Abstract
Biodiesel was used as an effective alternative to the fossil fuel, as it was non-toxic, renewable and biodegradable resource. Engine parameters like compression ratio, injection timing and injection pressure play a key role in the combustion of biodiesel. This research work presents the effect of compression ratio on the combustion, performance and emission characteristics of 80% diesel blended with 20% orange oil methyl ester (20OME) in diesel engine. Experiments were conducted on a single-cylinder direct injection (DI) diesel engine with compression ratios of 17:1 and 18:1. Diesel exhibited higher Brake Thermal Efficiency (BTE) than 20OME at both compression ratios. At all loads, an increased Brake Specific Energy Consumption (BSEC) was observed for 20OME in both compression ratios. Due to the presence of more oxygen content in the prepared biodiesel sample, 20OME showed higher heat release rate than diesel at compression ratio 18. Consequently, 20OME showed higher rate of pressure than diesel at CR 18. 20OME showed higher Exhaust Gas Temperature (EGT) than diesel at all loads. At CR 18, both diesel and 20OME showed similar trend of HC and CO emissions whereas in CR 17, diesel exhibited lower CO and HC emissions than 20OME. At low loads, 20OME showed lower NOx emission than diesel in compression ratio 17 whereas in CR 18, both fuels exhibited higher NOx emission at all loads. Lower smoke emission was observed with 20OME than diesel at both compression ratios.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
References
Amarnath, H. K., & Prabhakaran, P. (2012). A study on the thermal performance and emissions of a variable compression ratio diesel engine fuelled with Karanja biodiesel and the optimization of parameters based on experimental data. International Journal of Green Energy, 9, 841–863. https://doi.org/10.1080/15435075.2011.647167.
Annamalai, M., Dhinesh, B., Nanthagopal, K., Sivarama Krishnan, P., Lalvani, J. I. J., Parthasarathy, M., et al. (2016). An assessment on performance, combustion and emission behavior of a diesel engine powered by ceria nanoparticle blended emulsified biofuel. Energy Conversion and Management, 123, 372–380.
Ashraful, A. M., Masjuki, H. H., Kalam, M. A., Rizwanul Fattah, I. M., Imtenan, S., Shahir, S. A., et al. (2014). Production and comparison of fuel properties, engine performance, and emission characteristics of biodiesel from various non-edible vegetable oils: A review. Energy Conversion and Management, 80, 202–228. https://doi.org/10.1016/j.enconman.2014.01.037.
Awolu, O. O., & Layokun, S. K. (2013). Optimization of two-step transesterification production of biodiesel from neem (Azadirachta indica) oil. Journal of Energy and Environmental Engineering, 4, 39. https://doi.org/10.1186/2251-6832-4-39.
Barik, D., & Murugan, S. (2015). Effects of diethyl ether (DEE) injection on combustion performance and emission characteristics of Karanja methyl ester (KME)–biogas fueled dual fuel diesel engine. Fuel. https://doi.org/10.1016/j.fuel.2015.09.094.
De, B., & Panua, R. S. (2014). An experimental study on performance and emission characteristics of vegetable oil blends with diesel in a direct injection variable compression ignition engine. The Journal of the Brazilian Society of Mechanical Sciences and Engineering, 90, 431–438. https://doi.org/10.1016/j.proeng.2014.11.873.
Deepanraj, B., Lawrence, P., Sivashankar, R., & Sivasubramanian, V. (2015). Analysis of pre-heated crude palm oil, palm oil methyl ester and its blends as fuel in a diesel engine. International Journal of Ambient Energy, 1–6. https://doi.org/10.1080/01430750.2015.1004106.
Dhinesh, B., & Annamalai, M. (2018). A study on performance, combustion and emission behaviour of diesel engine powered by novel nano nerium oleander biofuel. Journal of Cleaner Production, 196, 74–83.
Dhinesh, B., Bharathi, R. N., Lalvani, J. I. J., Parthasarathy, M., & Annamalai, K. (2017). An experimental analysis on the influence of fuel borne additives on the single cylinder diesel engine powered by Cymbopogon flexuosus biofuel. Journal of the Energy Institute, 90(4), 634–645.
Dhinesh, B., Raj, Y. M. A., Kalaiselvan, C., & KrishnaMoorthy, R. (2018). A numerical and experimental assessment of a coated diesel engine powered by high-performance nano biofuel. Energy Conversion and Management, 171, 815–824.
Ganesan, V. (2012). Internal combustion engines. India: McGraw Hill Education Pvt. Ltd.
Gautam, A., & Kumar, A. (2015). Determination of important biodiesel properties based on fuel temperature correlations for application in a locomotive engine. Fuel, 142, 289–302. https://doi.org/10.1016/j.fuel.2014.10.032.
Hariharan, S., Murugan, S., & Nagarajan, G. (2013). Effect of diethyl ether on Tyre pyrolysis oil fueled diesel engine. Fuel, 104, 109–115. https://doi.org/10.1016/j.fuel.2012.08.041.
