Advertisement

Heat transfer by satellite cluster of cylinders at subcritical Reynolds number

  • S. K. Dhiman
  • Arbind Kumar
  • J. K. Prasad
Original
  • 14 Downloads

Abstract

2D unsteady computations were conducted in Fluent for differently configured cluster of cylinders at constant-heat-flux wall condition subjected to transverse air-flow at subcritical Reynolds number of 3.5 × 104. The investigation aimed to observe the performance of satellite arrangement of nine clustered cylinders for stage-wise heat exchange process in waste-heat-recovery recuperators (WHRR). Nusselt numbers were analyzed while the pressure distributions and flow visualizations were used to interpret the flow and heat transfer phenomenon. The analysis of heat transfer data revealed an improvement in heat transfer ratio of 3.55% by the satellite arrangement over that of cluster of nine single cylinders providing the heat transfer ideally.

Notes

References

  1. 1.
    Zdravkovich MM (1997) Flow around circular cylinders. Vol-1: fundamentals. Oxford University Press, LondonMATHGoogle Scholar
  2. 2.
    Eckert ERG, Goldstein RJ, Ibele WE, Simon TW, Kuehn TH, Strykowski PJ, Tamma KK, Bar-Cohen A, Heberlein JVR, Davidson JH, Bischof J, Kulacki F, Kortshagen U (2000) Heat transfer-a review of 1996 literature. Int J Heat and Mass Transfer 43:12730–11371MATHGoogle Scholar
  3. 3.
    Zdravkovich MM (2003) Flow around circular cylinders. Vol-2: applications. Oxford University Press, LondonMATHGoogle Scholar
  4. 4.
    Goldstein RJ, Ibele WE, Patankar SV, Si-mon TW, Kuehn TH, Strykowski PJ, Tamma KK, Heberlein JVR, Davidson JH, Bischof J, Kulacki FA, Kortshagen U, Garrick S, Srinivasan V, Ghosh K, Mittal R (2010) Heat transfer-a review of 2005 literature. Int. J. Heat and Mass Transfer 53:4397–4447CrossRefMATHGoogle Scholar
  5. 5.
    Zhou Y, Alam MM (2016) Wake of two interacting circular cylinders: a review. Int J Heat and Fluid Flow 62:510–537CrossRefGoogle Scholar
  6. 6.
    Kondjoyan A, Boisson HC (1997) Comparison of calculated and experimental heat transfer coefficients at the surface of circular cylinders placed in a turbulent cross-flow of air. J Food Engineering 34:123–143CrossRefGoogle Scholar
  7. 7.
    Szczepanik K, Ooi A, Aye L, Rosengarten G (2004) A numerical study of heat transfer from a cylinder in cross flow. Proc.: 15th Australasian Fluid Mech. Conf. AustraliaGoogle Scholar
  8. 8.
    Younis BA, Banica MC, Weigand B (2005) Prediction of vortex shedding with heat transfer. Numerical Heat Transfer-Part-A 48:1–19CrossRefGoogle Scholar
  9. 9.
    Rahman MM, Karim MM, Alim MA (2007) Numerical investigation of unsteady flow past a circular cylinder using 2d finite volume method. J Naval Architecture and Marine Eng 4:27–42Google Scholar
  10. 10.
    Walters DK, Cokljat D (2008) A three-equation eddy-viscosity model for Reynolds-averaged Navier–stokes simulations of transitional flow. ASME Journal of Fluids Engineering 13:121401-1121401-14Google Scholar
  11. 11.
    Dhiman SK, Kumar A, Prasad JK (2017) Unsteady computation of flow field and convective heat transfer over tandem cylinders at subcritical Reynolds numbers. J Mech Science and Tech 31(3):1341–1257CrossRefGoogle Scholar
  12. 12.
    Carmo BS, Meneghini JR, Sherwin SJ (2010) Secondary instabilities in the flow around two circular cylinders in tandem. J Fluid Mech 644:395–431CrossRefMATHGoogle Scholar
  13. 13.
    Jiang R, Lin J, Xiaoke K (2014) Numerical predictions of flows past two tandem cylinders of different diameters under unconfined and confined flows. Fluid Dyn Res 46:1–22MathSciNetCrossRefMATHGoogle Scholar
  14. 14.
    Chen H, Zheng Z, Chen Z, Bi XT (2016) Simulation of flow and heat transfer around a heated stationary circular cylinder by lattice gas automata. Powder Technol 290:72–82CrossRefGoogle Scholar
  15. 15.
    Dhiman SK, Prasad JK, Kumar A (2017) Unsteady convective heat transfer in cross flow past two tandem cylinders: an inverse heat conduction approach. Heat Mass Transf 53:1761–1775CrossRefGoogle Scholar
  16. 16.
    Lee D, Ahn J, Shin S (2013) Uneven longitudinal pitch effect on tube bank heat transfer in cross flow. Appl Therm Eng 51:937–947CrossRefGoogle Scholar
  17. 17.
    Prabowo MES, Nanang R, Anggiansyah R (2016) Flow and heat transfer enhancement around staggered tubes using rectangular vortex generators. ARPN J Engg and Applied Sciences 11(2):952–956Google Scholar
  18. 18.
    Zhou SD, Xi GD (2016) The heat transfer enhancement mechanisms of tubes with different arrays in the transitional flow. J Physics: Conf Series 745:032085.  https://doi.org/10.1088/1742-6596/745/3/032085 Google Scholar
  19. 19.
    Zhou S, Xi G (2017) Numerical simulation on time-mean characteristics of flow and heat transfer of inline double-column cylinders in the transitional flow using compound grid system. Int J Refrigeration 74:198–209CrossRefGoogle Scholar
  20. 20.
    ANSYS, Inc. (2011) Fluent 14.0, ANSYSFLUENT Theory GuideGoogle Scholar
  21. 21.
    Igarashi T, Hirata M (1977) Heat transfer in separated flows part 2: theoretical analysis. Heat Transfer-Jpn Res 6(3):60–78Google Scholar
  22. 22.
    Macovsky MS (1958) Vortex-Induced vibration studies, Report No. 1190, Navy Department, David Tayler Model Basin, Hydromechanics LaboratoryGoogle Scholar
  23. 23.
    Perkins HC, Leppert G (1964) Local heat-transfer coefficients on a uniformly heated cylinder. Int J Heat Mass Transf 7:143–158CrossRefGoogle Scholar
  24. 24.
    Igarashi T (1981) Characteristics of flow around two circular cylinders arranged in tandem. Bulletin of JSME 24(188):323–331CrossRefGoogle Scholar
  25. 25.
    Sanitjai S, Goldstein RJ (2004) Heat transfer from a circular cylinder to mixtures of water and ethylene glycol. Int J Heat Mass Transf 47:4795–4805CrossRefGoogle Scholar
  26. 26.
    Igarashi T, Suzuki K (1984) Characteristics of the ow around three circular cylinders arranged in line. Bull Japan Soc Mech Eng 27:2397–2404CrossRefGoogle Scholar
  27. 27.
    Smith BL, Stepan JJ, McEligot DM (2007) Velocity and pressure measurements along a row of confined cylinders. ASME J Fluids Engineering 129:13–14CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  1. 1.Birla Institute of TechnologyMesraIndia

Personalised recommendations