Abstract
The composition of MgB2-based materials (wires, bulks, and thin films) with high critical current densities, jc, prepared at different pressure (0.1 MPa–2 GPa)—temperature (600–1050 °C) conditions was analyzed by the X-ray and JAMP−9500F Auger spectrometer (after removing the oxidized layers at the sample surfaces by Ar ion etching performed directly in the vacuum chamber of a microscope). Similar regularly distributed inhomogeneities connected with Mg, B, and admixture O content variation on the nanolevel were observed in all types of the MgB2-based materials. The correlations between the character of the material inhomogeneities and the attained superconducting characteristics are discussed.
Similar content being viewed by others
References
Fluekiger, R. (ed.): Superconducting wires: basics and applications. World Scientific, New Jersey, London, Singapore, Beijing, Shanghai, Hong Kong, Taipei, Chennai, Tokyo (2016)
Tomsic, M., Rindfleisch, M., Yue, J., McFadden, K., Phillips, J., Sumption, M.D., Bhatia, M., Bohnenstiehl, S., Collings, E.W.: Overview of MgB2 superconductor applications. Int. J. Appl. Ceram. Technol. 4(3), 250–259 (2007)
Kovalev, L.K., Ilushin, K.V., Penkin, V.T., Kovalev, K.L., Poltavets, V.N., Koneyev, S.M.A., Modestov, K.A., Gawalek, W., Prikhna, T.A., Akimov, I.I.: An experimental investigation of a reluctance electrical drive with bulk superconducting elements in the rotor at temperature below 20 K. J. Phys. Conf. Ser. 43, 792–795 (2006)
Prikhna, T.A., Gawalek, W., Savchuk, Y.M., Sergienko, N.V., Moshchil, V.E., Sokolovsky, V., Vajda, J., Tkach, V.N., Karau, F., Weber, H., Eisterer, M., Joulain, A., Rabier, J., Chaud, X., Wendt, M., Dellith, J., Danilenko, N.I., Habisreuther, T., Dub, S.N., Meerovich, V., Litzkendorf, D., Nagorny, P.A., Kovalev, L.K., Schmidt, C., Melnikov, V.S., Shapovalov, A.P., Kozyrev, A.V., Sverdun, V.B., Kosa, J., Vlasenko, A.V.: Nanostructural superconducting materials for fault current limiters and cryogenic electrical machines. Acta Phys. Pol. A. 117(1), 7–14 (2010)
Mamalis, A.G., Hristoforou, E., Manolakos, D.E., Prikhna, T., Teodorakopoulos, I., Kouzilos, G.: Explosively consolidated powder-in-tube MgB2 superconductor aided by post-thermal treatment. IEEE Trans. Appl. Supercond. 19(1), 20–27 (2009)
Cunnane, D., Kawamura, J.H., Acharya, N., Wolak, M.A., Xi, X.X., Karasik, B.S.: Lownoise THz MgB2 Josephson mixer. Appl. Phys. Lett. 109, 112602 (2016)
Novoselov, E., Cherednichenko, S.: Low noise terahertz MgB2 hot-electron bolometer mixers with an 11 GHz bandwidth. Appl. Phys. Lett. 110, 032601 (2017)
Cunnane, D., Galan, E., Chen, K., Xi, X.: X: planar-type MgB2 SQUIDs utilizing a multilayer process. Appl. Phys. Lett. 103, 212603 (2013)
Galan, E., Melbourne, T., Davidson, B.A., Xi, X.X., Chen, K.: Multilayer MgB2 superconducting quantum interference filter magnetometers. Appl. Phys. Lett. 108, 172602 (2016)
Hong, S.-H., Lee, S.-G., Seong, W.K., Kang, W.N.: Fabrication of MgB2 nanobridge dc SQUIDs by focused ion beam. Physica C. 470, S1036–S1037 (2010)
Harada, Y., Kobayashi, K., Yoshizawa, M.: MgB2 SQUID for magnetocardiography. In: Grigorashvili, Y. (ed.) Superconductors - properties, technology, and applications. Tech (2012). https://doi.org/10.5772/38652
Lolli, L., Li, T., Portesi, C., Taralli, E., Acharya, N., Chen, K., Rajteri, M., Cox, D., Monticone, E., Gallop, J., Hao, L.: Micro-SQUIDs based on MgB2 nano-bridges for NEMS readout. Supercond. Sci. Technol. 29, 104008–104014 (2016)
Cunnane, D., Chen, K., Xi, X.X.: Superconducting MgB2 rapid single flux quantum toggle flip flop circuit. Appl. Phys. Lett. 102, 222601 (2013)
Goldacker, W., Schlachter, S.I., Reiner, J., Zimmer, S., Nyilas, A.: Mechanical properties of reinforced MgB2 wires. IEEE Trans. Appl. Supercond. 13(2), 3261–3264 (2003). https://doi.org/10.1109/TASC.2003.812218
