Abstract
Effects of particle size and chain length on flotation of quaternary ammonium salts (QAS) onto kaolinite have been investigated by flotation tests. Dodecyltrimethylammonium chloride (DTAC) and cetyltrimethylammonium chloride (CTAC) were used as collectors for kaolinite in different particle size fractions (0.075 ~ 0.01 mm, 0.045 ~ 0.075 mm, 0 ~ 0.045 mm). The anomalous flotation behavior of kaolinite have been further explained based on crystal structure considerations by adsorption tests and molecular dynamics (MD) simulation. The results show that the flotation recovery of kaolinite in all different particle size fractions decreases with an increase in pH. As the concentration of collectors increases, the flotation recovery increases. The longer the carbon chain of QAS is, the higher the recoveries of coarse kaolinite (0.075 ~ 0.01 mm and 0.045 ~ 0.075 mm) are. But the flotation recovery of the finest kaolinite (0 ~ 0.045 mm) decreases with chain lengths of QAS collectors increasing, which is consistent with the flotation results of unscreened kaolinite (0 ~ 0.075 mm). It is explained by the froth stability related to the residual concentration of QAS collector in mineral pulp. In lower residual concentration, the froth stability becomes worse. Within the range of flotation collector concentration, it’s easy of CTAC to be completely adsorbed by kaolinite in the particle size fraction (0–0.045 mm), which led to lower flotation recovery. Moreover, it is interesting that the coarser particle size of kaolinite is, the higher flotation recovery is. The anomalous flotation behavior of kaolinite is rationalized based on crystal structure considerations. The results of MD simulations show that the (001) kaolinite surface has the strongest interaction with DTAC, compared with the (001) face, (010) and (110) edges. On the other hand, when particle size of kaolinite is altered, the number of basal planes and edge planes is changed. It is observed that the finer kaolinite particles size become, the greater relative surface area of edges and the more the number of edges are. It means that fine kaolinite particles have more edges to adsorb fewer cationic colletors than that of coarse kaolinite particles, which is responsible for the poorer floatability of fine kaolinite.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Chassagne C, Mietta F, Winterwerp J (2009) Electrokinetic study of kaolinite suspensions. J Colloid Interface Sci 336(1):352–359
Chipfunhu D, Zanin M, Grano S (2012) Flotation behaviour of fine particles with respect to contact angle. Chem Eng Res Des 90(1):26–32
Gupta V, Miller JD (2010) Surface force measurements at the basal planes of ordered kaolinite particles. J Colloid Interface Sci 344(2):362–371
Gupta V, Hampton MA, Stokes JR, Nguyen AV, Miller JD (2011) Particle interactions in kaolinite suspensions and corresponding aggregate structures. J Colloid Interface Sci 359(1):95–103
JIANG H, L-h XU, Y-h HU, D-z WANG, C-k LI, MENG W, X-j WANG (2011) Flotation and adsorption of quaternary ammonium cationic collectors on diaspore and kaolinite. Trans Nonferrous Metals Soc China 21(11):2528–2534
Liu C, Ansheng F, Zhenxu G, Xuefeng C, Yuehua H (2011) Flotation behavior of four dodecyl tertiary amines as collectors of diaspore and kaolinite. Min Sci Technol (China) 21(2):249–253
L-y X, Zhong H, G-y L, Huang Z, Chang Q (2009) Flotation separation of the aluminosilicates from diaspore by a Gemini cationic collector. Int J Miner Process 92(1–2):74–83
Ma X, Bruckard W, Holmes R (2009) Effect of collector, pH and ionic strength on the cationic flotation of kaolinite. Int J Miner Process 93(1):54–58
Miettinen T, Ralston J, Fornasiero D (2010) The limits of fine particle flotation. Miner Eng 23(5):420–437
Rodrigues OMS, Peres AEC, Martins AH, Pereira CA (2013) Kaolinite and hematite flotation separation using etheramine and ammonium quaternary salts. Miner Eng 40:12–15
Santana R, Farnese A, Fortes M, Ataide C, Barrozo M (2008) Influence of particle size and reagent dosage on the performance of apatite flotation. Sep Purif Technol 64(1):8–15
Schulz JC, Warr GG (2002) Adsorbed layer structure of cationic and anionic surfactants on mineral oxide surfaces. Langmuir 18(8):3191–3197
Šolc R, Gerzabek MH, Lischka H, Tunega D (2011) Wettability of kaolinite (001) surfaces — molecular dynamic study. Geoderma 169:47–54
X-h Y, Gupta V, Du H, X-m W, Miller JD (2012) Surface charge and wetting characteristics of layered silicate minerals. Adv Colloid Interf Sci 179–182:43–50
Xia L-y, Zhong H, Liu G-y, Huang Z-q, Chang Q-w, Li X-g (2009) Comparative studies on flotation of illite, pyrophyllite and kaolinite with Gemini and conventional cationic surfactants. Trans Nonferrous Metals Soc China 19(2):446–453
Xu L-h W, H-q DF-q, Wang L, Wang Z, J-h X (2013) Flotation and adsorption of mixed cationic/anionic collectors on muscovite mica. Miner Eng 41:41–45
Y-h H, Liu X-w XZ (2003) Role of crystal structure in flotation separation of diaspore from kaolinite, pyrophyllite and illite. Miner Eng 16(3):219–227
Y-h H, Jiang H, Wang D (2003) Electrokinetic behavior and flotation of kaolinite in CTAB solution. Miner Eng 16(11):1221–1223
Y-h H, Wei S, Hao J, Miller JD, Fa K (2005) The anomalous behavior of kaolinite flotation with dodecyl amine collector as explained from crystal structure considerations. Int J Miner Process 76(3):163–172
Zhao S, Wang D, Hu Y, Bao S, Xu J (2003) Flotation of aluminosilicates using < i > N</i > −(2-aminoethyl)-1-naphthaleneacetamide. Miner Eng 16(10):1031–1033
Zhao H, Bhattacharjee S, Chow R, Wallace D, Masliyah JH, Xu Z (2008) Probing surface charge potentials of clay basal planes and edges by direct force measurements. Langmuir 24(22):12899–12910
Zhong H, G-y L, Xia L-y LY, Hu Y, Zhao S, Yu X (2008) Flotation separation of diaspore from kaolinite, pyrophyllite and illite using three cationic collectors. Miner Eng 21(12–14):1055–1061
Acknowledgments
The authors would like to thank the National Natural Science Foundation of China (NSFC), Grant No. 51304162 and Opening Project of Key Laboratory of Solid Waste Treatment and Resource Recycle, Ministry of Education of China (No. 12zxgk02 and No.13zxgk01) for the financial support.
Author information
Authors and Affiliations
Corresponding author
Additional information
Editorial handling: L. Anhuai
Rights and permissions
About this article
Cite this article
Longhua, X., Yuehua, H., Faqin, D. et al. Effects of particle size and chain length on flotation of quaternary ammonium salts onto kaolinite. Miner Petrol 109, 309–316 (2015). https://doi.org/10.1007/s00710-014-0332-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00710-014-0332-8