Abstract
Cross-linking between lignin and polysaccharide in plant cell-wall determines physical, chemical, and biological features of lignocellulosic biomass. Since Erdmann’s first report in 1866, numerous studies have suggested the presence of a bond between hemicelluloses and lignin; however, no clear evidence for this interaction has been reported. We describe the first direct proof of covalent bonding between plant cell-wall polysaccharides and lignin. Nuclear magnetic resonance spectroscopy was used to observe the long-range correlations through an α-ether bond between lignin and the primary hydroxyl group of a mannose residue in glucomannan. Complete signal assignment of the cognate structural units was also achieved. Thus, we identified lignin–carbohydrate bonds by complete connectivity analysis from the phenylpropane unit to the carbohydrate moiety.
Similar content being viewed by others
Introduction
Lignin is a key adaptation to terrestrial life that reinforces plant cell walls; this compound forms the hydrophobic xylem vessels that transport water, and it supports plant bodies by co-localising with polysaccharides, cellulose, and hemicellulose. Lignin is thought to associate with hemicelluloses through covalent and non-covalent bonding. The complex thus assembled is called the lignin–carbohydrate complex (LCC, Fig. 1).
A three-dimensional view of the lignin–carbohydrate complex (LCC) in the wood cell wall. An illustration of wood cell walls and their ultrastructure focusing on the ether linkage between lignin and carbohydrate, a structural feature that has remained unresolved for more than 150 years, and whose presence and location is elucidated in this study. Wood fibre networks consist of wood cell walls composed of cellulose, hemicellulose and lignin, the most abundant organic resources on earth. These polymer combinations give the plant cell wall strength and structure; however, the cell wall’s robustness is a barrier for the separation and utilisation of plant-based resources. Thus, the LCC is a key structure to elucidate physiologically, physically and industrially.
Recently, plant biomass has been highlighted as an alternative carbon source to fossil fuels. Plant cell walls, naturally designed to be durable, have good potential to become precursors for a variety of chemicals, fuels and value-added products; however, efficient separation of plant biomass is still challenging. Thus, a deeper fundamental understanding of the characteristics of plant cell walls, in particular with regard to the nature of the linkage between lignin and polysaccharides, is of great importance.
The most difficult process in biomass conversion is the separation of lignin from polysaccharides; however, LCCs are highly structurally rigid complexes, and separation of these polymers is difficult1,2. In 1866, Erdman3 hypothesised that lignin and polysaccharides combine chemically with each other to form a ‘glycolignose’. Subsequently, numerous investigations have been conducted to elucidate the structure and nature of LCCs in plant cell walls; however, no direct proof of the presence of chemical bonds between lignin and polysaccharides has been reported. To improve our understanding of plant cell wall structure and to develop efficient separation techniques to be implemented in lignocellulosic biorefineries, additional information on the chemical linkages between lignin and carbohydrates is necessary.
Since Björkman first developed procedures for fractionating LCCs from ball-milled wood4,5, several additional LCC fractionation methods have been proposed1,6,7, and the structure of LCC has been further analysed. Historically, the presence and nature of covalent bonds between lignin and carbohydrates has been investigated by indirect methods, such as alkaline degradation, Smith degradation, methylation analysis and IR and 1D NMR spectroscopies. Four types of lignin–carbohydrate (LC) linkages have been proposed to exist. Specifically, α ether linkages have been reported as the major LC bonds in LCCs8,9,10,11,12,13, with other LC bonds, such as α ester9,12,13,14,15,16, phenyl glycoside15,17,18 and acetal bonds19 also being reported. More recently, 2D 1H–13C heteronuclear single-quantum correlation (HSQC) NMR spectroscopy has been applied to the analysis of LC bonds, and the presence of α ether and phenyl glycoside bonds has been reported20,21,22,23,24. In addition, γ-ester LC linkages, instead of α esters, have been reported22,23. These observations and assignments were based on 1H–13C HSQC correlations. However, the chemical shifts of the relevant signals are not exactly identical to those of synthetic model compounds. Furthermore, the possibility of mis-assignment of the signals due to severe overlapping of the signals from other unidentified structures cannot be excluded.
In the present study, we conducted long-range correlation NMR experiments to obtain direct evidence on the chemical linkages between the phenylpropane units of lignin and hemicelluloses. To observe the LC bonds by long-range correlation NMR, condensation of the LC bonds in isolated LCC fractions is crucial; the frequency of LC bonds in LCCs isolated from plant cell walls is too low for NMR experiments to provide information about them. In order to prepare LCC fragments possessing a number of LC bonds high enough to suit NMR sensitivity, we concentrated the LC bonds in water-soluble neutral LCCs from Pinus densiflora (Japanese red pine) wood by carrying out the enzymatic digestion of the sugar moiety and using a polyvinyl gel characterised by an affinity for lignin and size-exclusion activity25,26.
