Skip to main content
SpringerLink
Log in

Effect of drip irrigation frequency on emitter clogging using reclaimed water

  • Original Paper
  • Published:
Irrigation Science Aims and scope Submit manuscript

Abstract

Drip irrigation frequency has important impacts on crop growth, soil moisture, nutrient, salinity and substances’ accumulation in the irrigation system as well as drip irrigation emitter clogging. However, previous studies on reasonable drip irrigation frequency merely focused on crop yield and quality, soil water and salinity transporting, neglecting its impact on the high-efficiency operation of the drip irrigation system. Studies on reasonable reclaimed water drip irrigation frequency were more insufficient. Therefore, the drip irrigation emitter clogging experiment using reclaimed water was accomplished in the wastewater treatment plant, and then, the effects of different irrigation frequencies, including once/2 days (IF1/2), once/4 days (IF1/4), once/8 days (IF1/8) and once/16 days (IF1/16), on dynamic emitters’ outflows and biofilms’ growth were studied. The results showed that emitter clogging degrees increased with shorter drip irrigation interval, mainly because that discharge ratio variation (Dra) and Christiansen uniformity coefficient (CU) both decreased. After the system accumulatively run 540 h, the smallest Dra and CU were observed in high-frequency drip irrigation treatment (IF1/2) as 30.98 and 31.97 %, respectively, along with the highest proportion of more serious clogged emitters, due to the effects of drip irrigation frequencies on the comprehensive biofilm growth and detachment inside emitters. The dry weights (DWs), extracellular polymeric substances (EPS) and phospholipid fatty acids (PLFAs) of biofilms all increased with shorter irrigation interval, and showed logarithmic relationships (R 2 > 0.92). The max DW, EPS and PLFAs of biofilms in IF1/2 reached 0.124 g, 1459.80 and 96.07 μg, respectively, after 540 h. Combined these with previous studying results, irrigated between once/8 days and once/4 days was believed to be appropriate for planting maize in North China Plain using reclaimed water drip irrigation.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6

Similar content being viewed by others

References

  • Asano T, Burton FL, Leverenz HL et al (2007) Water reuse: issues, technologies and applications. McGraw Hill Inc, New York

    Google Scholar 

  • Bucks DA, Erie LJ, French OF (1974) Quantity and frequency of trickle and furrow irrigation for efficient cabbage production. Agron J 66:53–57

    Article  Google Scholar 

  • Chinalia FA, Killham KS (2006) 2, 4-Dichlorophenoxyacetic acid (2, 4-D) biodegradation in river sediments of Northeast-Scotland and its effect on the microbial communities (PLFA and DGGE). Chemosphere 64:1675–1683

    Article  CAS  PubMed  Google Scholar 

  • Dalvi VB, Tiwari KN, Pawade MN et al (1999) Response surface analysis of tomato production under microirrigation. Agric Water Manag 41:11–19

    Article  Google Scholar 

  • Freeman BM, Blackwell J, Garzoli KV (1976) Irrigation frequency and total water application with trickle and furrow systems. Agric Water Manag 1:21–31

    Article  Google Scholar 

  • Frostegard A, Tunlid A, Baath E (1993) Phospholipid fatty acid composition, biomass, and activity of microbial communities from two soil types experimentally exposed to different heavy metals. Appl Environ Microbiol 59:3605–3617

    PubMed Central  CAS  PubMed  Google Scholar 

  • Goldberg SD, Shmueli M (1970) Drip irrigation-a method used under arid and desert conditions of high water and soil salinity. Trans ASAE 13:38–41

    Article  Google Scholar 

  • Henggeler JC (1988) Irrigation frequency with drip irrigation and its effect on yield. In: Brown JM (ed) Proceedings of the Beltwide Cotton production research conference on 3–8 Jan. 1988, New Orleans, LA. National Cotton Council of America, Memphis, TN, pp 79–80

  • Hong L, Herbert HP (2002) Extraction of extracurricular polymeric substances (EPS) of sludges. J Biotechnol 95(3):249–256

    Article  Google Scholar 

  • Kittock DL (1979) Pima and upland cotton response to irrigation management. Agron J 71(4):617–619

    Article  Google Scholar 

  • Li GB, Li YK, Xu TW, Liu YZ, Jin H, Yang PL, Yan DZ, Ren SM (2012) Effects of average velocity on the growth and surface topography of biofilms attached on the reclaimed wastewater drip irrigation system laterals. Irrig Sci 30:103–113

    Article  Google Scholar 

  • Li YK, Zhou B, Liu YZ, Jiang YG, Pei YT, Shi Z (2013) Preliminary surface topographical characteristics of biofilms attached on drip irrigation emitters using reclaimed water. Irrig Sci 30:103–113

