Skip to main content
SpringerLink
Log in

Synergic Impacts of Two Non-ionic Natural Surfactants and Low Salinity Water on Interfacial Tension Reduction, Wettability Alteration and Oil Recovery: Experimental Study on Oil Wet Carbonate Core Samples

  • Original Paper
  • Published:
Natural Resources Research Aims and scope Submit manuscript

Abstract

Low salinity water (LSW) flooding alters rock surface wettability toward more water wetness, and consequently, oil recovery will be increased from a carbonate oil reservoir. Surfactant flooding and polymer flooding enhance oil recovery by oil–water interfacial tension (IFT) reduction and water–oil mobility ratio change, respectively. In this study, a combination of LSW and two non-ionic natural surfactants for enhanced oil recovery was evaluated. Four types of salts (CaCl2, MgCl2, Na2SO4, and MgSO4) at different concentrations in distilled water were used to find optimal LSW based on contact angle (CA) reduction. Two non-ionic natural surfactants (a new natural surfactant from Gemini surfactants (GS) family and Tribulus terrestris surfactant) were applied to obtain their optimum concentration based on IFT reduction. The minimum IFT was achieved in 2000 ppm of GS (4.06 mN/m) and 3000 ppm of TTS (6.21 mN/m). Experimental results showed that the presence of GS in low salinity surfactant solution (1000 ppm of MgSO4 and 2000 ppm GS) is capable to reduce IFT (to 1.02 mN/m) and CA (to 31.25°). Therefore, GS showed good results in IFT improvement and wettability alteration. Finally, the optimal LSS was combined with different concentrations of PHPA polymer and injected into cores. Core flooding results demonstrated 69.7% oil recovery for LSW injection, 82.2% for low salinity GS injection (an increase of 12.5%) and 87.9% for low salinity GS-polymer injection (an increase of 5.7%).

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Figure 1
Figure 2
Figure 3
Figure 4
Figure 5
Figure 6
Figure 7
Figure 8
Figure 9
Figure 10
Figure 11
Figure 12
Figure 13

Similar content being viewed by others

References

  • Abo-Riya, M., Tantawy, A. H., & El-Doughoug, W. (2016). Synthesis and evaluation of novel cationic gemini surfactants based on Guava crude fat as petroleum-collecting and dispersing agents. Journal of Molecular Liquids, 221, 642–650.

    Google Scholar 

  • Ahmadi, M. A., Arabsahebi, Y., Shadizadeh, S. S., & Shokrollahzadeh Behbahani, S. (2014). Preliminary evaluation of mulberry leaf-derived surfactant on interfacial tension in an oil-aqueous system: EOR application. Fuel, 117, 749–775.

    Google Scholar 

  • Alagic, E., & Skauge, A. (2010). Combined low salinity brine injection and surfactant flooding in mixed-wet sandstone cores. Energy & Fuels, 24, 3551–3559.

    Google Scholar 

  • Alagic, E., Spildo, K., Skauge, A., & Solbakken, J. (2011). Effect of crude oil ageing on low salinity and low salinity surfactant flooding. Journal of Petroleum Science and Engineering, 78, 220–227.

    Google Scholar 

  • Al-Saedi, H. N., Brady, P. V., Flori, R. E., & Heidari, P. (2019a). Insights into the role of clays in low salinity water flooding in sand columns. Journal of Petroleum Science and Engineering, 174, 291–305.

    Google Scholar 

  • Al-Saedi, H. N., & Flori, R. E. (2019). Effect of divalent cations in low salinity water flooding in sandstone reservoirs. Journal of Molecular Liquids, 275, 163–172.

    Google Scholar 

  • Al-Saedi, H. N., Flori, R. E., & Brady, P. V. (2019b). Effect of divalent cations in formation water on wettability alteration during low salinity water flooding in sandstone reservoirs: Oil recovery analyses, surface reactivity tests, contact angle, and spontaneous imbibition experiments. Journal of Molecular Liquids, 283, 417–426.

    Google Scholar 

  • Anderson, W. G. (1986). Wettability literature survey—Part 2: Wettability measurement. Journal of Petroleum Technology, 38, 1246–1262.

    Google Scholar 

  • Austad, T., Fjelde, I., Veggeland, K., & Taugbol, K. (1994). Physicochemical principles of low tension polymer flood. Journal of Petroleum Science and Engineering, 10, 255–269.