Herein, we focus on the analysis of ether linkages among native LC bonds. During the polymerisation of monolignols, quinone methides are formed by coupling β- and phenoxy- radicals. These quinone methides then react with hydroxyl groups of the carbohydrates to form α ether bonds between lignin and carbohydrates. In previous studies, we demonstrated that primary hydroxyl groups (C6 position) of hexoses preferentially participate in α ether linkages through 2,3-dichloro-5,6-dicyanobenzoquinone (DDQ) oxidation followed by Prehm’s methylation12,26. Due to selective ether cleavage by DDQ at the α position and the labelling of the cleavage points of carbohydrates under neutral conditions, this result strongly supports the existence of an α ether bond. To obtain further unequivocal direct evidence of the presence of this bond, we used a combination of 1H–13C HSQC, heteronuclear multiple bond correlation (HMBC) and 13C-edited total correlation NMR spectroscopy (TOCSY) on the LC-bond-concentrated LCC fraction and demonstrated that in it the C-6 position of mannose was chemically linked to the α position of lignin.
Results
Preparation of the neutral LCC fraction by extraction and anion-exchange chromatography
LCC is a composite polymer comprising lignin and polysaccharides. To obtain original LCC from wood cell walls, we have focused on the MWL residue. MWL mostly consists of lignin, and its residue is in large part composed of polysaccharides, cellulose, and hemicellulose, but it also contains LCC. Here we isolated a water-soluble LCC fraction (LCC-WE) from the residue of MWL extracts. A flowchart of the LCC fractionation procedure is reported in Fig. 2A. To classify hemicellulose part, LCC-WE was separated into its neutral (C-1-M) and acidic (C-1-A) fractions as described previously27. C-1-M is a water-soluble LCC fraction containing structures in which pendant-like lignin is attached to a hemicellulose chain. In normal pine wood, this fraction is composed of lignin bound to chains of pure acetyl glucomannan. In reaction wood, β-1,4-galactan is present in this fraction, but arabino-glucuronoxylan is not. Sugar analysis showed that the neutral sugar content in C-1-M was 96.2%. The sugar composition was Rha 0.6%, Ara 1.2%, Xyl 0.3%, Man 59.0%, Gal 16.3% and Glc 22.6%. Smith degradation of C-1-M yielded 1.7% ethylene glycol, 4.9% glycerol, 81.0% erythritol, 8.3% mannose and 4.1% glucose. Xylose and galactose were not detected by this approach, supporting the hypothesis that the major component in C-1-M is partially acetylated glucomannan and that β-1,4-linked galactan is also present in the fraction.
Fractionation flowchart (A) and schematic depiction of the procedure (B) for purifying LCC fragments from wood powder through a combination of enzymatic digestion, gel filtration and hydrophobic interaction chromatographic purification using TOYOPEARL HW 50 gel for removing digested polysaccharides25,26.
Preparation of pure LCC fragments through a combination of enzymatic degradation and hydrophobic-gel chromatography
A high concentration of LC bonds and their high purity are crucial prerequisites for the complete structural elucidation of LCC. Thus, enzymatic hydrolysis of C-1-M was conducted. Cellulosin GM5, an enzyme with mainly mannanase activity, was allowed to react with C-1-M. After this digestion, LCC fragments were separated from the digested saccharides using a polyvinyl gel open column with an affinity for lignin. The LCC fragment was then purified by HPLC with a handmade-column filled with the same gel. This separation is a hybrid procedure consisting of gel filtration chromatography (GFC) and hydrophobic interaction chromatography (HIC)25,26. A flowchart of this procedure and a schematic depiction of its stages are reported in Fig. 2A,B, respectively.
Structural elucidation of neutral LCC using long-range-correlation 2D- and 3D-NMR
We analysed the purified LCC fraction using NMR spectroscopy. In Fig. 3 is reported the proposed chemical structure of the α-ether-type LCC. In the 1H–13C HSQC NMR spectrum, a Cα–Hα correlation signal corresponding to the α-ether-type LCC was observed at δH/δC = 4.50 ppm/80.2 ppm, as can be evinced from Fig. 4A,B, in accordance with the values observed for LCC model compounds28,29. In previous studies on LCCs, signals were assigned based only on a pair of chemical shifts originating from one-bond spin couplings between 1H and 13C22,23. However, these results do not conclusively prove the presence of covalent bonds between lignin and saccharides. In the present study, through-bond correlations with 2- to 4-bond spin couplings were analysed by 1H–13C HMBC, 2D HSQC-TOCSY, and 3D TOCSY-HSQC measurements. Correlations of the sugar moiety of LCC partly overlapped in the 2D HSQC-TOCSY; thus, more definite assignments were achieved by extending the correlation analysis into the third dimension employing 3D TOCSY-HSQC.
