Abstract
Coal mine waste rock is generated during coal extraction and is usually disposed of in non-engineered dumps. The dumps are extended vertically to 100–120 m height to reduce the spatial footprint. The waste mass generally consists of loose, cohesionless material associated with high heterogeneity, so the dumps are prone to slope failures. A typical dump configuration in Jharkhand, India (total height, H = 125 m; slope angle, θ = 3V:1H) is considered for evaluation in this study. A 2D limit equilibrium numerical analysis is performed to estimate the slope stability. A parametric study is conducted to understand the effect of bench height (H), bench width (W), and slope angle (θ) on the factor of safety. The heterogeneity of the material is analyzed using the probabilistic descriptors (mean, standard deviation, and coefficient of variation (CoV)). The influence of CoV on the shear strength parameters is studied at various intervals ranging from 10 to 80% and compared using Monte Carlo simulation and alternative point estimate methods. Further, the modified slope geometry and the benches are recommended as remediation methods to achieve the desired safety factor. The results provide valuable insights into understanding the influence of slope geometry and material heterogeneity during the stability analysis of coal mine dumps.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Data availability
All the data is reported within this article.
References
Babu GLS, Reddy KR, Srivastava A (2014) Influence of spatially variable geotechnical properties of MSW on stability of landfill slopes. J Hazard Toxic Radioact Waste 18:27–37. https://doi.org/10.1061/(asce)hz.2153-5515.0000177
Baecher GB, Christian JT (2005) Reliability and statistics in geotechnical engineering. Wiley, London
Behera PK, Sarkar K, Singh AK, Verma AK, Singh TN (2016) Dump slope stability analysis—a case study. J Geol Soc India 88:725–735. https://doi.org/10.1007/s12594-016-0540-4
CANMET (1977) Waste embankments. In pit slope manual. Chapter 9. CANMET Report 77-01. Minerals Research Program, Mining Research Laboratories, Ottawa
Chaturvedi A, Singh GSP (2022) Influence of interface and induced seismicity on overburden dump slope stability. Curr Sci 123:797–803. https://doi.org/10.18520/cs/v123/i6/797-803
Chaulya SK, Singh RS, Chakraborty K, Srivastava BK (2000) Quantification of stability improvement of a dump through biological reclamation. Geotech Geol Eng 18:193–207. https://doi.org/10.1023/A:1026576711324
Cheng Y, He D (2020) Slope reliability analysis considering variability of shear strength parameters. Geotech Geol Eng 38:4361–4368. https://doi.org/10.1007/s10706-020-01266-w
Cho YC, Song YS (2014) Deformation measurements and a stability analysis of the slope at a coal mine waste dump. Ecol Eng 68:189–199. https://doi.org/10.1016/j.ecoleng.2014.03.005
Dash AK (2019) Analysis of accidents due to slope failure in Indian opencast coal mines. Curr Sci 117:304–308. https://doi.org/10.18520/cs/v117/i2/304-308
Deliveris AV, Zevgolis IE, Koukouzas NC (2020) Probabilistic evaluation of local overstress on slope stability problems. Geotech Geol Eng 38:2957–2972. https://doi.org/10.1007/s10706-020-01199-4
DGMS (2017) Coal mines regulation (CMR). In: Gaz. India extraordinary. https://www.dgms.net/CoalMinesRegulation2017.pdf
Duncan JM (2000) Factors of safety and reliability in geotechnical engineering. J Geotech Geoenviron Eng 126(4):307–316. https://doi.org/10.1061/(asce)1090-0241(2000)126:4(307)
El-Ramly H, Morgenstern NR, Cruden DM (2002) Probabilistic slope stability analysis for practice. Can Geotech J 39(3):665–683. https://doi.org/10.1139/t02-034
Fattahi H, Zandy Ilghani N (2020) Slope stability analysis using Bayesian Markov chain Monte Carlo method. Geotech Geol Eng 38:2609–2618. https://doi.org/10.1007/s10706-019-01172-w
Fredlund DG (1981) The relationship between limit equilibrium slope stability methods. In: 10th ICSMFE, vol 3, pp 409–416