    Google Scholar 

  • Chang, H., Zhang, H., Jia, Z., Li, X., Gao, W., & Wei, W. L. (2016). Wettability of coal pitch surface by aqueous solutions of cationic Gemini surfactants. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 494, 59–64.

    Google Scholar 

  • Chhetri, A. B., Watts, K. C., Rahman, M. S., & Islam, M. R. (2009). Soapnut extract as a natural surfactant for enhanced oil recovery. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 31, 1893–1903.

    Google Scholar 

  • Daghlian, S. J., Sharifi, M., & Hemmati, A. (2016). Toward mechanistic understanding of surfactant flooding in enhanced oil recovery processes: The role of salinity, surfactant concentration and rock type. Journal of Molecular Liquids, 222, 632–639.

    Google Scholar 

  • Deymeh, H., Shadizadeh, S. S., & Motafakkerfard, R. (2012). Experimental investigation of Seidlitzia rosmarinus effect on oil–water interfacial tension: Usable for chemical enhanced oil recovery. Scientia Iranica, 12, 1661–1664.

    Google Scholar 

  • Jia, H., Leng, X., Hu, M., Song, Y., Wu, H., Lian, P., et al. (2017). Systematic investigation of the effects of mixed cationic/anionic surfactants on the interfacial tension of a water/model oil system and their application to enhance crude oil recovery. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 529, 621–627.

    Google Scholar 

  • Jiang, P., Li, N., Ge, J., Zhang, G., Wang, Y., Chen, L., et al. (2014). Efficiency of a sulfobetaine-type surfactant on lowering IFT at crude oil–formation water interface. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 443, 141–148.

    Google Scholar 

  • Johannessen, A. M., & Spildo, K. (2013). Enhanced oil recovery (EOR) by combining surfactant with low salinity injection. Energy & Fuels, 27, 5738–5749.

    Google Scholar 

  • Kamal, M. S., Sultan, A. S., Al-Mubaiyedh, U. A., & Hussein, I. A. (2015a). Review on polymer flooding: Rheology, adsorption, stability, and field applications of various polymer systems. Polymer Reviews, 55, 491–530.

    Google Scholar 

  • Kamal, M. S., Sultan, A. S., Al-Mubaiyedh, U. A., Hussein, I. A., & Feng, Y. (2015b). Rheological properties of thermoviscosifying polymers in high-temperature and high-salinity environments. The Canadian Journal of Chemical Engineering, 93, 1194–1200.

    Google Scholar 

  • Karimi, M., Al-Maamari, R. S., Ayatollahi, S., & Mehranbod, N. (2016). Wettability alteration and oil recovery by spontaneous imbibition of low salinity brine into carbonates: Impact of Mg2+, SO42− and cationic surfactant. Journal of Petroleum Science and Engineering, 147, 560–569.

    Google Scholar 

  • Khorsandi, S., Qiao, C., & Johns, R. T. (2017). Displacement efficiency for low-salinity polymer flooding including wettability alteration. SPE Journal, 22(2), 417–430.

    Google Scholar 

  • Lashkarbolooki, M., Ayatollahi, S., & Riazi, M. (2014). The impacts of aqueous ions on interfacial tension and wettability of an asphaltenic-acidic crude oil reservoir during smart water injection. Journal of Chemical and Engineering Data, 11, 3624–3634.

    Google Scholar 

  • Manshad, A. K., Rezaei, M., Moradi, S., Nowrouzi, I., & Mohammadi, A. H. (2017). Wettability alteration and interfacial tension (IFT) reduction in enhanced oil recovery (EOR) process by ionic liquid flooding. Journal of Molecular Liquids. https://doi.org/10.1016/j.molliq.2017.10.009.

    Article  Google Scholar 

  • Menger, F. M., & Littau, C. A. (1993). Gemini surfactants: A new class of self-assembling molecules. Journal of the American Chemical Society, 115, 10083–10090.

    Google Scholar 

  • Moradi, S., Isari, A. A., Bachari, Z., & Mahmoodi, H. (2019). Combination of a new natural surfactant and smart water injection for enhanced oil recovery in carbonate rock: Synergic impacts of active ions and natural surfactant concentration. Journal of Petroleum Science and Engineering, 176, 1–10.

    Google Scholar 

  • Pal, N., Samanta, K., & Mandal, A. (2019). A novel family of non-ionic Gemini surfactant from sunflower oil: Synthesis, characterization and physicochemical evaluation. Journal of Molecular Liquids, 275, 638–653.

