Skip to main content
SpringerLink
Log in

Performance of wax-impregnated timber out of ground contact: results from long-term field testing

  • Original
  • Published:
Wood Science and Technology Aims and scope Submit manuscript

Abstract

While, for instance, oils and waxes were found to be promising for protecting wood under laboratory test conditions, long-term outdoor experience with these materials is limited. This study aimed at investigating the performance of wax-treated wood exposed aboveground in double-layer and lap-joint configurations. Wetting resistance, susceptibility to checking and durability were investigated over several years. All wax-treated wood performed better in the lap-joint exposure than in double layer, which was characterized by severe moisture trapping. However, durability and moisture performance were considerably better compared to untreated controls, but diminished with increasing exposure time. Already after 1 year of exposure, the number of cracks on lap-joint specimens was nearly identic between treated and untreated samples. Due to the wax migration observed during exposure, the formation of checks, accumulation of water in treated samples and partial infection, it can be concluded that the chosen synthetic wax types are not recommendable for practical applications. On the other hand, the principle of wood protection through moisture protection became evident in the aboveground field tests: As long as moisture exclusion was assured, the development of decay was inhibited.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8

Similar content being viewed by others

References

  • Amthor J (1972) Paraffindispersionen zur Hydrophobierung von Spanplatten [Paraffin dispersions fort he waterproofing of particle board]. Holz Roh Werkst 30:422–429

  • Augusta U, Rapp AO, Welzbacher CR, Brischke C (2005) Dauerhaftigkeit heimischer Holzarten in verschiedenen Gebrauchsklassen ohne und mit Imprägnierung durch Öle [Durability of domestic wood species in different use classes with and without oil impregantion]. In: Holzhaus-Bauweisen im Vergleich und Neues vom Holzschutz, Beiträge zum 5. Holzbauforum Leipzig. Huss-Medien, Berlin

  • Banks WB (1973) Water uptake by Scots pine sapwood and its restriction by the use of water repellents. Wood Sci Technol 7:271–284

    Article  Google Scholar 

  • Borgin K (1968) The protection of wood against dimensional instability. For S Afr 9:81–94

    Google Scholar 

  • Brandt K, Brischke C, Melcher E, Niemeyer A, Rapp AO (2011) Untersuchung der hydrophobierenden Schutzwirkung von synthetischen Wachsen und Ölen zur Imprägnierung von Holz [Investigation of the effectiveness of impregnating wood with synthetic oils and waxes]. Final report. Institute of Wood Technology and Wood Biology, Hamburg

  • Brischke C, Rapp AO (2008) Dose–response relationships between wood moisture content, wood temperature and fungal decay determined for 23 European field test sites. Wood Sci Technol 42:507–518

    Article  CAS  Google Scholar 

  • Brischke C, Welzbacher CR, Rapp AO, Bollmus S (2006) Biozidfreier Holzschutz mit Ölen und Wachsen—Erfahrungen aus sieben Jahren Freilandversuchen zum Feuchteschutz durch Hydrophobierung [Non-biocidal wood protection with oils and waxes—Experience from 7 years field testing]. Holz-Zent.bl 132(7):206–208

  • CEN/TS 12037 (2003) Wood preservatives. Field test method for determining the relative protective effectiveness of a wood preservative exposed out of ground contact. Horizontal lap-joint method

  • EC European Commision (2012) Biocidal products regulation (BPR) 528/2012/EEC. European Commission, Strasbourg

    Google Scholar 

  • EN 252 (1989) Field test method for determining the relative protective effectiveness of wood preservatives in ground contact

  • EN 350-1 (1994) Durability of wood and wood based products—natural durability of solid wood—part 1: guide to the principles of testing and classification of the natural durability of wood

  • EN 335 (2013) Durability of wood and wood-based products—use classes: definitions, application to solid wood and wood-based products

  • Evans PD, Wingate-Hill R, Cunningham RB (2009) Wax and oil emulsion additives: how effective are they at improving the performance of preservative-treated wood? For Prod J 59(1/2):66–70

    CAS  Google Scholar 

  • Flæte PO, Høibø OA, Fjærtoft F, Nilsen TN (2000) Crack formation in unfinished siding of aspen (Populus tremula L.) and Norway spruce (Picea abies (L.) Karst.) during accelerated weathering. Holz Roh Werkst 58:135–139

    Article  Google Scholar 

  • Hill CA (2007) Wood modification: chemical, thermal and other processes. Wiley, New York

  • Hill CA (2011) Wood modification: an update. BioResources 6:918–919

    CAS  Google Scholar 

  • Lesar B, Humar M (2011) Use of wax emulsions for improvement of wood durability and sorption properties. Eur J Wood Prod 69:231–238

    Article  CAS  Google Scholar 

  • Lesar B, Pavlič M, Petrič M, Škapin S, Humar M (2011) Wax treatment of wood slows photodegradation. Polym Degrad Stab 96:1271–1278

    Article  CAS  Google Scholar 

  • Matsuoka Y, Ohmura W, Fujiwara S, Kanagawa Y (2002) Durability of Sugi (Cryptomeria japonica D. Don) wood treated in high temperature liquid paraffin. Document No. IRG/WP 02-40221. International Research Group on Wood Preservation, Stockholm, Sweden