The multiplicity edited 1H–13C HSQC NMR spectra of the α-ether-type LCC: overall (A) and magnified (B) spectrum. Signals originating from LCC α-ether linkages are labelled as the partial chemical structure on this figure, also shown in Fig. 3.‘α’, ‘β’ and ‘γ’ are 1H–13C correlations at the corresponding positions of lignin moiety of LCC. ‘1′– 6′’ are carbohydrate moiety (β-1,4-D-mannose) of LCC. Free β-O-4′″ lignin units, uncombined with carbohydrates, are abbreviated as ‘A’. Guaiacyl lignin units, erythro form, and threo form are abbreviated as ‘G’, ‘e’ and ‘t’, respectively. Signals originating from CH and CH3 are reported in blue. Methylene CH2 signals are reported in purple.
We then succeeded in the identification of α ether LC bonds. We directly observed the correlation signals associated with α ether LC bonds between lignin-α and the primary hydroxyl group of the mannose residue, C-6′. We were also able to assign all signals related to the LCC structural units by complete connectivity analysis, from the phenylpropane unit to the carbohydrate unit.
The signal assignments are summarised in Table 1 and shown in the edited HSQC spectrum with abbreviations (Figs 4A,B and S1).
Assignment of α-ether-type LCC through-bond NMR correlations in a lignin moiety
Signal assignment started from the Cα–Hα correlation signal of the α-ether-type LCC observed at δH/δC = 4.50 ppm/80.2 ppm in HSQC (Fig. 5A). TOCSY correlations between Hα and β, γ2 and γ1 protons in the guaiacyl lignin were observed at δH = 4.30 ppm, 3.60 ppm, and 3.32 ppm, respectively, in 2D HSQC-TOCSY (Fig. 5B). HMBC correlations between Cα at δC = 80.2 ppm and G2 and G6 protons in the guaiacyl lignin units were observed at δH = 6.95 and 6.74, respectively (Fig. 5C). HMBC correlations between Hα and G2, G6 and G1 carbons in the guaiacyl lignin unit were observed at δC = 111.2 ppm, 120.4 ppm, and 129.4 ppm, respectively (Fig. 5D).
Partial 2D-NMR spectra of one-bond and long-range correlations around the β-O-4′″ lignin subunits of the α-ether-type LCC. (A) 2D 1H–13C HSQC NMR spectrum of the α-position of β-O-4′″ lignin subunits at δH/δC = 4.50 ppm/80.2 ppm. (B) 1H–13C HSQC–TOCSY NMR spectrum of the α-carbon of the β-O-4′″ lignin subunits at δC = 80.2 ppm displaying the TOCSY correlation between the α-proton and the β-, γ1- and γ2-protons of the β-O-4′″ lignin subunits. (C) 1H–13C HSQC (blue) and 1H–13C HMBC (red) overlaid NMR spectra showing the correlations of the α-carbon of the β-O-4′″ lignin subunits (δC = 80.2 ppm) with the G2 and G6 protons of the guaiacyl lignin units. (D) 1H–13C HMBC NMR spectrum, showing the correlations of the α-proton of the β-O-4′″ lignin subunits (δH = 4.5 ppm) with the G2, G6 and G1 carbons of the guaiacyl lignin units.
In the F2–F3 plane (13C–1H plane) of 3D TOCSY-HSQC were observed correlations at 1H shift δH = 4.52 ppm, β-, γ1- and γ2- (Fig. 6A), which can be distinguished from those of the free β-O-4′″ lignin units (uncombined with carbohydrates; see Fig. 6B). The signals in the spectrum reported in Fig. 6A clearly indicate the existence of correlations of the phenylpropane unit in the α-ether-type LCC.
3D 1H–13C TOCSY-HSQC NMR spectra, showing the correlations of the α-proton of the β-O-4′″ lignin subunits with the β-, γ1- and γ2-protons of the guaiacyl lignin unit in the α-ether-type LCC (A) and of the free β-O-4′″ lignin unit (B) in the LCC fraction. Arrows in the structural formulae indicate observed couplings in each spectrum. (A) A slice of the F2–F3 plane of 1H–13C (TOCSY-HSQC at 1H shift of δH = 4.52 ppm), showing the α proton correlated to the β-, γ1- and γ2-protons of the lignin unit in the α-ether-linked LCC. Since the chemical shift of the α proton accidentally coincides with that of the C-1′ proton, also shown is the correlation of the C-1′ proton with the C-2′ proton of the β-d-mannose unit in the α-ether-type LCC. (B) A slice of the F2–F3 plane of 1H–13C (HSQC-TOCSY at 1H shift of δH = 4.71 ppm), showing the correlation of the α proton to the β-, γ1- and γ2-protons of the free β-O-4′″ lignin units (uncombined with carbohydrates).