Heywood, J. B. (1988). Internal combustion engine fundamentals. McGraw Hill.
Karthickeyan, V. (2017). Impact of partially stabilised zirconia on a single-cylinder diesel engine’s performance, using orange oil methyl ester biodiesel. International Journal of Ambient Energy, 1–10. https://doi.org/10.1080/01430750.2017.1341429.
Karthickeyan, V. (2018a). Experimental investigation on emission reduction in neem oil biodiesel using selective catalytic reduction and catalytic converter techniques. Environmental Science and Pollution Research, 25, 13548–13559. https://doi.org/10.1007/s11356-018-1599-9.
Karthickeyan, V. (2018b). Experimental analysis on thermally coated diesel engine with neem oil methyl ester and its blends. Heat and Mass Transfer, 54, 1961–1974. https://doi.org/10.1007/s00231-018-2286-6.
Karthickeyan, V. (2019). Effect of cetane enhancer on Moringa oleifera biodiesel in a thermal coated direct injection diesel engine. Fuel, 235, 538–550. https://doi.org/10.1016/j.fuel.2018.08.030.
Karthickeyan, V., Balamurugan, P., & Senthil, R. (2016a). Investigation of CI engine fueled with ethanol nano additives blended diesel. In Proceedings of the First International Conference on Recent Advances in Bioenergy Research (pp. 121–130). https://doi.org/10.1007/978-81-322-2773-1.
Karthickeyan, V., Balamurugan, P., & Senthil, R. (2016b). Production of orange oil methyl ester and experimental investigation on thermal barrier coated diesel engine. Asian Journal of Research in Social Sciences and Humanities, 6, 156–178. https://doi.org/10.5958/2249-7315.2016.00601.8.
Karthickeyan, V., Balamurugan, P., & Senthil, R. (2017). Comparative studies on emission reduction in thermal barrier coated engine using single blend ratio of various non-edible oils. Journal of the Brazilian Society of Mechanical Sciences and Engineering, 39, 1823–1833. https://doi.org/10.1007/s40430-016-0645-0.
Karthikeyan, R., & Mahalakshmi, N. V. (2007). Performance and emission characteristics of a turpentine-diesel dual fuel engine. Energy, 32, 1202–1209. https://doi.org/10.1016/j.energy.2006.07.021.
Mani, M., Subash, C., & Nagarajan, G. (2009). Performance, emission and combustion characteristics of a DI diesel engine using waste plastic oil. Applied Thermal Engineering, 29, 2738–2744. https://doi.org/10.1016/j.applthermaleng.2009.01.007.
Muralidharan, K., & Vasudevan, D. (2011). Performance, emission and combustion characteristics of a variable compression ratio engine using methyl esters of waste cooking oil and diesel blends. Applied Energy, 88, 3959–3968. https://doi.org/10.1016/j.apenergy.2011.04.014.
Murugan, S., Ramaswamy, M. C., & Nagarajan, G. (2008). A comparative study on the performance, emission and combustion studies of a DI diesel engine using distilled tyre pyrolysis oil-diesel blends. Fuel Processing Technology, 87, 2111–2121. https://doi.org/10.1016/j.fuel.2008.01.008.
Murugesan, A., Umarani, C., Subramanian, R., & Nedunchezhian, N. (2009). Bio-diesel as an alternative fuel for diesel engines—A review. Renewable and Sustainable Energy Reviews, 13, 653–662. https://doi.org/10.1016/j.rser.2007.10.007.
Osawa, W. O., Sahoo, P. K., Onyari, J. M., & Mulaa, F. J. (2016). Effects of antioxidants on oxidation and storage stability of Croton megalocarpus biodiesel. International Journal of Energy and Environmental Engineering, 7, 85–91. https://doi.org/10.1007/s40095-015-0191-z.
Purushothaman, K., & Nagarajan, G. (2009a). Effect of injection pressure on heat release rate and emissions in CI engine using orange skin powder diesel solution. Energy Conversion and Management, 50, 962–969. https://doi.org/10.1016/j.enconman.2008.12.030.
Purushothaman, K., & Nagarajan, G. (2009b). Experimental investigation on a C.I. engine using orange oil and orange oil with DEE. Fuel, 88, 1732–1740. https://doi.org/10.1016/j.fuel.2009.03.032.
Purushothaman, K., & Nagarajan, G. (2009c). Performance, emission and combustion characteristics of a compression ignition engine operating on neat orange oil. Renew Energy, 34, 242–245. https://doi.org/10.1016/j.renene.2008.03.012.
Rashid, U., Ibrahim, M., Yasin, S., Yunus, R., Taufiq-Yap, Y. H., & Knothe, G. (2013). Biodiesel from Citrus reticulata (mandarin orange) seed oil, a potential non-food feedstock. Industrial Crops and Products, 45, 355–359. https://doi.org/10.1016/j.indcrop.2012.12.039.
