Skip to main content

Advertisement

SpringerLink
Log in

Animal solid waste as a potential renewable biomass energy source: a case study of Jordan

  • Original Article
  • Published:
Biomass Conversion and Biorefinery Aims and scope Submit manuscript

Abstract

Livestock and chicken manures generated in 2017 in Al-Mafraq governorate (North of Jordan) were estimated to be around 250 × 103 tons and expected to increase in the coming years. Therefore, the accumulation of animal manures will continue to pose a significant threat to public health by direct or indirect exposure. In this work, manures of cow, sheep/goats, and chicken and poultry litter were tested for their chemical composition and thermal characteristics, and then the potential of these manures as valuable renewable energy resources were examined. The proximate and ultimate analyses of these wastes were evaluated along with their heating values. Representative samples of different animal manures, chicken feather, and poultry litter were also subjected to a pyrolysis process. Poultry litter had the highest heating value (19.48 MJ/kg) among the tested samples, followed by chicken feathers (18.95 MJ/kg) and sheep/goat (10.92 MJ/kg). Cow manure had the lowest heat value (8.68 MJ/kg). Based on the elemental analysis, poultry waste had the highest contents of carbon and hydrogen, while cow manure had the lowest. Positive correlations were found between the levels of hydrogen and carbon of the selected wastes and their heat values. Poultry litter had a high nitrogen content and a low C:N ratio, whereas cow manure had the lowest nitrogen content and the highest C:N ratio. Poultry manure and litter had a higher volatile matter and a lower ash content than sheep/goat and cow manures. Chicken manure was the best among the tested samples in terms of bio-oil production (36 wt%) followed by poultry litter and sheep/goat manures, while cow manure was the lowest. Poultry litter was found to be the best source for biogas production. It is anticipated that 48.7 million m3 of biogas can be produced annually from the available animal waste resources in this governorate, and this amount of biogas can be converted into energy of about 10.1 × 106 GJ. This amount of energy can satisfy the energy demand of at least 5% of the population in the Al-Mafraq governorate. In conclusion, the study recommended that converting animal solid manures to energy would be a promising waste management option or strategy to be applied in this governorate as well as in Jordan.

Graphical abstract

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4

Similar content being viewed by others

Abbreviations

EA:

Elemental analyzer

TCD:

Thermal conductivity detector

TG:

Thermogravimetric

TGA:

Thermogravimetric analysis

HHV:

Higher heat value

LHV:

Lower heat value

NCV:

Net calorific value

GCV:

Gross calorific value

W:

Weight

VS:

Volatile solids content

BOD5:

Biochemical oxygen demand

DS:

Dry solid

MCM:

Million cubic meter

CM:

Cow manure

GM:

Goat manure

ChM:

Chicken manure

PL:

Poultry litter

LCA:

Life cycle assessment

References

  1. Irfan M, Zhao Z-Y, Ahmad M, Mukeshimana MC (2019) Solar energy development in Pakistan: barriers and policy recommendations. Sustainability 11(4):1206

    Article  Google Scholar 

  2. Irfan M, Zhao Z-y, Ahmad M, Batool K, Jan A, Mukeshimana MC (2019) Competitive assessment of Indian wind power industry: a five forces model. J Renew Sust Energ 11(6):063301

    Article  Google Scholar 

  3. Azadbakht M, Safieddin Ardebili SM, Rahmani M (2021) Potential for the production of biofuels from agricultural waste, livestock, and slaughterhouse waste in Golestan province. Biomass Conversion and Biorefinery, Iran

    Google Scholar 

  4. Azadbakht M, Safieddin Ardebili SM, Rahmani M (2021) A study on biodiesel production using agricultural wastes and animal fats. Biomass Convers Bior. https://doi.org/10.1007/s13399-021-01308-0