    Google Scholar 

  • Pooryousefy, E., Xie, Q., Chen, Y., Sari, A., & Saeedi, A. (2018). Drives of low salinity effect in sandstone reservoir. Journal of Molecular Liquids, 250, 396–403.

    Google Scholar 

  • Puntervold, T., Strand, S., Ellouz, R., & Austad, T. (2015). Modified seawater as a smart EOR fluid in chalk. Journal of Petroleum Science and Engineering, 133, 440–443.

    Google Scholar 

  • Saboorian-Jooybari, H., Dejam, M., & Chen, Z. (2016). Heavy oil polymer flooding from laboratory core floods to pilot tests and field applications: Half-century studies. Journal of Petroleum Science and Engineering, 142, 85–100.

    Google Scholar 

  • Shadizadeh, S. S., & Kharrat, R. (2015). Experimental investigation of Matricaria chamomilla extract effect on oil-water interfacial tension: Usable for chemical enhanced oil recovery. Petroleum Science and Technology, 33, 901–907.

    Google Scholar 

  • Shiran, B. S., & Skauge, A. (2013). Enhanced oil recovery (EOR) by combined low salinity water/polymer flooding. Energy & Fuels, 27(3), 1223–1235.

    Google Scholar 

  • Spildo, K., Sun, L., Djurhuus, K., & Skauge, A. (2014). A strategy for low cost, effective surfactant injection. Journal of Petroleum Science and Engineering, 117, 8–14.

    Google Scholar 

  • Strand, S., Hognesen, E. J., & Austad, T. (2006). Wettability alteration of carbonates—Effect of potential ions Ca2+ and SO42− and temperature. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 275, 1–10.

    Google Scholar 

  • Xie, Q., Saeedi, A., Pooryousefy, E., & Liu, T. (2016). Extended DLVO-based estimates of surface force in low salinity water flooding. Journal of Molecular Liquids, 221, 658–665.

    Google Scholar 

  • Yildiz, H. O., & Morrow, N. R. (1996). Effect of brine composition on recovery of Moutray crude oil by waterflooding. Journal of Petroleum Science and Engineering, 221, 658–665.

    Google Scholar 

  • Zaitoun, A., Makakou, P., Blin, N., Al-Maamari, R. S., Al-Hashmi, A. R., Abdel-Goad, M., et al. (2012). Shear stability of EOR polymers. SPE Journal. https://doi.org/10.2118/141113-PA.

    Article  Google Scholar 

  • Zhang, P., Tweheyo, M. T., & Austad, T. (2006). Wettability alteration and improved oil recovery in chalk: The effect of calcium in the presence of sulfate. Energy & Fuels, 20, 2056–2062.

    Google Scholar 

  • Zhang, P., Tweheyo, M. T., & Austad, T. (2007). Wettability alteration and improved oil recovery by spontaneous imbibition of seawater into chalk: Impact of the potential determining ions: Ca2+, Mg2+ and SO42−. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 310, 199–208.

    Google Scholar 

  • Zhou, H., Liang, Y., Huang, P., Liang, T., Wu, H., Lian, P., et al. (2018). Systematic investigation of ionic liquid-type Gemini surfactants and their abnormal salt effects on the interfacial tension of a water/model oil system. Journal of Molecular Liquids, 249, 33–39.

    Google Scholar 

  • Zhou, H., Luo, Q., Gong, Q. T., Liu, Z. Y., Zhang, L., & Zhao, S. (2017). Interfacial dilatational properties of di-substituted alkyl benzene sulfonates at kerosene/water and crude oil/water interface. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 520, 561–569.

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Department of Chemical Engineering, Marvdasht Branch, Islamic Azad University, Marvdasht, Iran

    Abdolreza Dabiri & Bizhan Honarvar

Authors
  1. Abdolreza Dabiri
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Bizhan Honarvar
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Bizhan Honarvar.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Dabiri, A., Honarvar, B. Synergic Impacts of Two Non-ionic Natural Surfactants and Low Salinity Water on Interfacial Tension Reduction, Wettability Alteration and Oil Recovery: Experimental Study on Oil Wet Carbonate Core Samples. Nat Resour Res 29, 4003–4016 (2020). https://doi.org/10.1007/s11053-020-09657-9

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11053-020-09657-9

Keywords

Search

Navigation