Abstract
Indentation-induced phase transformation processes were studied by in situ Raman imaging of the deformed contact region of silicon thin films, using a Raman spectroscopy-enhanced instrumented indentation technique (IIT). In situ Raman imaging was used to study the generation and evolution of the phase transformation of silicon while performing an IIT experiment analyzed to determine the average contact pressure and indentation strain. This is, to our knowledge, the first sequence of Raman images documenting the evolution of the strain fields and changes in the phase distributions of a material while conducting an indentation experiment. The reported in situ experiments provide insights into the transformation processes in silicon during indentation, confirming, and providing the experimental evidence for, some of the previous assumptions made on this subject. The developed Raman spectroscopy-enhanced IIT has shown its potential in advancing the understanding of deformation mechanisms and will provide a very useful tool in validating and refining contact models and related simulation studies.
Similar content being viewed by others
References
A. Mujica, A. Rubio, A. Munoz, and R.J. Needs: High-pressure phases of group-IV, III-V, and II-VI compounds. Rev. Mod. Phys. 75, 863 (2003).
M.C. Gupta and A.L. Ruoff: Static compression of silicon in the [100] and in the [111] directions. J. Appl. Phys. 51, 1072 (1980).
J.C. Jamieson: Crystal structures at high pressures of metallic modifications of silicon and germanium. Science 139, 762 (1963).
J.Z. Hu, L.D. Merkle, C.S. Menoni, and I.L. Spain: Crystal data for high-pressure phases of silicon. Phys. Rev. B 34, 4679 (1986).
J. Crain, G.J. Ackland, J.R. Mclean, R.O. Piltz, P.D. Hatton, and G.S. Pawley: Reversible pressure-induced structural transitions between metastable phases of silicon. Phys. Rev. B 50, 13043 (1994).
D.R. Clarke, M.C. Kroll, P.D. Kirchner, R.F. Cook, and B.J. Hockey: Amorphization and conductivity of silicon and germanium induced by indentation. Phys. Rev. Lett. 60, 2156 (1988).
G.M. Pharr, W.C. Oliver, and D.S. Harding: New evidence for a pressure-induced phase transformation during the indentation of silicon. J. Electron. Mater. 19, 881 (1990).
I.V. Gridneva, Y.V. Milman, and V.I. Trefilov: Phase transition in diamond-structure crystals during hardness measurements. Phys. Status Solidi 14, 177 (1972).
G.M. Pharr, W.C. Oliver, R.F. Cook, P.D. Kirchner, M.C. Kroll, T.R. Dinger, and D.R. Clarke: Electrical resistance of metallic contacts on silicon and germanium during indentation. J. Mater. Res. 7, 961 (1992).
E.R. Weppelmann, J.S. Field, and M.V. Swain: Observation, analysis, and simulation of the hysteresis of silicon using ultra-micro-indentation with spherical indenters. J. Mater. Res. 8, 830 (1993).
J.E. Bradby, J.S. Willaims, J. Wong-Leung, M.V. Swain, and P. Munroe: Mechanical deformation in silicon by micro-indentation. J. Matter. Res. 16(5), 1500 (2001).
T. Juliano, V. Domnich, and Y. Gogotsi: Examining pressure-induced phase transformations in silicon by spherical indentation and Raman spectroscopy: A statistical study. J. Mater. Res. 19, 3099 (2004).
H. Saka, A. Shimantani, M. Suganuma, and Suprijadi: Transmission electron microscopy of amorphization and phase transformation beneath indents in Si. Philos. Mag. A 82, 1971 (2002).
D. Ge, A.M. Minor, E.A. Stach, and J.W. Morris, Jr.: Size effects in the nanoindentation of silicon at ambient temperature. Philos. Mag. 86, 4069 (2006).
V. Domnich and Y. Gogotsi: Phase transformations in silicon under contact loading. Rev. Adv. Mater. Sci. 3, 1 (2002).
K. Mylvaganam, L.C. Zhang, P. Eyben, J. Mody, and W. Vandervorst: Evolution of metastable phases in silicon during nanoindentation: Mechanism analysis and experimental verification. Nanotechnology 20, 305705 (2009).
S-T. Ho, Y-H. Chang, and H-N. Lin: Conducting atomic force microscopy of phase transformation in silicon nanoindentation. J. Appl. Phys. 96, 3562 (2004).
A. Kailer, Y.G. Gogotsi, and K.G. Nickel: Phase transformations of silicon caused by contact loading. J. Appl. Phys. 81, 3057 (1997).
J. Jang, M.J. Lance, D. Wen, T.Y. Tsui, and G.M. Pharr: Indentation-induced phase transformations in silicon: Influences of load, rate and indenter angle on the transformation behavior. Acta Mater. 53, 1759 (2005).