Serquis, A., Civale, L., Hammon, D.L., Coulter, J.Y., Liao, X.Z., Zhu, Y.T., Peterson, D.E., Mueller, F.M.: Microstructure and high critical current of powder-intube MgB2. Appl. Phys. Lett. 82, 1754 (2003). https://doi.org/10.1063/1.1561572
Rostila, L., Demencik, E., Souc, J., Brisigotti, S., Kováč, P., Polak, M., Grasso, G., Lyly, M., Stenvall, A., Tumino, A., Kopera, Ľ.: Magnesium diboride wires with nonmagnetic matrices—AC loss measurements and numerical calculations. IEEE Trans. Appl. Supercond. 21(3), 3338–3341 (2011)
Gajda, D., Zaleski, A., Morawski, A., Cetner, T., Thong, C.J., Rindfleisch, M.A.: Point pinning centers in SiC doped MgB2 wires after HIP. Supercond. Sci. Technol. 29, 085010 (2016)
Kováč, P., Hušek, I., Melišek, T., Grivel, J.C., Pachla, W., Štrbík, V., Diduszko, R., Homeyer, J., Andersen, N.H.: The role of MgO content in ex situ MgB2 wires. Supercond. Sci. Technol. 17(10), L41 (2004)
Bhalothia, S., Kumar, N., Das, S., Bernhard, C., Varma, G.D.: Effect of graphene oxide doping on superconducting properties of bulk MgB2. Supercond. Sci. Technol. 26(9), 095008 (2013)
Prikhna, T.A., Gawalek, W., Savchuk, Y.M., Kozyrev, A.V., Wendt, M., Melnikov, V.S., Turkevich, V.Z., Sergienko, N.V., Moshchil, V.E., Dellith, J., Shmidt, C., Dub, S.N., Habisreuther, T., Litzkendorf, D., Nagorny, P.A., Sverdun, V.B., Weber, H.W., Eisterer, M., Noudem, J., Dittrich, U.: Formation of higher borides during high-pressure synthesis and sintering of magnesium diboride and their positive effect on pinning and critical current density. IEEE Trans. Appl. Supercond. 19(3), 2780–2783 (2009)
Prikhna, T.A., Eisterer, M., Weber, H.W., Gawalek, W., Kovylaev, V.V., Karpets, M.V., Basyuk, T.V., Moshchil, V.E.: Nanostructural inhomogeneities acting as pinning centers in bulk MgB2 with low and enhanced grain connectivity. Supercond. Sci. Technol. 27(4), 044013–044017 (2014)
Prikhna, T., Gawalek, W., Eisterer, M., Weber, H., Monastyrov, M., Sokolovsky, V., Noudem, J., Moshchil, V., Karpets, M., Kovylaev, V., Borimskiy, A., Tkach, V., Kozyrev, A., Kuznietsov, R., Dellith, J., Shmidt, C., Litzkendorf, D., Karau, F., Dittrich, U., Tomsic, M.: The effect of high-pressure synthesis on flux pinning in MgB2-based superconductors. Physica C. 479, 111–114 (2012)
Haigh, S., Kovac, P., Prikhna, T., Savchuk, Y.M., Kilburn, M., Salter, C., Hutchison, J., Grovenor, C.: Chemical interactions in Ti doped MgB2 superconducting bulk samples and wires. Supercond. Sci. Technol. 18(9), 1190–1196 (2005)
Prikhna, T.A., Gawalek, W., Surzhenko, A.B., Moshchil, V.E., Savchuk, Y.M., Melnikov, V.S., Nagorny, P.A., Habisreuther, T., Dub, S.N., Wendt, M., Litzkendorf, D., Dellith, J., Schmidt, C., Krabbes, G., Vlasenko, A.V.: High-pressure synthesis of MgB2 with and without tantalum addition. Physica C. 372–376(3), 1543–1545 (2002)
Hörhager, N., Eisterer, M., Weber, H.W., Prikhna, T., Tajima, T., Nesterenko, V.F.: Ti and Zr doped MgB2 bulk superconductors. J. Phys. Conf. Ser. 43, 500–504 (2006)
Prikhna, T.A., Eisterer, M., Rindfleisch, M., Romaka, V.V., Tomsic, M., Moshchil, V.E., Orlovskyi, M.V., Karpets, M.V., Sverdun, V.B., Ponomaryov, S.S., Shaternik, A.V., Kozyrev, A.V.: Correlations between superconducting characteristics and structure of MgB2-based materials, ab-initio modeling. IEEE Trans. Appl. Supercond. 29(3), 1–7 (2019), Art no. 6200207). https://doi.org/10.1109/TASC.2018.2874415
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Prikhna, T., Eisterer, M., Rindfleisch, M. et al. Manufacturing, Structure, Properties of MgB2-Based Materials. J Supercond Nov Magn 32, 3115–3120 (2019). https://doi.org/10.1007/s10948-019-5062-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10948-019-5062-z