    Article  Google Scholar 

  5. Omrani G (1996) Basics biogas production from urban and rural waste. University of Tehran Publications, Iran

    Google Scholar 

  6. Ryser ET (2001) Public health concerns. In: Marth EH, Steele JL (eds) Applied dairy microbiology. Marcel Dekker, Inc., New York, pp 397–545

  7. Nicholson FA, Groves SJ, Chambers BJ (2005) Pathogen survival during livestock manure storage and following land application. Bioresour Technol 96(2):135–143

    Article  Google Scholar 

  8. Avcioğlu AO, Türker U (2012) Status and potential of biogas energy from animal wastes in Turkey. Renew Sust Energ Rev 16(3):1557–1561

    Article  Google Scholar 

  9. Ogbuewu I, Omede A, Durunna C, Emenalom O, Uchegbu MC, Okoli I, Iloeje M (2012) Livestock waste and its impact on the environment. Sci J Rev 1:17–32

    Google Scholar 

  10. Truong L, Morash D, Liu Y, King A (2019) Food waste in animal feed with a focus on use for broilers. Int J Recycl Organic Waste Agri 8(4):417–429

    Article  Google Scholar 

  11. Afazeli H, Jafari A, Rafiee S, Nosrati M (2014) An investigation of biogas production potential from livestock and slaughterhouse wastes. Renew Sust Energ Rev 34:380–386

    Article  Google Scholar 

  12. Al-Hamamre Z, Saidan M, Hararah M, Rawajfeh K, Alkhasawneh HE, Al-Shannag M (2017) Wastes and biomass materials as sustainable-renewable energy resources for Jordan. Renew Sust Energ Rev 67:295–314

    Article  Google Scholar 

  13. Ayilara MS, Olanrewaju OS, Babalola OO, Odeyemi O (2020) Waste management through composting: challenges and potentials. Sustainability 12(11):4456

    Article  Google Scholar 

  14. Díaz-Vázquez D, Alvarado-Cummings SC, Meza-Rodríguez D, Senés-Guerrero C, de Anda J, Gradilla-Hernández MS (2020) Evaluation of biogas potential from livestock manures and multicriteria site selection for centralized anaerobic digester systems: the case of Jalisco. México Sustainability 12(9):3527

    Article  Google Scholar 

  15. Batzias FA, Sidiras DK, Spyrou EK (2005) Evaluating livestock manures for biogas production: a GIS based method. Renew Energy 30(8):1161–1176

    Article  Google Scholar 

  16. Cantrell KB, Ducey T, Ro KS, Hunt PG (2008) Livestock waste-to-bioenergy generation opportunities. Bioresour Technol 99(17):7941–7953

    Article  Google Scholar 

  17. Safieddin Ardebili SM, Asakereh A, Soleymani M (2020) An analysis of renewable electricity generation potential from municipal solid waste: a case study (Khuzestan Province, Iran). Biomass Convers Bior. https://doi.org/10.1007/s13399-020-01011-6

    Book  Google Scholar 

  18. Safieddin Ardebili SM (2020) Green electricity generation potential from biogas produced by anaerobic digestion of farm animal waste and agriculture residues in Iran. Renew Energy 154:29–37

    Article  Google Scholar 

  19. Irfan M, Hao Y, Panjwani MK, Khan D, Chandio AA, Li H (2020) Competitive assessment of South Asia’s wind power industry: SWOT analysis and value chain combined model. Energy Strateg Rev 32:100540

    Article  Google Scholar 

  20. Magrí A, Teira-Esmatges MR (2015) Assessment of a composting process for the treatment of beef cattle manure. J Environ Sci Health B 50(6):430–438

    Article  Google Scholar 

  21. Font-Palma C (2019) Methods for the treatment of cattle manure—a review. C Journal of Carbon Research 5(2):27. https://doi.org/10.3390/c5020027

    Article  Google Scholar 

  22. Aguirre-Villegas HA, Larson RA (2017) Evaluating greenhouse gas emissions from dairy manure management practices using survey data and lifecycle tools. J Clean Prod 143:169–179

