Abstract
The results of theoretical and experimental investigations revealed a dependence between the parameters of steam condensation process in tubes and channels on the coolant flow pattern: counter flow, forward flow, and cross flow. The loss of total steam pressure in case of counter flow is higher than it is in case of using a forward or cross flow pattern. During condensation, superheated steam retains its superheated state over the entire tube length if the steam quality at the outlet x 1 > 0, and the superheating temperature depends on the coolant flow pattern. A method for calculating the pressure loss to steam temperature ratio as a function of coolant flow pattern is developed, which is confirmed by experimental data. The ratio \(\frac{{kF}} {{cG}} \) or its versions (where c and G are the specific heat capacity and flow rate of coolant) should be regarded as the main parameter in generalizing data.
References
O. O. Mil’man and V. A. Fedorov, Air-Cooled Condensing Installations (MEI, Moscow, 2002) [in Russian].
A Handbook on Heat Transfer, Vol. 1, Ed. by B. S. Petukhov and V. K. Shikov (Energoatomizdat, Moscow, 1987) [in Russian].
S. S. Kutateladze, Condensation and Boiling Heat Transfer (GNTI, Moscow, 1952) [in Russian].
O. O. Milman, D. B. Spalding, and V. A. Fedorov, “Steam condensation in parallel channels with nonuniform heat removal in different zones of heat-exchange surface,” Int. J. Heat Mass Transfer, No. 55, 6054–6059 (2012).
Z. A. Miropol’skii, R. I. Shneerova, and L. M. Ternakova, “Heat transfer during condensation of superheated and saturated steam inside tubes,” in Heat Transfer. Soviet Union’s Investigations (Nauka, Moscow, 1975) [in Russian].
Yu. M. Brodov, M. A. Nirenshtein, K. E. Aronson, and A. Yu. Ryabchikov, “Specific Features Related to Calculating the Condensing Heat-Transfer Apparatuses of Steam Turbine Units in Modernizing Them under Field Conditions,” Elektr. Stn., No. 7, 15–18 (2007).
Y. Taitel and A. Ducler, “A model for predicting flow regime transition in horizontal and near horizontal gas — liquid flow,” AJCh. 22, 47–55 (1976).
D. Barnea, O. Shohan, J. Taitel, and A. Ducler, “Flow pattern transition for horizontal and inclined pipes. Experimental and comparison with theory,” Multiphase Flow 6, 217–222 (1980).
V. A. Fedorov, O. O. Milman, B. A. Shifrin, “Results of experimental studies of thermohydraulic processes during the condensation of superheated steam inside the inclined tubes,” High Temperature 52 318–320 (2014).
B. S. Petukhov, L. G. Genin, and S. A. Kovalev, “Heat Transfer in Nuclear Power Installations” (MEI, Moscow, 2003) [in Russian].
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © O.O. Mil’man, V.A. Fedorov, A.V. Kondrat’ev, A.V. Ptakhin, 2015, published in Teploenergetika.
Rights and permissions
About this article
Cite this article
Mil’man, O.O., Fedorov, V.A., Kondrat’ev, A.V. et al. Specific features of steam condensation inside tubes and channels. Therm. Eng. 62, 299–309 (2015). https://doi.org/10.1134/S0040601515040060
Published:
Issue Date:
DOI: https://doi.org/10.1134/S0040601515040060