Abstract
The results of experimental investigations into the zeta potential of ultrafine sulfides (chalcopyrite, tennantite, galenite, sphalerite, pyrite, and pyrrhotine), the floatability of monomineral fractions of sulfides of the floatation coarseness (–0.1 + 0.05 mm) in a mechanical flotation machine, and the floatability fine particles of sulfide (–0.044 + 0.010 mm) in the Hallimond tube are presented. The preparation procedure of ultrafine powders and sulfhydril collectors to measure the zeta potential is presented. Zeta potentials of the surface of mineral particles and insoluble forms of sulfhydril collectors are investigated in the pH range from 2.0 to 12.5 (an acidic medium was formed by using H2SO4 and basic one by using NaOH or Ca(OH)2), and various values of zeta potentials are found for sulfides in the sodium hydroxide and lime medium. Zeta potentials for all sulfides are negative in the NaOH medium at pH > 9.5, they are positive (1–18 mV) in the Ca(OH)2 medium at pH > 11, and zeta potentials for chalcopyrite are positive in the studied range \(p{H_{Ca{{\left( {OH} \right)}_2}}}\) 9.0–12.5. The values of the isoelectric point in the medium of sulfuric acid and sodium hydroxide are as follows: for chalcopyrite—pH 6.5 and 8.8, for tennantite—pH 3.0, for sphalerite—pH 5.1 and 6.4, for pyrite—pH 3.1 and 8.9, and for pyrrhotine—pH 7.0. In the lime medium, the value for tennantite and sphalerite pH 12.0, for galenite—pH 11.2, for pyrite—pH 9.5 and 11.2, and for pyrrhotine—pH 9.5 and 12.1. Measurements of zeta potentials of ultrafine sulfide particles give the opportunity to refine the interaction mechanism of sulfhydril collectors with sulfides and associate the nonselective recovery of final tailings of sulfides in the highly alkaline lime medium with the contribution of the electrostatic component during the adhesion of ultrafine sulfide particles on bubbles and their mechanical carryout into the froth product.
Similar content being viewed by others
References
Klassen, V.I. and Mokrousov, V.A., Vvedenie v teoriyu flotatsii (Introductory Flotation Theory), Moscow: Gosgortekhizdat, 1959.
Sorokin, M.M., Flotatsionnye metody obogashcheniya. Khimicheskie osnovy flotatsii (Flotation Methods of Ore Dressing. Chemical Foundations of Flotation), Moscow: MISIS, 2011, pp. 95–99.
Mao, L. and Yoon, R.-H., Predicting flotation rates using a rate equation derived from first principles, Int. J. Miner. Process., 1997, vol. 51, pp. 171–181.
Fuerstenau, D.W. and Pradip, Zeta potentials in the flotation of oxide and silicate minerals, Adv. Colloid Interface Sci., 2005, vol. 114–115, pp. 9–26. doi 10. 1016/jcis200408.006.
Melik-Gaikazyan, V.I. and Emel’yanova, N.P, Competitive Representations in Studies on Froth Flotation and Prospects of Their Application for Selection of Reagents, Russ. J. Non-Ferrous Met., 2007, vol. 48, no. 4, pp. 237–251.
Chanturiya, V.A. and Vigdergauz, V.E., Elektrokhimiya sul’fidov. Teoriya i praktika flotatsii (Electrochemistry of Sulfides. Theory and Practice of Flotation), Moscow: Ruda i Metally, 2008.
Abramov, A.A., Flotatsionnye metody obogashcheniya (Flotation methods of Ore Dressing), Moscow: Mosk. Gos. Gorn. Univ., 2008.
Rodriguez, K. and Araujo, M, Temperature and pressure effects on zeta potential values of reservoir minerals, J. Colloid Interface Sci., 2006, vol. 300, pp. 788–799.
Kaya, A. and Yukselen, Y, Zeta potential of clay minerals and quartz contaminated by heavy metals, Can. Geotechnical J., 2005, vol. 42, no. 5, pp. 1280–1289.
Samygin, V.D., Filippov, L.O., and Shekhirev, D.V., Osnovy obogashcheniya rud (Foundations of Ore Dressing), Moscow: Alteks, 2003.