Geete SS, Singh KH, Verma AK, Singh TN, Dahale PP (2023) Stability analysis of overburden dump slope—a case study of Marki Mangli-I Coal Mine. In: Earth retaining structures and stability analysis: proceedings of the Indian geotechnical conference 2021, vol 6. Springer, pp 83–99
Griffiths DV, Fenton GA (2007) Probabilistic methods in geotechnical engineering, vol 491. Springer
Gupta T, Rai R, Jaiswal A, Shrivastva BK (2014) Sensitivity analysis of coal rib stability for internal mine dump in opencast mine by finite element modelling. Geotech Geol Eng 32:705–712. https://doi.org/10.1007/s10706-014-9741-z
Hawley M, Cunning J (2017) Guidelines for mine waste dump and stockpile design. CSIRO Publishing
Igwe O, Chukwu C (2019) Slope stability analysis of mine waste dumps at a mine site in Southeastern Nigeria. Bull Eng Geol Environ 78:2503–2517. https://doi.org/10.1007/s10064-018-1304-8
Kainthola A, Verma D, Gupte SS, Singh TN (2011) A coal mine dump stability analysis—a case study. Geomaterials 01:1–13. https://doi.org/10.4236/gm.2011.11001
Kasmer O, Ulusay R, Gokceoglu C (2006) Spoil pile instabilities with reference to a strip coal mine in Turkey: mechanisms and assessment of deformations. Environ Geol 49:570–585. https://doi.org/10.1007/s00254-005-0092-1
Keskin T, Makineci E (2009) Some soil properties on coal mine spoils reclaimed with black locust (Robinia pceudoacacia L.) and umbrella pine (Pinus pinea L.) in Agacli-Istanbul. Environ Monit Assess 159:407–414. https://doi.org/10.1007/s10661-008-0638-2
Krahn J (2003) The limits of limit equilibrium analyses. Can Geotech J 40(3):643–660. https://doi.org/10.1139/t03-024
Kulhawy FH (1992) On the evaluation of soil properties. ASCE Geotech 31:95–115
Kumar A, Das SK, Nainegali L, Reddy KR (2023) Phytostabilization of coalmine overburden waste rock dump slopes: current status, challenges, and perspectives. Bull Eng Geol Environ 82(4):130. https://doi.org/10.1007/s10064-023-03159-7
Layek S, Villuri VGK, Koner R, Chand K (2022) Rainfall and seismological dump slope stability analysis on active mine waste dump slope with UAV. Adv Civ Eng. https://doi.org/10.1155/2022/5858400
Masoudian MS, Zevgolis IE, Deliveris AV, Marshall AM, Heron CM, Koukouzas NC (2019) Stability and characterisation of spoil heaps in European surface lignite mines: a state-of-the-art review in light of new data. Environ Earth Sci 78:1–18. https://doi.org/10.1007/s12665-019-8506-7
McQuillan A, Canbulat I, Payne D, Oh J (2018) New risk assessment methodology for coal mine excavated slopes. Int J Min Sci Technol 28(4):583–592. https://doi.org/10.1016/j.ijmst.2018.07.001
MESA (1975) Engineering and design manual—coal refuse disposal facilities. Report prepared for US Dept. Int., Mining Enforcement and Safety Administration by E. D’Appolonia Consulting Engineers, Inc. USGPO, Washington. US Department of the Interior, Mining Enforcement and Safety Administration
Mohanty M, Sarkar R, Das SK (2022) Probabilistic assessment of effects of heterogeneity on the stability of coal mine overburden dump slopes through discrete element framework. Bull Eng Geol Environ 81(6):1–28. https://doi.org/10.1007/s10064-022-02720-0
Nayak PK, Dash AK, Dewangan P (2020) Design considerations for waste dumps in Indian opencast coal mines—a critical appraisal. In: Proceedings of 2nd international conference on opencast mining technology and sustainability, pp 19–31
Nguyen PMV, Wrana A, Rajwa S, Różański Z, Frączek R (2022) Slope stability numerical analysis and landslide prevention of coal mine waste dump under the impact of rainfall—a case study of Janina Mine, Poland. Energies 15(21):8311. https://doi.org/10.3390/en15218311
Orendorff B (2009) An experimental study of embankment dam breaching. Doctoral dissertation, University of Ottawa, Canada
Poulsen B, Khanal M, Rao AM, Adhikary D, Balusu R (2014) Mine overburden dump failure: a case study. Geotech Geol Eng 32(2):297–309. https://doi.org/10.1007/s10706-013-9714-7
