Abstract
In this work, the influence of substrate properties on the polarization of highly c-axis oriented aluminium nitride (AlN) thin films and as a consequence, on the piezoelectric properties and the wet-chemical etching behaviour is investigated. Therefore, 620 nm thin AlN layers are simultaneously sputter-deposited under nominal unheated substrate conditions on silicon (Si) substrates or on those covered with a sputter-deposited titanium (Ti) film. After wet-chemically etching in a phosphorous acid based solution at 80 °C different residues of AlN remain. Wet-chemical etching of AlN films deposited on Ti results in a high film porosity. In contrast, AlN layers on Si are either hardly attacked or the complete thin film is removed except some remaining conical shaped residues. Furthermore, we demonstrate a change in the measured electro-mechanical properties with changing maximum deposition temperature caused by a self-heating effect of the substrate during the AlN deposition process. The change in piezoelectric properties and the differing etching behaviour is caused by a change in polarity within the AlN layer. These domains are visualized by piezoresponse force microscopy measurements, and are in good agreement with the observed etching results. For layers with mixed polarization, the absolute values of the piezoelectric constant d 33 are reduced due to the counteraction of piezoelectric domains with opposite polarization.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Ababneh A, Kreher H, Schmid U (2008) Etching behaviour of sputter-deposited aluminium nitride thin films in H3PO4 and KOH solutions. Microsyst Technol 14:567–573. doi:10.1007/s00542-007-0450-x
Ababneh A et al (2012) c-axis orientation and piezoelectric coefficients of AlN thin films sputter-deposited on titanium bottom electrodes. Appl Surf Sci 259:59–65. doi:10.1016/j.apsusc.2012.06.086
Abdallah B, Al-Khawaja S, Alkhawwam A (2011) Electrical characteristics of insulating aluminum nitride MIS nanostructures. Appl Surf Sci 258:419–424. doi:10.1016/j.apsusc.2011.08.119
Akiyama M, Kamohara T, Ueno N, Sakamoto M, Kano K, Teshigahara A, Kawahara N (2007) Polarity inversion in aluminum nitride thin films under high sputtering power. Appl Phys Lett 90:151910–151913. doi:10.1063/1.2721865
Akiyama M, Kamohara T, Kano K, Teshigahara A, Kawahara N (2008) Influence of oxygen concentration in sputtering gas on piezoelectric response of aluminum nitride thin films. Appl Phys Lett 93:021903. doi:10.1063/1.2957654
Ambacher O (1998) Growth and applications of Group III nitrides. J Phys D Appl Phys 31:2653–2710. doi:10.1088/0022-3727/31/20/001
Artieda A, Sandu C, Muralt P (2010) Highly piezoelectric AlN thin films grown on amorphous, insulating substrates. J Vac Sci Technol, A 28:390–393. doi:10.1116/1.3359588
Brubaker MD, Levin I, Davydov AV, Rourke DM, Sanford NA, Bright VM, Bertness KA (2011) Effect of AlN buffer layer properties on the morphology and polarity of GaN nanowires grown by molecular beam epitaxy. J Appl Phys 110:053506. doi:10.1063/1.3633522
Chen D, Xu D, Wang J, Zhang Y (2008) Investigation of chemical etching of AlN film with different textures by x-ray photoelectron spectroscopy. J Phys D Appl Phys 41:235303. doi:10.1088/0022-3727/41/23/235303
Chen D, Wang J, Xu D, Zhang Y (2009) The influence of the AlN film texture on the wet chemical etching. Microelectron J 40:15–19. doi:10.1016/j.mejo.2008.09.001
Cherng JS, Chen TY (2011) Influence of sputtering atmosphere on polarity distribution of piezoelectric aluminum nitride thin films. Curr Appl Phys 11:S371–S375. doi:10.1016/j.cap.2011.03.043
Engelmark F, Iriarte GF, Katardjiev IV, Ottosson M, Muralt P, Berg S (2001) Structural and electroacoustic studies of AlN thin films during low temperature radio frequency sputter deposition. J Vac Sci Technol, A 19:2664. doi:10.1116/1.1399320
Guo W et al (2015) KOH based selective wet chemical etching of AlN, AlxGa1 − xN, and GaN crystals: a way towards substrate removal in deep ultraviolet-light emitting diode. Appl Phys Lett 106:082110. doi:10.1063/1.4913705
Harumoto T et al (2013) Controlled polarity of sputter-deposited aluminum nitride on metals observed by aberration corrected scanning transmission electron microscopy. J Appl Phys 113:084306. doi:10.1063/1.4792942
Haynes WM, Lide DR (2010) CRC Handbook of Chemistry and Physics, 91st Edition. 91 edn. CRC Press
Iriarte GF, Rodríguez JG, Calle F (2010) Synthesis of c-axis oriented AlN thin films on different substrates: a review. Mater Res Bull 45:1039–1045. doi:10.1016/j.materresbull.2010.05.035