Prestidge, C.A, Rheological investigation of ultrafine galena particle slurries under flotation-related condition, Int. J. Miner. Process., 1997, vol. 51, pp. 241–254.
Fullston, D., Fomasiero, D., and Ralston, J, Zeta potential study of the oxidation of copper sulfide minerals, Colloids Surf., A, 1999, vol. 146, nos. 1–3, pp. 113–121. doi 101016/S0927-7757(98)00725-0
Mermillod-Blondin, R., Kongolo, M., de Donato, R., Benzaazoua, M., Barres, O., Bussiere, B., and Aubertin, M, Pyrite flotation with xanthate under alkaline conditions–application to environmental desulfurization, in: Centenary of Flotation Symp., Brisbane, QLD, 2005, pp. 683–692.
Chandra, A.P. and Gerson, A.R., A review of the fundamental studies of the copper activation mechanisms for selective flotation of the sulfide minerals, sphalerite, pyrite, Adv. Colloid Interface Sci., 2009, vol. 145, pp. 97–100.
López Valdivieso, A., Sánchez López, A.A., and Song, S, On the cathodic reaction coupled with the oxidation of xanthates at the pyrite/aqueous solution interface, Int. J. Miner. Process., 2005, vol. 77, no. 3, pp. 154–164.
Elmahdy, A.M., Mirnezami, M., and Finch, J.A., Zeta potential of air bubbles in presence of froths, Int. J. Miner. Process., 2008, vol. 89, nos. 1–4, pp. 40–43.
Oliveira, C. and Rubio, J, Zeta potential of single and polymer-coated microbubbles using an adapted microelectrophoresis technique, Int. J. Miner. Process., 2011, vol. 98, pp. 118–123.
Tekhnicheskie zapiski po problemam vody (firma Dekremon) (Technical Notes on Water Problems (Dekremon Limited Company)), Moscow: Stroiizdat, 1983, vol. 1, pp. 61–69.
Ignatkina, V.A. and Bocharov, V.A., and D’yachkov, F.G, Collecting properties of diisobutyl dithiophosphinate in sulfide mineral f lotation from sulfide ore, J. Mining Sci., 2013, vol. 49, no. 5, pp. 795–802. doi 10.1134/S1062739149050146
Yagudina, Yu.R., Development and Substantiation of Parameters of the Combined Processing Technology of Tennantite-Containing Ores of Copper Pyrite Deposits of Ural, Extended Abstract of Cand. Sci. (Eng.) Dissertation, Magnitogorsk Gos. Tekh. Univ., Magnitogorsk, 2015. http://www.magtu.ru/dokumenty/finish/549-yagudina-yuliyaradikovna/3803-avtoreferat-yagudinojyu- r.html (accessed: April 1, 2016).
Mikhailov, V.A., Sorokina, O.V., Savinkina, E.V., and Davydova, M.N., Khimicheskoe ravnovesie (Chemical Equilibrium), Moscow: Binom. Laboratoriya Znanii, 2008.
Reutov, O.A., Kurts, A.L., and Butin, K.P., Organicheskaya khimiya. Chast’ 1 (Organic Chemistry. Part 1), Moscow: Binom. Laboratoriya Znanii, 2009.
Ryaboi, V.I., Shenderovich, V.A., and Krechetov, V.P, Application of aeroflots for ore flotation, Obogashchenie rud, 2005, no. 6, pp. 43–44.
Ignatkina, V.A. and Bocharov, V.A, Peculiarities of flotation of various copper sulfides and sphalerite pyrite ores, Gornyi Zh., 2014, no. 12, pp. 75–79.
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © V.A. Ignatkina, V.A. Bocharov, D.D. Aksenova, A.A. Kayumov, 2017, published in Izvestiya Vysshikh Uchebnykh Zavedenii, Tsvetnaya Metallurgiya, 2017, No. 1, pp. 4–12.
About this article
Cite this article
Ignatkina, V.A., Bocharov, V.A., Aksenova, D.D. et al. Zeta potential of the surface of ultrafine sulfides and floatability of minerals. Russ. J. Non-ferrous Metals 58, 95–100 (2017). https://doi.org/10.3103/S1067821217020043
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.3103/S1067821217020043