Assignment of α-ether-type LCC through-bond NMR correlations between the lignin and carbohydrate moieties
The dominant correlation signal observed in the HMBC was the one due to the correlation between the α-carbon at δC = 80.2 ppm and the carbohydrate proton at δH = 3.48 ppm, as shown in Fig. 7A. Symmetrically, a correlation was observed in the HMBC between the α-proton at δH = 4.50 ppm and the carbohydrate carbon at δC = 68.1 ppm, as shown in Fig. 7B. The HSQC correlation peak of δH/δC = 3.48 ppm/68.1 ppm is assigned to C-6′ through the multiplicity-edited HSQC experiment, in which signals originating from CH and CH3, and those from CH2 are observed in opposite sign, a test that demonstrated that the signal of C-6′ at δH/δC = 3.48 ppm/68.1 ppm was due to the methylene group (Fig. 4A,B).
Partial 2D-NMR spectra, showing correlations between the LC linkage and the carbohydrate moiety. Arrows in the structural formula indicate observed couplings in each spectrum. (A) 1H–13C HSQC (blue) and 1H–13C HMBC (red) NMR spectra. The α C-H of the β-O-4′″ lignin subunits, δH/δC = 4.50 ppm/80.2 ppm in HSQC, correlates with the C-6′ proton through the ether linkage. A correlation with the γ2 proton of the guaiacyl unit is also observed. (B) 1H–13C HSQC (blue) and 1H–13C HMBC (red) overlaid NMR spectra. C-6′, δH/δC = 3.48 ppm/68.1 ppm, in HSQC correlates with the α proton of the β-O-4′″ lignin subunit through the ether linkage. (C) 1H–13C HSQC (blue) and 2D 1H–13C HSQC–TOCSY(green) overlaid NMR spectra. C-6′ correlates with the 5′ proton at δH = 3.64 ppm. (D) 1H–13C HSQC (blue) and 2D 1H–13C HSQC–TOCSY(green) overlaid NMR spectra. The C-3′ carbon correlates with the 4′ proton at δH = 3.68 ppm. (E,F) 1H–13C HSQC (blue) and 1H–13C HMBC (red) overlaid NMR spectra. The HMBC correlation from the C-4′ carbon to the 1″ proton (E) and the HMBC correlation from the anomeric C-1″ carbon to the 4′ proton (F) are observed. These correlations reveal β-1,4-linked mannosyl residues of the α-ether-type LCC.
Assignment of α-ether-type LCC through-bond NMR correlations in the carbohydrate moiety
Carbohydrate correlations within the LCC were identified in the 2D HMBC, 2D HSQC-TOCSY and 3D TOCSY-HSQC spectra. A correlation signal due to the C-6′ carbon at δC = 68.1 ppm and the C-5′ proton at δH = 3.64 ppm was observed in the 2D HSQC-TOCSY (Fig. 7C).
TOCSY correlations between C-6′ and C-3′ were observed in the 3D TOCSY-HSQC (Fig. 8). In the slices of the F1–F3 planes, 1H–1H correlations were observed from C-4′ (δH/δC = 3.68 ppm/77.6 ppm), C-5′, C-3′ (overlapped with 5′) and C-6′ (Fig. 8A); correlations from C-5′ (δH/δC = 3.64 ppm/69.0 ppm) to C-4′ and C-6′ (Fig. 8B) and from C-6′ (δH/δC = 3.48 ppm/68.0 ppm) to C-5′ and C-4′ (Fig. 8C) were also observed. Furthermore, TOCSY correlations between C-3′ and C-4′ were observed in the 2D HSQC-TOCSY (Fig. 7D).
3D TOCSY-HSQC NMR spectrum of the α-ether-type LCC. Arrows in the structural formulae indicate observed couplings in each spectrum. (A) A slice of the F1–F3 plane of 1H–1H (TOCSY-HSQC at a 13C shift, δC = 77.9 ppm), showing the carbohydrate correlations of the α-ether-type LCC: C-4′ proton correlated to the C-5′ proton followed by the C-6′ proton of the β-d-mannose unit in the α-ether-type LCC. Correlation to the C-3′ proton is overwrapped with that to the C-5′ proton. (B) A slice of the F1–F3 plane of 1H–1H (TOCSY-HSQC at 13C shift of δC = 68.9 ppm), showing the carbohydrate correlations of the α-ether-type LCC: the C-5′ proton is correlated to the C-4′ and C-6′ protons of the β-d-mannose unit in the α-ether-type LCC. (C) A slice of the F1–F3 plane of 1H–1H (TOCSY-HSQC at 13C shift of δC = 67.9 ppm), showing the carbohydrate correlations of the α-ether-type LCC: the C-6′proton is correlated to the C-5′ proton followed by C-4′ proton of the β-d-mannose unit in the α-ether-type LCC.