Kamohara T et al (2006) Influence of sputtering pressure on polarity distribution of aluminum nitride thin films. Appl Phys Lett 89:243503–243507. doi:10.1063/1.2405849
Kirste R et al (2013) Polarity control and growth of lateral polarity structures in AlN. Appl Phys Lett 102:181913. doi:10.1063/1.4804575
Kucera M et al (2014) Design-dependent performance of self-actuated and self-sensing piezoelectric-AlN cantilevers in liquid media oscillating in the fundamental in-plane bending mode. Sens Actuators B: Chem 200:235–244. doi:10.1016/j.snb.2014.04.048
Manzaneque T, Ruiz-Díez V, Hernando-García J, Wistrela E, Kucera M, Schmid U, Sánchez-Rojas JL (2014) Piezoelectric MEMS resonator-based oscillator for density and viscosity sensing. Sens Actuators, A 220:305–315. doi:10.1016/j.sna.2014.10.002
Marauska S et al (2012) Sputtered thin film piezoelectric aluminum nitride as a functional MEMS material. Microsyst Technol 18:787–795. doi:10.1007/s00542-012-1493-1
Milyutin E et al (2010) Sputtering of (001)AlN thin films: control of polarity by a seed layer. J Vac Sci Technol, B 28:L61–L63. doi:10.1116/1.3501117
Hu J, Hao Z, Niu L, E Y, Wang L, Luo Y (2013) Atomically smooth and homogeneously N-polar AlN film grown on silicon by alumination of Si3N4 Applied Physics Letters 102:141913 doi:http://dx.doi.org/10.1063/1.4801765
Pearton SJ, Abernathy CR, Ren F, Lothian JR, Wisk PW, Katz A (1993) Dry and wet etching characteristics of InN. J Vacuum Sci Technol A 11:1772–1775. doi:10.1116/1.578423
Pfusterschmied G et al. Piezoelectric response optimization of multi roof tile-shaped modes in MEMS resonators by variation of the support boundary conditions. In: Solid-State Sensors, Actuators and Microsystems (TRANSDUCERS), 2015 Transducers–2015 18th International Conference on, 21-25 June 2015 2015. pp 969-972. doi:10.1109/TRANSDUCERS.2015.7181086
Ruffner JA, Clem PG, Tuttle BA, Dimos D, Gonzales DM (1999) Effect of substrate composition on the piezoelectric response of reactively sputtered AlN thin films. Thin Solid Films 354:256–261. doi:10.1016/S0040-6090(99)00521-0
Schneider M, Bittner A, Patocka F, Stöger-Pollach M, Halwax E, Schmid U (2012) Impact of the surface-near silicon substrate properties on the microstructure of sputter-deposited AlN thin films. Appl Phys Lett 101:221602. doi:10.1063/1.4768951
Schneider M, Bittner A, Schmid U (2015) Improved Piezoelectric Constants of Sputtered Aluminium Nitride Thin Films by Pre-conditioning of the Silicon Surface accepted at Journal of Physics D: Applied Physics
Stewart M, Cain MG (2014) Direct Piezoelectric Measurement: The Berlincourt Method. In: Cain MG (ed) Characterisation of Ferroelectric Bulk Materials and Thin Films. Springer Series in Measurement Science and Technology, vol 2. Springer Netherlands, pp 37-64. doi:10.1007/978-1-4020-9311-1_3
Strite S, Morkoç H (1992) GaN, AlN, and InN: A review Journal of Vacuum Science & Technology B 10:1237-1266 doi:http://dx.doi.org/10.1116/1.585897
Tadigadapa S, Mateti K (2009) Piezoelectric MEMS sensors: state-of-the-art and perspectives. Meas Sci Technol 20:092001. doi:10.1088/0957-0233/20/9/092001
Tanner SM, Felmetsger VV (2010) Microstructure and chemical wet etching characteristics of AlN films deposited by ac reactive magnetron sputtering. J Vac Sci Technol, A 28:69. doi:10.1116/1.3268620
Tonisch K, Cimalla V, Foerster C, Romanus H, Ambacher O, Dontsov D (2006) Piezoelectric properties of polycrystalline AlN thin films for MEMS application. Sens Actuators, A 132:658–663. doi:10.1016/j.sna.2006.03.001
Yim WM, Paff RJ (1974) Thermal expansion of AlN, sapphire, and silicon. J Appl Phys 45:1456–1457. doi:10.1063/1.1663432
Zhuang D, Edgar JH (2005) Wet etching of GaN, AlN, and SiC: a review. Mater Sci Eng R 48:1–46. doi:10.1016/j.mser.2004.11.002
Zhuang D, Edgar JH, Strojek B, Chaudhuri J, Rek Z (2004) Defect-selective etching of bulk AlN single crystals in molten KOH/NaOH eutectic alloy. J Cryst Growth 262:89–94. doi:10.1016/j.jcrysgro.2003.10.051
Acknowledgments
We gratefully acknowledge the financial support from the Austrian Science Fund (FWF), No. P 25212-N30. In addition, we thank Dr. Klaudia Hradil from the X-ray Center (XRC) of TU Wien for her support with the measurements.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Wistrela, E., Schneider, M., Bittner, A. et al. Impact of the substrate dependent polarity distribution in c-axis oriented AlN thin films on the etching behaviour and the piezoelectric properties. Microsyst Technol 22, 1691–1700 (2016). https://doi.org/10.1007/s00542-015-2799-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00542-015-2799-6