    Article  CAS  Google Scholar 

  • Liu HJ, Huang GH (2009) Laboratory experiment on drip emitter clogging with fresh water and treated sewage effluent. Agric Water Manag 96:745–756

    Article  Google Scholar 

  • Liu MX, Yang JS, Li XM et al (2011) Effects of irrigation amount and frequency on soil water distribution and water use efficiency in a cotton field under mulched drip irrigation. Yingyong Shengtai Xuebao 22(12):3203–3210

    PubMed  Google Scholar 

  • Lowry OH, Rosebrough NJ, Farr AL, Randall RJ (1951) Protein measurement with the Folin phenol reagent. J Biolol Chem 193(1):265–275

    CAS  Google Scholar 

  • Nocker A, Lepo JE, Martin LL, Snyder RA (2007) Response of estuarine biofilm microbial community development to changes in dissolved oxygen and nutrient concentrations. Microb Ecol 54(3):532–542

    Article  PubMed  Google Scholar 

  • O’Leary WM, Wilkinson SG (1988) Gram-positive bacteria. In: Ratledge C, Wilkinson SG (eds) Microbial lipids. Academic Press, London

    Google Scholar 

  • Pei YT, Li YK, Liu YZ, Zhou B, Shi Z, Jiang YG (2014) Eight emitters clogging characteristics and its suitability evaluation under on-site reclaimed water drip irrigation. Irrig Sci 32(2):141–157

    Article  Google Scholar 

  • Peng ZG (2006) Study on growth mechanisms, environmental effects and water consumption of lawn irrigated with reclaimed water. China Agricultural University, Beijing

    Google Scholar 

  • Pennanen T, Liski J, Baath E et al (1999) Structure of the microbial communities in coniferous forest soils in relation to site fertility and stand development stage. Microb Ecol 38:168–179

    Article  PubMed  Google Scholar 

  • Sui J, Gong SH, Wang JD et al (2008) Effects of drip irrigation frequency on the distribution of soil water, soil temperature and maize grown in North China. J Soil Water Conserv 22(4):148–152

    Google Scholar 

  • Wang FX, Kang YH, Liu SP (2006) Effects of drip irrigation frequency on soil wetting pattern and potato growth in North China Plain. Agric Water Manag 79:248–264

    Article  Google Scholar 

  • Wang JD, Gong SH, Sui J et al (2008) Effects of drip irrigation frequency on the farmland soil water-heat distribution and spring maize growth in North China. Trans CSAE 2:39–45

    Google Scholar 

  • Wu XB, Wu WY, Liu HL et al (2008) Experimental study on anti-clogging performance of emitters for reclaimed wastewater irrigation. Trans CSAE 24(5):61–64

    Google Scholar 

  • Yu M, Yang JS, Liu MX et al (2011) Effects of mulched drip irrigation frequency on soil water-salt transport and cotton yield. Agric Res Arid Areas 3:18–23

    Google Scholar 

  • Zhou B, Li YK, Pei YT et al (2013) Quantitative relationship between biofilms components and emitter clogging under reclaimed water drip irrigation. Irrig Sci 31(6):1251–1263

    Article  Google Scholar 

Download references

Acknowledgments

We are grateful for financial support from the National Natural Science Fund of China (Nos. 51321001, 51339007, 51179190), Special Public Welfare Project of Chinese Ministry of Water Resources (201401078) and New Century Excellent Researcher Award Program of Chinese Ministry of Education (NETC-10-0780).

Author information

Authors and Affiliations

  1. College of Water Resources and Civil Engineering, China Agricultural University, Beijing, 100083, China

    Bo Zhou, Yunkai Li, Yaoze Liu, Feipeng Xu & Yiting Pei

  2. Center for Systems Integration and Sustainability, Michigan State University, East Lansing, MI, 48823-5243, USA

    Yunkai Li

  3. College of Water and Architectural Engineering, Shihezi University, Shihezi, 832000, Xinjiang, China

    Zhenhua Wang

Authors
  1. Bo Zhou
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Yunkai Li
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Yaoze Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Feipeng Xu
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Yiting Pei
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Zhenhua Wang
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding authors

Correspondence to Yunkai Li or Zhenhua Wang.

Additional information

Communicated by K. Stone.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Zhou, B., Li, Y., Liu, Y. et al. Effect of drip irrigation frequency on emitter clogging using reclaimed water. Irrig Sci 33, 221–234 (2015). https://doi.org/10.1007/s00271-015-0461-9

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00271-015-0461-9

Keywords

Search

Navigation