A three-bond HMBC correlation was observed that started from a C-4′ carbon at δC = 77.6 ppm and reached a C-1″ proton at δH = 4.54 ppm(Fig. 7E). A symmetric 3-bond HMBC correlation from the C-1″ carbon at δC = 100.5 ppm to the C-4′ proton at δH = 3.68 ppm was observed (Fig. 7F). These correlations demonstrate the presence of the 1–4 glycosidic linkage of the polysaccharide. Additionally, a TOCSY correlation from C-1′ to C-2′ was observed in 3D TOCSY-HSQC, a slice of the F2–F3 plane at a 1H shift of δH = 4.5 ppm, as shown in Fig. 6A.
TOCSY correlations among C-3′, C-4′, C-5′ and C-6′ via spin–spin couplings were observed, whereas correlations among C-2′, C-3′ and C-1′ were not. In general, the J coupling between axial and equatorial protons is weak, and the sequential axial-to-axial proton TOCSY correlations were clearly observed. Evidence thus indicates that the configuration of the C-2′proton is equatorial, resulting in the missing correlation signal through C-2′. These results support the idea that the carbohydrate moiety is d-mannose, a C-2 epimer of d-glucose.
The anomeric configuration of the sugar moiety was determined by the coupling constant, 1JCH, of C-1′. The accurate value of the coupling constant was measured by the chemical shift difference between the correlation peaks in the TROSY and anti-TROSY experiments. A value of 160 Hz was thus determined for 1JCH, indicating a β-anomeric sugar configuration (Fig. 9).
From these findings, we determined that natural LCC has an α ether LC bond at the C-6′ position of β-1,4-linked-d-mannose in glucomannan.
Discussion
Although LCCs have been studied for more than a century, direct evidence of the presence of chemical bonds between lignin and carbohydrates has not yet been obtained. We have succeeded in purifying an LCC fraction to a level superior to that achieved by conventional preparation methods to convincingly prove the existence of a direct lignin–carbohydrate covalent bond. Correlations observed in 2D and 3D NMR spectra, including 1H–13C three-bond correlations between lignin and carbohydrates, demonstrated the presence of α-ether-type LCCs. We have assigned correlations among atoms directly involved in the lignin–carbohydrate linkage and those located in its vicinity, including lignin aromatics, lignin interunit aliphatics and hexose of C1 to C6.
Difficulties in elucidating the structure of LCC arise from the fractionation of LCCs. LC linkages in natural wood cell walls are present in low frequency and diverse throughout macromolecules. In this study, we used water-soluble neutral LCCs from softwood obtained by water extraction of the residue of milled wood lignin (MWL). These LCCs contain pendant-like lignin, that is relatively small lignin molecules attached to hemicellulose chains as ‘pendants’. These compounds are suitable for LC bond analysis due to the relatively high frequency of occurrence of the LC bond and the simplicity of the structure of the hemicelluloses. Another challenge in LC bond analysis is the detection and assignment of the linkages between lignin and carbohydrates. NMR spectroscopy is a powerful tool for the structural analysis of lignocelluloses; however, detection and correlation analysis of LC linkages has proven difficult due to the low number of such linkages. In particular, the low number of LC bonds and the low sensitivity of the spectroscopic method when investigating macromolecules with short T2 values render the observation of long-range correlation signals between lignin and carbohydrates challenging to achieve. We applied glycohydrolase treatment and separated LCC fragments from the hydrolysates using a polyvinyl gel having an affinity to lignin and displaying a size-exclusion effect.
The present study provides the first direct evidence for an α ether bond between lignin and hemicellulose. Thus far, NMR has been applied to the analysis of lignin-carbohydrate bonds, but the previous methods depended on estimation of the structure by chemical shift correlation between model compounds and extracted LCC samples. However, the chemical shifts of these signals are not exactly identical. Also, overlapping signals from other unidentified structures cannot be excluded. In this study, we first observed the long-range correlations through an α-ether bond between lignin and the primary hydroxyl group of a mannose residue in glucomannan, and identified lignin–carbohydrate bonds by complete connectivity analysis from the phenylpropane unit of lignin to the carbohydrate moiety in hemicellulose.
This study strongly supports the idea that the linkage is formed during the polymerisation of lignin in the presence of hemicelluloses via quinone methide formation and subsequent nucleophilic attack of the primary hydroxyl group of the hemicelluloses as found in the experiments that α-ether bonds were preferentially formed between lignin and C-6 position of mannose residue by peroxidase-catalysed dehydrogenative polymerization of coniferyl alcohol in the presence of glucomannan30. The methodologies we devised to conduct this study can be applied to various LCC fractions from different plant sources to obtain detailed structural information on LCCs in plant cell walls.