    Article  Google Scholar 

  23. Esteves EMM, Herrera AMN, Esteves VPP, Morgado CdRV (2019) Life cycle assessment of manure biogas production: a review. J Clean Prod 219:411–423

    Article  Google Scholar 

  24. Fernandez-Lopez M, Puig-Gamero M, Lopez-Gonzalez D, Avalos-Ramirez A, Valverde J, Sanchez-Silva L (2015) Life cycle assessment of swine and dairy manure: pyrolysis and combustion processes. Bioresour Technol 182:184–192

    Article  Google Scholar 

  25. Abu-Ashour J, Qdais HA, Al-Widyan M (2010) Estimation of animal and olive solid wastes in Jordan and their potential as a supplementary energy source: an overview. Renew Sust Energ Rev 14(8):2227–2231

    Article  Google Scholar 

  26. British Standard/ International Organization for Standardization (2013) Solid mineral fuels: Determination of total sulphur (Eschka method) (BS ISO 334:2013)

  27. International Organization for Standardization (2010) Hard coal and coke — determination of volatile matter (ISO 562:2010(en))

  28. International Organization for Standardization (2010) Solid mineral fuels — determination of ash (ISO 1171:2010(en))

  29. Melikoglu M, Lin C, Webb C (2013) Analysing global food waste problem: pinpointing the facts and estimating the energy content. Open Eng 3(2):157–164

    Article  Google Scholar 

  30. Thangarasu V, Anand R (2019) 11 - Physicochemical fuel properties and tribological behavior of aegle marmelos correa biodiesel. In: Azad K (ed) Advances in eco-fuels for a sustainable environment. Woodhead Publishing, Sawston, Cambridge, pp 309–336

    Chapter  Google Scholar 

  31. Abdeshahian P, Lim JS, Ho WS, Hashim H, Lee CT (2016) Potential of biogas production from farm animal waste in Malaysia. Renew Sust Energ Rev 60:714–723

    Article  Google Scholar 

  32. Zareei S (2018) Evaluation of biogas potential from livestock manures and rural wastes using GIS in Iran. Renew Energy 118:351–356

    Article  Google Scholar 

  33. Tatlidil FF, Bayramoglu Z, Akturk D (2009) Animal manure as one of the main biogas production resources: case of Turkey. J Anim Vet Adv 8:2473–2476

    Google Scholar 

  34. Saidan M, Khasawneh HJ, Tayyem M, Hawari M (2017) Getting energy from poultry waste in Jordan: cleaner production approach. J Chem Technol Metall 52(3):595–601

    Google Scholar 

  35. Dornelas KC, Schneider RM, Amaral do AG (2017) Biogas from poultry waste—production and energy potential. Environ Monit Assess 189(8):407

    Article  Google Scholar 

  36. JDOS. Number of livestock by governorate. [Jordan Department of Statistics] 2017. Available from: http://dosweb.dos.gov.jo/agriculture/livestock/number-of-livestock-by-governorate/. Accessed 07/05/2021

  37. IJDOS. Number of livestock by governorate. [Jordan Department of Statistics] 2019. Available from: http://dosweb.dos.gov.jo/agriculture/livestock/number-of-livestock-by-governorate/. Accessed 07/05/2021

  38. Dunlop MW, McAuley J, Blackall PJ, Stuetz RM (2016) Water activity of poultry litter: relationship to moisture content during a grow-out. J Environ Manag 172:201–206

    Article  Google Scholar 

  39. Park J, Cho KH, Ligaray M, Choi M-J (2019) Organic matter composition of manure and its potential impact on plant growth. Sustainability 11(8):2346

    Article  Google Scholar 

  40. Alsheyab MAT, Schingnitz D, Al-Shawabkeh AF, Kusch S (2013) Analysis of the potential use of major refuse-derived fuels in Jordan as supplementary fuel. J Air Waste Manag Assoc 63(8):902–908