Rizwanul Fattah, I. M., Masjuki, H. H., Kalam, M. A., Mofijur, M., & Abedin, M. J. (2014). Effect of antioxidant on the performance and emission characteristics of a diesel engine fueled with palm biodiesel blends. Energy Conversion and Management, 79, 265–272. https://doi.org/10.1016/j.enconman.2013.12.024.
Sakthivel, G., Nagarajan, G., Ilangkumaran, M., & Gaikwad, A. B. (2014). Comparative analysis of performance, emission and combustion parameters of diesel engine fuelled with ethyl ester of fish oil and its diesel blends. Fuel, 132, 116–124. https://doi.org/10.1016/j.fuel.2014.04.059.
Senthil, R., & Silambarasan, R. (2015). Environmental effect of antioxidant additives on exhaust emission reduction in compression ignition engine fuelled with Annona methyl ester. Environmental Technology, 20, 1–7. https://doi.org/10.1080/09593330.2015.1021856.
Senthil, R., Silambarasan, R., & Ravichandiran, N. (2015). Influence of injection timing and compression ratio on performance, emission and combustion characteristics of Annona methyl ester operated diesel engine. Alexandria Engineering Journal, 54, 295–302. https://doi.org/10.1016/j.aej.2015.05.008.
Sharma, A., & Murugan, S. (2015). Potential for using a tyre pyrolysis oil-biodiesel blend in a diesel engine at different compression ratios. Energy Conversion and Management, 93, 289–297. https://doi.org/10.1016/j.enconman.2015.01.023.
Singh, N., & Bharj, R. (2015). Experimental investigation on the role of indigenous carbon nanotube emulsified fuel in a four-stroke diesel engine. Proceedings of the Institution of Mechanical Engineers, Part C: Journal of Mechanical Engineering Science, 1–14. https://doi.org/10.1177/0954406215586021.
Subbaiah, G. V., & Gopal, K. R. (2013). An experimental investigation on the performance and emission characteristics of a diesel engine fuelled with rice bran biodiesel and ethanol blends. International Journal of Green Energy, 37–41. https://doi.org/10.1080/15435075.2010.548539.
Subramani, L., Parthasarathy, M., Balasubramanian, D., & Ramalingam, K. (2018). Novel Garcinia gummi-gutta methyl ester (GGME) as a potential alternative feedstock for existing unmodified DI diesel engine. Renewable Energy, 125, 568–577.
Subramaniam, D., Murugesan, A., Avinash, A., & Kumaravel, A. (2013). Bio-diesel production and its engine characteristics—An expatiate view. Renewable and Sustainable Energy Reviews, 22, 361–370. https://doi.org/10.1016/j.rser.2013.02.002.
Tüccar, G., Tosun, E., Özgür, T., & Aydin, K. (2014). Diesel engine emissions and performance from blends of citrus sinensis biodiesel and diesel fuel. Fuel, 132, 7–11. https://doi.org/10.1016/j.fuel.2014.04.065.
Tudu, K., Murugan, S., & Patel, S. K. (2016). Effect of diethyl ether in a DI diesel engine run on a tyre derived fuel-diesel blend. Journal of the Energy Institute, 89, 525–535. https://doi.org/10.1016/j.joei.2015.07.004.
Vallinayagam, R., Vedharaj, S., Yang, W. M., Lee, P. S., Chua, K. J. E., & Chou, S. K. (2013). Combustion performance and emission characteristics study of pine oil in a diesel engine. Energy, 57, 344–351. https://doi.org/10.1016/j.energy.2013.05.061.
Vedharaj, S., Vallinayagam, R., Yang, W. M., Chou, S. K., & Lee, P. S. (2014). Effect of adding 1,4-dioxane with kapok biodiesel on the characteristics of a diesel engine. Applied Energy, 136, 1166–1173. https://doi.org/10.1016/j.apenergy.2014.04.012.
Wamankar, A. K., & Murugan, S. (2015). Combustion, performance and emission of a diesel engine fuelled with diesel doped with carbon black. Energy, 1–9. https://doi.org/10.1016/j.energy.2015.04.012.
Acknowledgements
The authors would like to express their thanks to University Grants Commission-South Eastern Regional Office, Hyderabad, India, for financial support through Minor research project for teachers with grant number 4-4/2013-14 (MRP-SEM/UGC-SERO).
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 2020 Springer Nature Singapore Pte Ltd.
About this chapter
Cite this chapter
Karthickeyan, V., Dhinesh, B., Balamurugan, P. (2020). Effect of Compression Ratio on Combustion, Performance and Emission Characteristics of DI Diesel Engine with Orange Oil Methyl Ester. In: Ghosh, S., Sen, R., Chanakya, H., Pariatamby, A. (eds) Bioresource Utilization and Bioprocess. Springer, Singapore. https://doi.org/10.1007/978-981-15-1607-8_14
Download citation
DOI: https://doi.org/10.1007/978-981-15-1607-8_14
Published:
Publisher Name: Springer, Singapore
Print ISBN: 978-981-15-1606-1
Online ISBN: 978-981-15-1607-8
eBook Packages: Earth and Environmental ScienceEarth and Environmental Science (R0)