Conclusions
Determining the possible presence of covalent bonds linking lignin and carbohydrates has been an important research goal in plant science for over 150 years. Although abundant supporting evidence for the existence of these chemical bonds has been accumulated, no direct proof has been reported for these interactions. To demonstrate the existence of these bonds, we purified LCC fragments from a neutral LCC fraction using mannanase and a polyvinyl gel having an affinity to lignin and exerting a size-exclusion effect. We applied HMBC and 13C-edited TOCSY-HSQC analyses to the purified LCC fragments and conclusively detected correlation signals between the C-6 position of the β-mannose residue in glucomannan and the α position of lignin, indicating the presence of an α ether bond between these species. This LCC study provides deeper understanding of plant cell-wall structures and the roles of LC bonds in the physical properties of cell walls, a key research objective for developing conversion technologies for plant biomass through component separation.
Methods
Sample preparation
Fractions of LCCs and MWL were prepared from the reaction wood of Japanese red pine (Pinus densiflora Zieb. et Zucc.) collected in Kyoto, Japan. The pine wood was extracted with ethyl alcohol–benzene mixture (1:2, v/v) and 0.25% aqueous potassium acetate27. The wood meal was dried and subsequently vibromilled for 48 h under a nitrogen atmosphere with external cooling by tap water. The crude MWL fraction was extracted twice from the wood meal with 80% aqueous dioxane for 48 h at room temperature. LCCs were extracted from the wood residue with cold water (20 °C) for 12 h, and then with hot water (80 °C) for 5 h. The two extracts were combined and concentrated to a small volume. A water-soluble LCC (LCC-WE) fraction was precipitated from the concentrated solution by addition of five times the volume of ethyl alcohol. LCC-WE was then fractionated into neutral (C-1-M), acidic (C-l-A) and lignin-rich (C-1-R) sub-fractions by anion-exchange chromatography on DEAE-Sephadex A-50 (CO32− form), as described previously27. The neutral fraction (C-1-M) was used in this study. A flowchart of this sample preparation procedure is presented in Fig. 2A. Smith degradation of C-1-M was conducted by reaction with sodium periodate at 4 °C for 20 days followed by reduction with NaBH4 and hydrolysis with TFA at 100 °C for 3 h. The products were analysed by gas chromatography using a Shimadzu GC-17 on an Ulbon HR-SS-10 column (25 m × 0.25 mm i.d., Shinwa Chemical Industries Ltd, Kyoto) with a temperature gradient from 100 °C to 210 °C at a rate of 5 °C/min.
Enzymatic digestion and purification of LCC fragments
The C-1-M fraction (8.0 g) was digested at 45 °C for 24 h in 0.1 M sodium acetate buffer (pH 4.5) by Cellulosin GM5 (HBI Enzymes Inc., Hyogo, Japan), which displays mainly mannanase activity. Cellulosin GM5 mannanase activity was 1786 U, when digesting glucomannan from Konjac (Wako Pure Chemical Industries, Ltd., Osaka, Japan). 1U is defined as the amount of enzyme releasing 1μmol of reducing sugar per min. After the digestion, LC fragments were separated using a size-exclusion polyvinyl gel with an affinity for lignin13. The enzymatic hydrolysates were loaded onto the hydrophobic interaction/size exclusion gel TOYOPEARL HW50 (80 cm, 8 cm i.d., Tosoh Bioscience LLC, Tokyo, Japan) and eluted with water to wash out the carbohydrate fragments. The eluent was then converted to 50% aqueous 1,4-dioxane to recover the adsorbed LCC fragments. The eluate was collected, concentrated with a rotary evaporator, and purified by HPLC (HITACHI L7000 DAD system, Tokyo, Japan). The conditions for HPLC were as follows: mobile phase, water and 1,4-dioxane, analytical column, TOYOPEARL HW50 (30 cm, 2 cm i.d.), detection wavelength of 190–400 nm, flow rate of 3.0 mL/min, and gradient of 0% to 50% increase in 1,4-dioxane over 10–50 min. The HPLC eluates were collected between 12 and 32 min and analysed by NMR. The flow chart of this procedure and schematic description of it are reported in Fig. 2A,B, respectively.