D. Ge, V. Domnich, and Y. Gogotsi: High-resolution transmission electron microscopy study of metastable silicon phases produced by nanoindentation. J. Appl. Phys. 93, 2418 (2003).
I. Zarudi, L.C. Zhang, J. Zou, and T. Vodenitcharova: The R8-BC8 phases and crystal growth in monocrystalline silicon under microindentation with a spherical indenter. J. Mater. Res. 19, 332 (2004).
A. Haq and P.R. Munroe: Phase transformations in (111) Si after spherical indentation. J. Mater. Res. 24, 1967 (2009).
Y.B. Gerbig, S.J. Stranick, and R.F. Cook: Direct observation of phase transformation anisotropy in indented silicon studied by confocal Raman spectroscopy. Phys. Rev. B 83, 205209 (2001).
C.R. Das, H.C. Hsu, S. Dhara, A.K. Bhaduri, B. Raj, L.C. Chen, K.H. Chen, S.K. Albert, A. Ray, and Y. Tzeng: A complete Raman mapping of phase transitions in Si under indentation. J. Raman Spectrosc. 41, 334 (2010).
F. Demangeot, P. Puech, V. Paillard, V. Domnich, and Y.G. Gogotsi: Spatial distribution of strain and phases in Si nano-indentation analysed by Raman mapping. Solid State Phenom. 82–84, 777 (2002).
P. Puech, F. Demangeot, P.S. Pizani, V. Domnich, and Y. Gogotsi: Is there a link between very high strain and metastable phases in semiconductors: Cases of Si and GaAs?J. Phys.: Condens. Matter 16, S39 (2004).
P. Eyben, F. Clemente, K. Vanstreels, G. Purtois, T. Clarysse, K. Sankaran, J. Mody, W. Vandervorst, K. Mylvaganam, and L. Zhang: Analysis and modeling of the high vacuum scanning spreading resistance microscopy nanocontact on silicon. J. Vac. Sci. Technol., B 28, 401 (2010).
J.E. Bradby, J.S. Williams, and M.V. Swain: In situ electrical characterization of phase transformations in Si during indentation. Phys. Rev. B 67, 085205 (2003).
A.B. Mann, D. Van Heerden, J.B. Pethica, P. Bowes, and T.P. Weihs: Contact resistance and phase transformations during nanoindentation of silicon. Philos. Mag. A 82, 1921 (2002).
B.D. Malone, J.D. Sau, and M.L. Cohen: Ab initio survey of the electronic structure of tetrahedrally bonded phases of silicon. Phys. Rev. B 78, 035210 (2008).
S. Ruffell, J.E. Bradby, J.S. Williams, and P. Munroe: Formation and growth of nanoindentation-induced high pressure phases in crystalline and amorphous silicon. J. Appl. Phys. 102, 063521 (2007).
Y.B. Gerbig, C.A. Michaels, A.M. Forster, J.W. Hettenhouser, W.E. Byrd, D.J. Morris, and R.F. Cook: Indentation device for in situ Raman spectroscopic and optical studies. Rev. Sci. Instrum. 83, 125106 (2012).
Y.B. Gerbig, C.A. Michaels, A.M. Forster, and R.F. Cook: In situ observation of the indentation-induced phase transformation of silicon thin films. Phys. Rev. B 85, 104102 (2012).
Any mention of commercial products within this paper is for information only; it does not imply recommendation or endorsement by NIST.
A.J. Bushby and N.M. Jennet: Determining the area function of spherical indenters for nanoindentation. In Fundamentals of Nanoindentation & Nanotribology II, S.P. Baker, R.F. Cook, S.G. Corcoran, and N.R. Moody ed.; Mat. Res. Soc. Symp. Proc., Vol. 649, Warrendale, PA, 2001, p. Q7.17.1.
J.S. Field and M.V. Swain: Determining the mechanical properties of small volumes of material from submicrometer spherical indentations. J. Mater. Res. 8, 297 (1993).
Y.B. Gerbig, S.J. Stranick, D.J. Morris, M.D. Vaudin, and R.F. Cook: Effect of crystallographic orientation on phase transformations during indentation of silicon. J. Mater. Res. 24, 1172 (2009).
B.A. Weinstein and G.J. Piermarini: Raman scattering and phonon dispersion in Si and GaP at very high pressure. Phys. Rev. B 12, 1172 (1972).
W. Windl, P. Pavone, K. Karch, O. Schütt, D. Strauch, P. Giannozzi, and S. Baroni: Second-order Raman spectra of diamond from ab initio phonon calculations. Phys. Rev. B 48, 3164 (1993).
