Summary
In 62 male rotogravure printers, the time-weighted average (TWA) toluene exposure during one workweek ranged from 8 to 496 mg/m3 (median 96). Post-shift urinary excretion of hippuric acid showed a poor correlation with the air toluene concentration. Level of o-cresol excretion ranged from 0.08 to 2.37 mmol/mol creatinine and was associated with the exposure (r s = 0.57, P<0.0001), although the variation was considerable. However, this metabolite was significantly influenced by smoking habits, both in the workers (0.34 vs 0.10 mmol/mol creatinine after adjustment to zero exposure for the smokers and non-smokers, respectively; P = 0.03) and in 21 unexposed controls (0.18 vs 0.06 mmol/mot creatinine; P = 0.002). The excretion of these metabolites was followed during vacation, when the workers were unexposed. The shared one-compartment half-time was 44h (± SE 30, 82). After 2–4 weeks of vacation, the concentration of o-cresol was significantly higher for the smokers than the non-smokers (0.14 vs 0.06 mmol/mol creatinine; P = 0.02).No smoking-associated difference was found for the urinary hippuric acid concentration. However, there was an association between alcohol consumption and hippuric acid excretion (P = 0.03); no such difference was shown for o-cresol. These results demonstrate that hippuric acid excretion is unsuitable for biological monitoring of toluene exposure when the exposure level is below 200 mg/m3. Also, in spite of the favourable excretion kinetics, the impact of smoking and the large interindividual variation warrant the same conclusion for o-cresol as a means of monitoring low level exposure in an individual worker.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Angerer J (1979) Occupational chronic exposure to organic solvents. VII. Metabolism of toluene in man. Int Arch Occup Environ Health 43:63–67
Angerer J (1985) Occupational chronic exposure to organic solvents. XII. O-Cresol excretion after toluene exposure. Int Arch Occup Environ Health 56:323–328
Brown GK, Stokke O, Jellum E (1978) Chromatographic profile of high boiling point organic acids in human urine. J Chromatogr 145:177–184
Brugnone F, De Rosa E, Perbellini L, Bartolucci GB (1986) Toluene concentrations in the blood and alveolar air of workers during the workshift and the morning after. Br J Ind Med 43:56–61
Døssing M, Bælum J, Hansen SH, Lundqvist GR (1984) Effect of ethanol, cimetidine and propanolol on toluene metabolism in man. Int Arch Occup Environ Health 54:309–315
Engström K, Husman K, Rantanen J (1976) Measurements of toluene and xylene metabolites by gas chromatography. Int Arch Occup Environ Health 36:153–160
Fishbein L (1985) An overview of environmental and toxicological aspects of aromatic hydrocarbons. II. Toluene. Sci Total Environ 42:267–288
Guardabasso V, Munson P, Rodbard D (1988) EXPFIT: a program for simultaneous analysis of families of exponential decay curves. Comput Methods Programs Biomed 27:55–63
IARC (1986) IARC monographs on the evaluation of the carcinogenic risk of chemicals to humans, vol 38. Tobacco smoking. International Agency for Research on Cancer, Lyon
Jelnes JE (1989) Toluene. In: Heimbürger G, Beije B, Lundberg P (eds) Criteria documents from the Nordic Expert Group 1989. Arbete och Hälsa 37:7–57
Lauwerys R (1983) Toluene. In: Industrial health and safety. Commission of the European Communities, Luxemburg, pp 161–175 (Human biological monitoring of industrial chemicals series)
Low LK, Meeks JR, Mackerer CR (1988) Health effects of the alkylbenzenes, I. Toluene. Toxicol Ind Health 4:49–75
Lowry LK (1986) Biological exposure index as a complement to the TLV. J Occup Med 28:578–582
Matsui H, Kasao M, Imamura S (1977) Quantitative determination of hippuric and m-methylhippuric acids in urine by highspeed liquid chromatography. Br J Ind Med 34:310–313
Nise G, Ørbæk P (1988) Toluene in venous blood during and after work in rotogravure printing. Int Arch Occup Environ Health 60:31–35
Nise G, Attewell R, Skerfving S, Ørbæk P (1989) Elimination of toluene from venous blood and adipose tissue after occupational exposure. Br J Ind Med 46:407–411
Ogata M, Sugihara R (1978) High performance liquid chromatographic procedure for quantitative determination of urinary phenylglyoxylic, mandelic, and hippuric acids as indices of styrene exposure. Int Arch Occup Environ Health 42:11–19
Ogata M, Tomokuni K, Takatsuka Y (1970) Urinary excretion of hippuric acid and m- or p-methylhippuric acid in the urine of persons exposed to vapours of toluene and m- or p-xylene as a test of exposure. Br J Ind Med 27:43–50
Ørbæk P, Nise G (1989) Neurasthenic complaints and psychometric function of toluene-exposed rotogravure printers. Am J Ind Med 16:67–77
Pfäffli P, Savolainen H, Kalliomäki PL, Kallikoski P (1979) Urinary o-cresol in toluene exposure. Scand J Work Environ Health 5:286–289
Szadkowski D, Borkamp A, Lehnert G (1980) Hippursäureaus-scheidung im Ham in Abhängigkeit von Tagesrhythmik und alimentären Einflüssen. In Arch Occup Environ Health 45:141–152
Tähti H, Kärkkäinen S, Pyykkö K, Rintala E, Kataja M, Vapaatalo H (1981) Chronic occupational exposure to toluene. Int Arch Occup Environ Health 48:61–69
Waldron HA, Cherry N, Johnston JD (1983) The effects of ethanol on blood toluene concentrations. Int Arch Occup Environ Health 51:365–369
Wallén M, Näslund PH, Byfält Nordqvist M (1984) The effects of ethanol on the kinetics of toluene in man. Toxicol Appl Pharmacol 76:414–419
Wigaeus Hjelm E, Näslund PH, Wallén M (1988) Influence of cigarette smoking on the toxicokinetics of toluene in humans. J Toxicol Environ Health 25:155–163
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Nise, G. Urinary excretion of O-cresol and hippuric acid after toluene exposure in rotogravure printing. Int. Arch Occup Environ Heath 63, 377–381 (1992). https://doi.org/10.1007/BF00386931
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF00386931