NMR experiments
Samples were dissolved in 0.5 mL of DMSO-d6 and transferred to an NMR tube. NMR spectra were recorded at a temperature of 313 K using Bruker AVANCE 600 MHz spectrometers equipped with a 5-mm cryoprobe. A 1D 1H NMR spectrum of the sample was acquired using an acquisition time (AQ) of 0.9 s and an inter scan delay (D1) of 2.0 s; 32 scans were recorded. The HSQC spectrum was recorded by performing an adiabatic HSQC experiment (Bruker pulse program ‘hsqccetgpsisp2.2′) with the following parameters; AQ, 0.10 s, D1, 2.0 s, the spectral window of 16 ppm in F2 and 165 ppm in F1 with 2048 × 512 increments, and 32 scans per increment. The 1JCH used was 145 Hz. Prior to Fourier transformation, the data matrices were zero filled to 1024 points in the 13C dimension and processed with a Gaussian window function in the F2 dimension and a sine-bell square window function in the F1 dimension. The multiplicity-edited HSQC was recorded by the Bruker pulse program ‘hsqcedetgp’. The 1H-13C HMBC spectrum was recorded by performing a magnitude-mode ge-2D HMBC using low-pass J-filter (Bruker pulse program ‘hmbcgplpndqf’) with the following parameters; AQ, 0.12 s, D1, 1.2 s, spectral window of 14 ppm in F2 and 150 ppm in F1 with 2048 × 512 increments, 48 scans per increment and processed with a sine-bell window function in both F1 and F2 dimensions. The 2D 1H-13C HSQC-TOCSY spectrum was recorded by the Bruker pulse program ‘hsqcdietgpsi’ with the following parameters; AQ, 0.14 s, D1, 2.0 s, spectral window of 11 ppm in F2 and 130 ppm in F1 with 2048 × 512 increments; 32 scans per increment, 100 ms of TOCSY spin lock period, and processed with a sine-bell square window function in both F1 and F2 dimensions. The 3D 1H-13C TOCSY-HSQC spectrum was recorded by the Bruker pulse program ‘mlevhsqcetgp3d’ with the following parameters; AQ, 0.07 s, D1, 1.0 s, spectral window of 12 ppm in F3, 58 ppm in F2 and 5.5 ppm in F1 with 1024 × 384 × 64 increments, 8 scans per increment, 100 ms of TOCSY spin lock period, and processed with a sine-bell square window function in all dimensions. Data processing was performed using standard Bruker Topspin-NMR software (ver. 3.1). The solvent (DMSO) peak was used as an internal chemical shift reference point (δH/δC = 2.49 ppm/39.6 ppm). The1H-13C TROSY spectrum was recorded by performing an experiment modified from pulse program ‘trosyetgpsisp’. One-bond coupling constants 1JCH are measured by a selection of a pair of single multiplet components in TROSY.
References
Koshijima, T. & Watanabe, T. Association between lignin and carbohydrates in wood and other plant tissues. (Springer Berlin Heidelberg, 2003).
Terashima, N., Yoshida, M., Hafrén, J., Fukushima, K. & Westermark, U. Proposed supramolecular structure of lignin in softwood tracheid compound middle lamella regions. Holzforschung 66 (2012).
Erdmann, J. Ueber die Concretionen in den Birnen. European Journal of Organic Chemistry 138, 1–19 (1866).
Björkman, A. Studies on finely divided wood. Part 1. Extraction of lignin with neutral solvents. Svensk papperstidning 59, 477–485 (1956).
Björkman, A. Studies on finely divided wood. Part 3. Extraction of lignin with neutral solvents. Svensk papperstidning 60, 243–251 (1957).
Lawoko, M., Henriksson, G. & Gellerstedt, G. Structural differences between the lignin−carbohydrate complexes present in wood and in chemical pulps. Biomacromolecules 6, 3467–3473 (2005).
Du, X. Y., Gellerstedt, G. & Li, J. B. Universal fractionation of lignin-carbohydrate complexes (LCCs) from lignocellulosic biomass: an example using spruce wood. Plant Journal 74, 328–338 (2013).
Freudenberg, K. & Grion, G. Beitrag zum Bildungsmechanismus des Lignins und der Lignin-Kohlenhydrat-Bindung. Chemische Berichte 92, 1355–1363 (1959).
Eriksson, Ö., Goring, D. A. I. & Lindgren, B. O. Structural studies on the chemical bonds between lignins and carbohydrates in spruce wood. Wood Sci. Technol. 14, 267–279 (1980).
Košíková, B., Joniak, D. & Kosáková, L. On the Properties of benzyl ether bonds in the lignin-saccharidic complex isolated from spruce. Holzforschung 33, 11 (1979).
Yaku, F., Tanaka, R. & Koshijima, T. Lignin carbohydrate complex. Pt. IV. Lignin as side chain of the carbohydrate in Björkman LCC. Holzforschung 35, 177 (1981).
Watanabe, T. & Koshijima, T. Evidence for an ester linkage between lignin and glucuronic acid in lignin–carbohydrate complexes by DDQ-oxidation. Agric. Biol. Chem. 52, 2953–2955 (1988).
Watanabe, T. Structural studies on the covalent bonds between lignin and carbohydrate in lignin-carbohydrate complexes by selective oxidation of the lignin with 2, 3-Dichloro-5, 6-dicyano-1, 4-benzoquinone. Wood res.: Bull. Wood Res. Inst. Kyoto Univ. 76, 59–123 (1989).
Karl Freudenberg, J. M. H. Modelle für die Bindung des Lignins an die Kohlenhydrate. Chemische Berichte 93, 2814–2819 (1960).
Yaku, F., Yamada, Y. & Koshijima, T. Lignin carbohydrate complex Pt. II. Enzymic degradation of acidic polysaccharide in Björkman LCC. Holzforschung 30, 148 (1976).
