Zhou J, Li W, Huang Y, Nguyenh NT, Tan SH (2017) Active droplet sorting in microfluidics: a review. Lab Chip 17:751–771.  https://doi.org/10.1039/C6LC01435F CrossRefGoogle Scholar
  41. Yamamoto Y, Ito T, Wakimoto T, Katoh K (2018) Numerical and theoretical analyses of the dynamics of droplets driven by electrowetting on dielectric in a Hele-Shaw cell. J Fluid Mech 839:468–488.  https://doi.org/10.1017/jfm.2018.16 MathSciNetCrossRefzbMATHGoogle Scholar
  42. Zhang Y, Nguyen NT (2017) Magnetic digital microfluidics—a review. Lab Chip 17:994–1008.  https://doi.org/10.1039/C7LC00025A CrossRefGoogle Scholar
  43. Zhao Y, Liu F, Chen CH (2011) Thermocapillary actuation of binary drops on solid surfaces. Appl Phys Lett 99:104101.  https://doi.org/10.1063/1.3632041 CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  1. 1.Department of Mechanical EngineeringOsaka City UniversityOsakaJapan
  2. 2.Department of Applied Chemistry and BioengineeringOsaka City UniversityOsakaJapan

Personalised recommendations