Abstract
The synthesis and performance of La0.7Sr0.3VO3/YSZ composites are investigated as alternative anodes for the direct utilization of methane (i.e., biogas) in solid oxide fuel cells. In this study, the structural stability between Sr-doped lanthanum vanadate and yttria-stabilized zirconia was investigated by using the powder mixture annealed at various periods of time and temperatures. The chemical reaction between these two materials in the temperature ranging from 1100 to 1400 °C was examined by X-ray diffraction (XRD) and electron probe microanalysis (EPMA) analyses. According to the examination of La0.7Sr0.3VO3/YSZ powder mixture after heat treatment at 1100–1400 °C, no second phase was detected when the La0.7Sr0.3VO3/YSZ powder mixture was heated at 1100 °C. The reaction products of perovskite SrZrO3 were formed when the specimens were heated treatment at over 1200 °C. Owing to the further diffusion of Sr cations from La0.7Sr0.3VO3 toward the reaction layer/YSZ interface via the reaction layer, the reaction layer was extended into the YSZ. The interfacial reaction behavior between electrode and electrolyte pellets of the reaction couple was examined by EPMA. No reaction products were observed as La0.7Sr0.3VO3/YSZ composite co-fired at 1100 °C. The reaction products of perovskite SrZrO3 were formed when the specimens were heat treated at over 1200 °C. The bonding energy between La-O (188 kcal/mol) is stronger than Sr-O (83.6 kcal/mol). Thus, Sr ions tend to migrate and react with YSZ much faster than La ions. Furthermore, when the Sr concentration increases to 70%, excess of SrZrO3 formation leads to the phase decomposition of perovskite La0.3Sr0.7VO3.
Similar content being viewed by others
References
Setoguchi, T., Sawano, M., Eguchi, K., Arai, H.: Application of the stabilized zirconia thin film prepared by spray pyrolysis method to SOFC. Solid State Ionics. 40–41, 502–505 (1990)
Charpentier, P., Fragnaud, P., Schleich, D.M., Gehain, E.: Preparation of thin film SOFCs working at reduced temperature. Solid State Ionics. 135, 373–380 (2000)
Fukui, T., Ohara, S., Murata, K., Yoshida, H., Miura, K., Inagaki, T.: Performance of intermediate temperature solid oxide fuel cells with La(Sr)Ga(Mg)O3 electrolyte film. J Power Sources. 106, 142–145 (2002)
Bringley, J.F., Scott, B.A., Placa, S.J., MnGuire, T.R., Mehran, F., McElfresh, M.W., Cox, D.E.: Structure and properties of the LaCuO3-δ perovskites. Phys Rev B. 47(15), 269–275 (1993)
Petrov, A.N., Kononchuk, O.F., Andreev, A.V., Cherepanov, V.A., Kofstad, P.: Crystal structure, electrical and magnetic properties of La1 − xSrxCoO3 − y. Solid State Ionics. 80, 189–199 (1995)
Karppinen, M., Yamauchi, H., Suematsu, H., Fukunaga, O.: Synthesis of various LaCuO3−y phases by a high-pressure technique and subsequent post-annealing treatments. Physica C. 264, 268–274 (1996)
Dougier, P., Casalot, A.: Sur Quelques Nouvelles Series de Composes Oxygenes du Vanadium et des Lanthanides de Structure Perovskite. J Solid State Chem. 2, 396–403 (1970)
Dougier, P., Fan, J.C.C., Goodenough, J.B.: Etude des proprietes magnetiques, electriques et optiques des phases de structure perovskite SrVO2.90 et SrVO3. J Solid State Chem. 14, 247–259 (1975)
Mahajan, A.V., Johnston, D.C., Torgeson, D.R., Borsa, F.: Structural, electronic, and magnetic properties of LaxSr1-xVO3 (0.1 <= x <= 1.0). Phys Rev B. 46, 10973–10985 (1992)
Giannakopoulou, V., Odier, P., Bassat, J.M., Loup, J.P.: SrVO3 and Sr2VO4, electrical properties below and above room T. Solid State Commun. 93, 579–583 (1995)
Hui, S.Q., Petric, A.: Conductivity and stability of SrVO3 and mixed perovskites at low oxygen partial pressures. Solid State Ionics. 143, 275–283 (2001)
Ge, X.M., Chan, S.H.: Lanthanum strontium vanadate as potential anodes for solid oxide fuel cells. J Electrochem Soc. 156(3), B386–B391 (2009)
Brugnoni, C., Ducati, U., Scagliotti, M.: SOFC cathode/electrolyte interface. Part I: reactivity between La0.85Sr0.15MnO3 and ZrO2-Y2O3. Solid State Ionics. 76, 177–182 (1995)
Kuge’er, D., Holc, J., Hrovat, M., Bernik, S., Samardmija, Z., Kolar, D.: Interactions between a thick film LaMnO3 cathode and YSZ SOFC electrolyte during high temperature ageing. Solid State Ionics. 78, 79–85 (1995)
Taimatsu, H., Wada, K., Yamamura, H.: Mechanism of reaction between lanthanum manganite and yttria-stabilized zirconia. J Am Ceram Soc. 75, 401–405 (1992)
Yokokawa, H., Sakai, N., Kawada, T., Dokiya, M.: Thermodynamic analysis on interface between perovskite electrode and YSZ electrolyte. Solid State Ionics. 40/41, 398–401 (1990)
van Roosmalen, J.A.M., Cordfunke, E.H.P.: Chemical reactivity and interdiffusion of (La, Sr)MnO3 and (Zr, Y)O2 solid oxide fuel cell cathode and electrolyte materials. Solid State Ionics. 52, 303–312 (1992)
Yokokawa, H., Sakai, N., Kawada, T., Dokiya, M.:Chemical thermodynamic stability of the interface. In: Badwal, S.P.S., Bannister, M.J., Hannink, R.H.J. (eds.) Science and Technology of Zirconia V, pp. 752–763. Technomic Publishing Co., Lancaster (1993)
Stochniol, G., Syskakis, E., Naoumidis, A.: Chemical compatibility between strontium-doped lanthanum manganite and yttria-stabilized zirconia. J Am Ceram Soc. 78, 929–932 (1995)
Funding
The authors acknowledge the financial support provided by the Ministry of Science and Technology Taiwan under grant MOST-105-2923-E-006-004-MY3. This work was also financially supported by the Hierarchical Green-Energy Materials (Hi-GEM) Research Center from The Featured Areas Research Center Program within the framework of the Higher Education Sprout Project by the Ministry of Education (MOE) in Taiwan.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Liu, CY., Tsai, SY., Ni, CT. et al. Interfacial reaction between YSZ electrolyte and La0.7Sr0.3VO3 perovskite anode for application. J Aust Ceram Soc 55, 97–102 (2019). https://doi.org/10.1007/s41779-018-0215-2
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s41779-018-0215-2