  • Müller H (1962) Erfahrungen mit Paraffin-Emulsionen als Quellschutzmittel in der Spanplattenindustrie [Experience with paraffin-wax emulsions as anti-swelling agents in chipboard industry]. Holz Roh Werkst 20:434–437

    Article  Google Scholar 

  • Palanti S, Feci E, Torniai AM (2011) Comparison based on field tests of three low-environmental-impact wood treatments. Int Biodeterior Biodegrad 65:547–552

    Article  CAS  Google Scholar 

  • Rapp AO, Augusta U (2004) The full guideline for the “double layer test method”—a field test method for determining the durability of wood out of ground. Document No. IRG/WP 04-20290. International Research Group on Wood Preservation, Stockholm, Sweden

  • Rapp AO, Sailer M, Peek R-D (2000) Innovative Holzvergütung zur Erhöhung der Dauerhaftigkeit [Innovative processes to improve the durability of wood]. 10. Hamburger Forst- und Holztagung, 23/24 May 2000:27–34

  • Rapp AO, Beringhausen C, Bollmus S, Brischke C, Frick T, Haas T, Sailer M, Welzbacher CR (2005) Hydrophobierung von Holz—Erfahrungen nach 7 Jahren Freilandtest [Hydrophobation of wood—experience after 7 years field testing]. In: 24th Holzschutztagung der DGFH, Leipzig, Germany, pp 157–170

  • Ringman R, Pilgård A, Brischke C, Richter K (2014) Mode of action of brown rot decay resistance in modified wood: a review. Holzforschung 68:239–246

  • Rypstra T, Vermaas HF, Sanderson RD (1979) Dimensional stabilisation of wood: factors influencing it and the principles of treatment. S Afr J 108:22–28

    Google Scholar 

  • Sailer M (2000) Anwendungen von Pflanzenölimprägnierungen zum Schutz von Holz im Außenbereich [Impregnation of wood with vegetable oils for protection in outdoor applications]. Dissertation, University Hamburg

  • Sandberg D, Söderström O (2006) Crack formation due to weathering of radial and tangential sections of pine and spruce. Wood Mat Sci Eng 1:12–20

    Article  Google Scholar 

  • Scholz G, Militz H (2011) Materialeigenschaften wachsimprägnierten Holzes [Material properties of wax-impregnated wood]. Holztechnologie 52(6):29–33

    Google Scholar 

  • Scholz G, Van den Bulcke J, Boone M, Zauer M, Bäucker E, Van Acker J, Militz H (2010a) Investigation on wax-impregnated wood. Part 1: microscopic observations and 2D x-ray imaging of distinct wax types. Holzforschung 64:581–585

    CAS  Google Scholar 

  • Scholz G, Krause A, Militz H (2010b) Beeinflussung der Holzfestigkeit durch Wachstränkung [Impacts of wax impregnation on the strength of wood]. Holztechnologie 51(3):22–27

    Google Scholar 

  • Scholz G, Krause A, Militz H (2010c) Exploratory study on the impregnation of Scots pine sapwood (Pinus sylvestris L.) and European beech (Fagus sylvatica L.) with different hot melting waxes. Wood Sci Technol 44:379–388

    Article  CAS  Google Scholar 

  • Scholz G, Adamopoulos S, Militz H (2011) Migration of blue stain fungi within wax impregnated wood. IAWA J 32(1):88–96

    Article  Google Scholar 

  • Stamm AJ, Hansen LA (1935) Minimizing wood shrinkage and swelling—replacing water in wood with nonvolatile materials. Ind Eng Chem 27:1480–1484

    Article  CAS  Google Scholar 

  • Unger A, Schniewind AP, Unger W (2001) Conservation of wood artifacts: a handbook. Springer, Belrin

  • Voulgaridis E (1986) Effect of water temperature and melting point of wax on water repellency in treated wood. Holzforsch Holzverwert 38:141–144

    CAS  Google Scholar 

  • Wiertelak J, Czarnecki J (1935) Paraffin-impregnated wood—resistance to water and sulfuric acid solutions. Ind Eng Chem 27:543–547

    Article  CAS  Google Scholar 

  • Zahora A (2000) Long-term performance of a “wax” type additive for use with water-borne pressure preservative treatments. Document No. IRG/WP 00-40159. International Research Group on Wood Preservation, Stockholm, Sweden

Download references

Acknowledgments

The authors gratefully acknowledge support in the field trials from Karin Brandt and Andrea Niemeyer. Dr. Tobias Huckfeldt is acknowledged for characterizing fungal species from the field samples.

Author information

Authors and Affiliations

  1. Institute of Vocational Sciences in the Building Trade (IBW), Leibniz University Hannover, Herrenhäuser Str. 8, 30419, Hannover, Germany

    Christian Brischke

  2. Thünen Institute of Wood Research, Leuschnerstr. 91d, 21031, Hamburg, Germany

    Eckhard Melcher

Authors
  1. Christian Brischke
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Eckhard Melcher
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Christian Brischke.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Brischke, C., Melcher, E. Performance of wax-impregnated timber out of ground contact: results from long-term field testing. Wood Sci Technol 49, 189–204 (2015). https://doi.org/10.1007/s00226-014-0692-6

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00226-014-0692-6

Keywords

Search

Navigation