    Article  Google Scholar 

  41. Wang X, Yang G, Feng Y, Ren G, Han X (2012) Optimizing feeding composition and carbon–nitrogen ratios for improved methane yield during anaerobic co-digestion of dairy, chicken manure and wheat straw. Bioresour Technol 120:78–83

    Article  Google Scholar 

  42. Al-Da’asen A (2020) Effect of pre-treatment of wheat straw and sludge digestion on biogas yield production. Master Department of Environmetal Engineering: Al-Hussein Bin University, Supervisors Al-Hweiti M and Al-Harahsheh A 

  43. Patel B, Gami B (2012) Biomass characterization and its use as solid fuel for combustion. Iran J Energy Environ 3(2):123–128

    Google Scholar 

  44. Harker JH, Backhurst JR (1981) Fuel and energy. Academic Press, London

    Google Scholar 

  45. JDOS. Demographic statistics - (Population). [Jordan Department of Statistics] 2020. Available from: http://jorinfo.dos.gov.jo/Databank/pxweb/en/Demographi_Statistics/. Accessed 07/05/2021

  46. Erdogdu AE, Polat R, Ozbay G (2019) Pyrolysis of goat manure to produce bio-oil. Eng Sci Technol Int J 22(2):452–457

    Google Scholar 

  47. Ngo T-A, Kim J, Kim SK, Kim S-S (2010) Pyrolysis of soybean oil with H-ZSM5 (proton-exchange of zeolite socony mobil #5) and MCM41 (mobil composition of matter no. 41) catalysts in a fixed-bed reactor. Energy 35(6):2723–2728

    Article  Google Scholar 

  48. Pedersen AJ, Frandsen FJ, Riber C, Astrup T, Thomsen SN, Lundtorp K, Mortensen LF (2009) A full-scale study on the partitioning of trace elements in municipal solid waste incineration—effects of firing different waste types. Energ Fuel 23(7):3475–3489

    Article  Google Scholar 

  49. Jahirul MI, Rasul MG, Chowdhury AA, Ashwath N (2012) Biofuels production through biomass pyrolysis —a technological review. Energies 5(12):4952–5001

    Article  Google Scholar 

  50. Touray N, Tsai W-T, Chen H-R, Liu S-C (2014) Thermochemical and pore properties of goat-manure-derived biochars prepared from different pyrolysis temperatures. J Anal Appl Pyrolysis 109:116–122

    Article  Google Scholar 

Download references

Acknowledgements

The authors would like to express their thanks to Cementra Company in Al-Mafraq governorate for performing the ultimate and approximate analysis of solid animal waste samples used in this study.

Author information

Authors and Affiliations

  1. Department of Civil Engineering, Al Al-Bayt University, P.O. Box 130040, Al-Mafraq, Jordan

    Omar Toheeteh Alnhoud

  2. Department of Chemical Engineering, Mutah University, P.O. Box 7, Mutah, Jordan

    Adnan Mohammad Al-Harahsheh

  3. Department of Chemical Engineering, Jordan University of Science and Technology, Irbid, 22110, Jordan

    Mohammad Salameh Al-Harahsheh

  4. Department of Biological Sciences, Al Al-Bayt University, P.O. Box 130040, Al-Mafraq, Jordan

    Fawzi Irshaid Irshaid

Authors
  1. Omar Toheeteh Alnhoud
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Adnan Mohammad Al-Harahsheh
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Mohammad Salameh Al-Harahsheh
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Fawzi Irshaid Irshaid
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Adnan Mohammad Al-Harahsheh.

Additional information

Publisher’s note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Alnhoud, O.T., Al-Harahsheh, A.M., Al-Harahsheh, M.S. et al. Animal solid waste as a potential renewable biomass energy source: a case study of Jordan. Biomass Conv. Bioref. 13, 6807–6816 (2023). https://doi.org/10.1007/s13399-021-01714-4

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13399-021-01714-4

Keywords

Search

Navigation