M. Kadleíková, J. Breza, and M. Veselý: Raman spectra of synthetic sapphire. Microelectron. J. 32, 955 (2001).
E. Anastassakis, A. Pinczuk, and E. Burstein: Effect of static uniaxial stress on the Raman spectrum of silicon. Solid State Commun. 8, 133 (1970).
T.P. Mernagh and L-G. Liu: Pressure dependence of Raman phonons of some group IVA (C, Si, and Ge) elements. J. Phys. Chem. Solids 52, 507 (1991).
S. Khachadorian, K. Papagelis, H. Scheel, A. Coli, A.C. Ferrari, and C. Thomsen: High pressure Raman scattering of silicon nanowires. Nanotechnology 22, 195707 (2011).
A. Debernardi, S. Baroni, and E. Molinari: Anharmonic phonon lifetimes in semiconductors from density-functional perturbation theory. Phys. Rev. Lett. 75, 1819 (1995).
H. Olijnyk: Raman scattering in metallic Si and Ge up to 50 GPa. Phys. Rev. Lett. 68, 2232 (1992).
K. Gaál-Nagy, M. Schmitt, P. Pavone, and D. Strauch: Ab initio study of the high-pressure phase transition from the cubic-diamond to the β-tin structure of Si. Comput. Mater. Sci. 22, 49 (2001).
D.E. Kim and S.I. Oh: Deformation pathway to high-pressure phases of silicon during nanoindentation. J. Appl. Phys. 104, 013502 (2008).
S.M-M. Dubois, G-M. Rignanese, T. Pardoen, and J-C. Charlier: Ideal strength of silicon: An ab initio study. Phys. Rev. B 74, 235203 (2006).
J. Gilman: Shear-induced metallization. Philos. Mag. B 67, 207 (1993).
M. Durandurdu: Diamond to β-tin phase transition of silicon under hydrostatic and nonhydrostatic compressions. J. Phys.: Condens. Matter 20, 325232 (2008).
C-F. Han and J-F. Lin: The model developed for stress-induced structural phase transformations in micro-crystalline silicon films. Nano-Micro Lett. 2, 68 (2010).
Y-H. Lin, S-R. Jian, Y-S. Lai, and P-F. Yang: Molecular dynamics simulations of nanoindentation-induced mechanical deformation and phase transformation in monocrystalline silicon. Nanoscale Res. Lett. 3, 71 (2008).
C.F. Sanz-Navarro, S.D. Kenny, and R. Smith: Atomistic simulations of structural transformations of silicon surfaces under nanoindentation. Nanotechnology 15, 692 (2004).
G.S. Smith, E.B. Tadmor, N. Bernstein, and E. Kaxiras: Multiscale simulations of silicon nanoindentation. Acta Mater. 49, 4089 (2001).
L.L. Boyer, E. Kaxiras, J.L. Feldman, J.Q. Broughton, and M.J. Mehl: New low-energy crystal structure for silicon. Phys. Rev. Lett. 67, 715 (1991).
L. Qin, K.L. Teo, Z.X. Shen, C.S. Peng, and J.M. Zhou: Raman scattering of Ge/Si dot superlattices under hydrostatic pressure. Phys. Rev. B 64, 075312 (2001).
W.C.D. Cheong and L.C. Zhang: Stress criterion for the β-tin transformation in silicon under indentation and uniaxial compression. Key Eng. Mater. 233–236, 603 (2003).
R.O. Piltz, J.R. Maclean, S.J. Clark, G.J. Ackland, P.D. Hatton, and J. Crain: Structure and properties of silicon XII: A complex tetrahedrally bonded phase. Phys. Rev. B 52, 4072 (1995).
K. Winer: Structural and vibrational properties of a realistic model of amorphous silicon. Phys. Rev. B 35, 2366 (1987).
J. Khajehpour, W.A. Daoud, T. Williams, and L. Bourgeois: Laser-induced reversible and irreversible changes in silicon nanostructures: One- and multi-phonon Raman scattering study. J. Phys. Chem. C 115, 22131 (2011).
V. Lavrentiev, J. Vacik, V. Vorlicek, and V. Vosecek: Raman scattering in silicon disordered by gold ion implantation. Phys. Status Solidi B 247, 2022 (2010).
H. Olijnyk and A. Jephcoat: Effect of pressure on Raman spectra of metastable phases of Si and Ge. Phys. Status Solidi B 211, 413 (1999).
T. Ishidate, K. Inoue, K. Tsuji, and S. Minomura: Raman scattering in hydrogenated amorphous silicon under high pressure. Solid State Commun. 42, 197 (1982).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Gerbig, Y.B., Michaels, C.A. & Cook, R.F. In situ observation of the spatial distribution of crystalline phases during pressure-induced transformations of indented silicon thin films. Journal of Materials Research 30, 390–406 (2015). https://doi.org/10.1557/jmr.2014.316
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1557/jmr.2014.316