Rai R, Kalita S, Gupta T, Shrivastva BK (2012) Sensitivity analysis of internal dragline dump stability: finite element analysis. Geotech Geol Eng 30:1397–1404. https://doi.org/10.1007/s10706-012-9541-2
Rajak TK, Yadu L, Chouksey SK (2020) Strength characteristics and stability analysis of ground granulated blast furnace slag (GGBFS) stabilized coal mine overburden-pond ash mix. Geotech Geol Eng 38:663–682. https://doi.org/10.1007/s10706-019-01056-z
Reddy SK (2023) Analysis of fault’s effect on the highwall stability of medapalli open pit coal mine. Geotech Geol Eng 41:2969–2986. https://doi.org/10.1007/s10706-023-02440-6
Sahu K, Mishra S (2018) Scientific study and advice on mitigation of silt generation and boulders and debris flow in the coal mine overburden. Int J Sci Res 7:898–903. https://doi.org/10.21275/ART20182242
Sia AHI, Dixon N (2012) Numerical modelling of landfill lining system–waste interaction: implications of parameter variability. Geosynth Int 19(5):393–408. https://doi.org/10.1680/gein.12.00025
Singh RS (2000) Revegetation of coal mine overburden dump (OBD) slopes by aromatic grasses. J Med Aromat Plant Sci 22(1):506–509
Steiakakis E, Kavouridis K, Monopolis D (2009) Large scale failure of the external waste dump at the “South Field” lignite mine, Northern Greece. Eng Geol 104:269–279. https://doi.org/10.1016/j.enggeo.2008.11.008
Supandi S (2021) The influence of water balance for slope stability on the high mine waste dump. Geotech Geol Eng 39:5253–5266. https://doi.org/10.1007/s10706-021-01829-5
Świtoniak MARCIN, Hulisz PIOTR, Różański SZYMON, Kałucka IZABELA (2013) Soils of the external dumping ground of the Bełchatów opencast lignite mine. Technog Soils Poland Toruń Polish Soc Soil Sci 26:255–274
Tripathi N, Singh RS, Chaulya SK (2012) Dump stability and soil fertility of a coal mine spoil in Indian dry tropical environment: a long-term study. Environ Manag 50(4):695–706. https://doi.org/10.1007/s00267-012-9908-4
Ulusay R, Arikan F, Yoleri MF, Çaǧlan D (1995) Engineering geological characterization of coal mine waste material and an evaluation in the context of back-analysis of spoil pile instabilities in a strip mine, SW Turkey. Eng Geol 40:77–101. https://doi.org/10.1016/0013-7952(95)00042-9
USBM (1982) (US Department of Interior, Bureau of Mines) Development of systematic waste disposal plans for metal and nonmetal mines. Minerals research contract report (Contract No. J0208033) prepared for US Department of Interior, Bureau of Mines
Varela C, Vazquez C, Gonzalez-Sangregorio MV, Leiros MC, Gil-Sotres F (1993) Chemical and physical properties of opencast lignite minesoils. Soil Sci 156:193–204
Wang YK, Sun SW, Liu L (2019) Mechanism, stability and remediation of a large scale external waste dump in China. Geotech Geol Eng 37:5147–5166. https://doi.org/10.1007/s10706-019-00969-z
Yang W, Xia X, Zhao G, Ji Y, Shen D (2011) Overburden failure and the prevention of water and sand inrush during coal mining under thin bedrock. Min Sci Technol 21:733–736. https://doi.org/10.1016/j.mstc.2011.04.002
Acknowledgements
We are grateful to the Indian Institute of Technology (Indian School of Mines) and the University of Illinois Chicago for supporting this research.
Funding
This research was funded by the Ministry of Education, Government of India, SPARC Project No. P1207 titled “Geoenvironmental and Geotechnical Issues of Coal Mine Overburden.”
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflicts of interest
The authors declare that they have no conflicts of interest.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Kumar, A., Das, S.K., Nainegali, L. et al. Probabilistic Slope Stability Analysis of Coal Mine Waste Rock Dump. Geotech Geol Eng 41, 4707–4724 (2023). https://doi.org/10.1007/s10706-023-02541-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10706-023-02541-2