Abstract
The effect of combined deformation on changes in the plastic and strength characteristics of silicon is investigated. A notable increase in plasticity upon combined deformation compared to traditional hot deformation is revealed. It is shown that the microhardness of silicon is reduced as plastic deformation increases. The mobility of dislocations has an appreciable effect on the strength characteristics of silicon single crystals. Surface microstructures of the deformed samples are studied. A possible explanation for the observed effects is given.
Similar content being viewed by others
REFERENCES
Criffin, P.B., Plummer, J.D., and Deal, M.D., Silicon VLSI Technology: Fundamentals, Practice, and Modeling, New York: Prentice Hall, 2000.
Nalwa, H.S., Silicon-Based Materials and Devices, New York: Academic, 2001.
Dmitrievskii, A.A., Efremova, N.Yu., Zanin, A.P., and Lovtsov, A.R., J. Surf. Invest.: X-Ray, Synchrotron Neutron Tech., 2012, vol. 6, no. 2, p. 362.
Adarchin, S.A., Kosushkin, V.G., Berezhanskii, I.R., et al., Trudy III Mezhdunarodnoi nauchno-prakticheskoi konferentsii “Fizika i tekhnologiya nanomaterialov i struktur” (Proc. III Int. Sci.-Pract. Conf. “Physics and Technology of Nanomaterials and Structures”), Kursk, 2017, p. 170.
Baranov, Yu.V., Troitskii, O.A., Avramov, Yu.S., and Shlyapin, A.D., Fizicheskie osnovy elektroimpul’snoi i elektroplasticheskoi obrabotok i novye materialy (Physical Foundations of Electropulse and Electroplastic Treatment and New Materials), Moscow: Mosk. Gos. Ind. Univ., 2001, p. 10.
Sueoko, K., Akatsuka, M., Katahama, H., and Adachi, N., Jpn. J. Appl. Phys., 1997, vol. 36, no. 12A, p. 7095.
Golovin, Yu.I., Dmitrievskii, A.A., Pushnin, I.A., and Suchkova, N.Yu., Phys. Solid State, 2004, vol. 46, no. 10, p. 1851.
Brinkevich, D.I., Vabishchevich, S.A., Prosolovich, V.S., and Yavid, V.Yu., Perspekt. Mater., 2007, no. 1, p. 32.
Chiradze, G.A. and Gerasimov, A.B., Mezhdunar. Zh. Prikl. Fundam. Issled., 2013, no. 11, p. 56.
Kontsevoi, Yu.A., Litvinov, Yu.M., and Fattakhov, E.A., Plastichnost’ i prochnost' poluprovodnikovykh materialov i struktur (Plasticity and Strength of Semiconductor Materials and Structures), Moscow: Radio i Svyaz’, 1982.
Govorkov, V.G., Kristallografiya, 1961, vol. 5, no. 6, p. 789.
Amelinckx, S., The Direct Observation of Dislocations, Academic, 1964.
Sluchinskaya, I.A., Osnovy materialovedeniya i tekhnologii poluprovodnikov (Introduction to Semiconductor Materials Science and Technology), Moscow: Mir, 2002, p. 86.
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated by I. Obrezanova
About this article
Cite this article
Velikhanov, A.R. Correlation between Defect Structure and the Strength Properties of Silicon for Various Means of Plastic Deformation. Bull. Russ. Acad. Sci. Phys. 83, 1210–1213 (2019). https://doi.org/10.3103/S1062873819100228
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.3103/S1062873819100228