Knut Lundquist, R. S. Kenneth Tingsvik. Lignin carbohydrate linkages in milled wood lignin preparations from spruce wood. Svensk papperstidning 86, 44–37 (1983).
Smelstorius, J. A. Chemical composition of wood of Australian-grown Pinus radiata D. Don. III. Lignin-polysaccharide complexes. Holzforschung 28, 99 (1974).
Joseleau, J.-P. & Kesraoui, R. Glycosidic bonds between lignin and carbohydrates. Holzforschung 40, 163 (1986).
Yimin Xie, S. Y., Wu, H. & Analysis, H. L. of the structure of lignin-carbohydrate complexes by the specific13C tracer method. J. Wood Sci. 46, 130–136 (2000).
Miyagawa, Y., Kamitakahara, H. & Takano, T. Fractionation and characterization of lignin-carbohydrate complexes (LCCs) of Eucalyptus globulus in residues left after MWL isolation. Part II: Analyses of xylan-lignin fraction (X-L). Holzforschung 67, 629–642 (2013).
Du, X. Y. et al. Analysis of lignin-carbohydrate and lignin-lignin linkages after hydrolase treatment of xylan-lignin, glucomannan-lignin and glucan-lignin complexes from spruce wood. Planta 239, 1079–1090 (2014).
Balakshin, M. Y., Capanema, E. A. & Chang, H.-m MWL fraction with a high concentration of lignin-carbohydrate linkages: Isolation and 2D NMR spectroscopic analysis. Holzforschung 61, 1–7 (2007).
Balakshin, M., Capanema, E., Gracz, H., Chang, H. M. & Jameel, H. Quantification of lignin-carbohydrate linkages with high-resolution NMR spectroscopy. Planta 233, 1097–1110 (2011).
Yuan, T. Q., Sun, S. N., Xu, F. & Sun, R. C. Characterization of lignin structures and lignin-carbohydrate complex (LCC) linkages by quantitative 13C and 2D HSQC NMR spectroscopy. J. Agric. Food. Chem. 59, 10604–10614 (2011).
Watanabe, T., Junichi, A. & Koshijima, T. Isolation of lignin-carbohydrate complex fragments by adsorption chromatography. Mokuzai Gakkaishi 31, 52–53 (1985).
Watanabe, T., Ohnishi, J., Yamasaki, Y., Kaizu, S. & Koshijima, T. Binding-site analysis of the ether linkages between lignin and hemicelluloses in lignin–carbohydrate complexes by DDQ-oxidation. Agric. Biol. Chem. 53, 2233–2252 (1989).
Watanabe, T., Junichi, A. & Koshijima, T. A convenient method for preparing lignin-carbohydrate complex from Pinus densiflora wood. Mokuzai Gakkaishi 33, 798–803 (1987).
Toikka, M. Lignin–carbohydrate model compounds. Formation of lignin–methyl arabinoside and lignin–methyl galactoside benzyl ethers via quinine methide intermediates. J. Chem. Soc., Perkin Trans. 1, 3813 (1998).
Toikka, M. Lignin–carbohydrate model compounds. Reactivity of methyl 3-O-(α-l-arabinofuranosyl)-β-d-xylopyranoside and methyl β-d-xylopyranoside towards a β-O-4-quinone methide. J. Chem. Soc., Perkin Trans. 1, 1877 (1999).
Ohnishi, J., Watanabe, T. & Koshijima, T. Synthesis of dehydrogenation polymer-polyose complexes by peroxidase. Phytochemistry 31, 1185–1190 (1992).
Acknowledgements
This study was supported in part by JSPS KAKENHI for Young Scientists (24880022 and 16H06210), a collaboration programme of RISH (M5-2-4), a joint usage/research programme of IAE (ZE28A-32), and CREST (JPMJCR11B4) from Japan Science and Technology Agency. We thank Prof. John Ralph, University of Wisconsin, for valuable suggestions for 3D TOCSY HSQC experiments.
Author information
Authors and Affiliations
Contributions
H.N., M.K. and T.W. designed research. H.N. and A.K., performed research. H.N. and T.W. wrote the manuscript. T.N. and M.K. refined the manuscript.
Corresponding author
Ethics declarations
Competing Interests
The authors declare no competing interests.
Additional information
Publisher's note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Electronic supplementary material
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The images or other third party material in this article are included in the article’s Creative Commons license, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons license and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this license, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Nishimura, H., Kamiya, A., Nagata, T. et al. Direct evidence for α ether linkage between lignin and carbohydrates in wood cell walls. Sci Rep 8, 6538 (2018). https://doi.org/10.1038/s41598-018-24328-9
Received:
Accepted:
Published:
DOI: https://doi.org/10.1038/s41598-018-24328-9
- Springer Nature Limited