Abstract
N,N-Dimethylacetamide/lithium chloride (DMAc/LiCl) mixture is a popular solvent system used for cellulose dissolution, analysis, and derivatization. However, a pre-treatment (activation) procedure is needed for most celluloses to dissolve readily in DMAc/LiCl. Here, an optimized version of the activation protocol based on solvent exchange to 1,4-dioxane was introduced. Its universality was demonstrated by successful activation and dissolution of six different celluloses (AVICEL, Sigmacell, cotton linters, Encell, Lincell, and Whatman paper). Dissolution times varied significantly for different cellulose types and also depended on factors such as the drying method employed or the water removal step inclusion/omission. Dioxane-activated celluloses were analyzed with a variety of methods. SEC measurements indicated low destructivity of the dioxane activation method. The infrared spectroscopy analysis showed that dioxane remained adsorbed on cellulose even after rigorous drying. In addition, upon dioxane activation, stagnation or a slight increase in the total order index of celluloses was observed. This observation was in accordance with the crystallinity index changes determined by solid-state NMR. Finally, scanning electron microscopy revealed disintegration of AVICEL particles and defibrillation of fibrous celluloses upon dioxane activation; Sigmacell remained apparently unchanged.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Brus J (2000) Heating of samples induced by fast magic-angle spinning. Solid State Nuc Mag Res 16:151–160. doi:10.1016/S0926-2040(00)00061-8
Edgar KJ, Arnold KM, Blount WW, Lawniczak JE, Lowman DW (1995) Synthesis and properties of cellulose acetoacetates. Macromolecules 28:4122–4128. doi:10.1021/ma00116a011
El Seoud OA, Heinze T (2005) Organic esters of cellulose: new perspectives for old polymers. Adv Polym Sci 186:103–149. doi:10.1007/b136812
El Seoud OA, Marson GA, Ciacco GT, Frollini E (2000) An efficient, one-pot acylation of cellulose under homogeneous reaction conditions. Macromol Chem Phys 201:882–889. doi:10.1002/(SICI)1521-3935(20000501)201:8<882:AID-MACP882>3.0.CO;2-I
El Seoud OA, Koschella A, Fidale LC, Dorn S, Heinze T (2007) Applications of ionic liquids in carbohydrate chemistry: a window of opportunities. Biomacromolecules 8:2629–2647. doi:10.1021/bm070062i
Frisch MJ et al (2004) Gaussian 03, revision C.02. Gaussian, Inc, Wallingford, CT
Gericke M, Liebert T, El Seoud OA, Heinze T (2011) Tailored media for homogeneous cellulose chemistry: ionic liquid/co-solvent mixtures. Macromol Mater Eng 296:483–493. doi:10.1002/mame.201000330
Heinze T (1998) New ionic polymers by cellulose functionalization. Macromol Chem Phys 199:2341–2364. doi:10.1002/(SICI)1521-3935(19981101)199:11<2341:AID-MACP2341>3.0.CO;2-J
Heinze T, Liebert T (2001) Unconventional methods in cellulose functionalization. Prog Polym Sci 26:1689–1762. doi:10.1016/S0079-6700(01)00022-3
Henniges U, Schiehser S, Rosenau T, Potthast A (2010) Cellulose solubility: dissolution and analysis of “problematic” cellulose pulps in the solvent system DMAc/LiCl. In: Liebert TF, Heinze TJ, Edgar KJ (eds) Cellulose solvents: for analysis, shaping and chemical modification. American Chemical Society, Washington, DC, pp 165–177
Henniges U, Kostic M, Borgards A, Rosenau T, Potthast A (2011) Dissolution behavior of different celluloses. Biomacromolecules 12:871–879. doi:10.1021/bm101555q
Horsley LH (1947) Table of azeotropes and nonazeotropes. Anal Chem 19:508–600. doi:10.1021/ac60008a002
Ishii D, Isogai A (2008) The residual amide content of cellulose sequentially solvent-exchanged and then vacuum-dried. Cellulose 15:547–553. doi:10.1007/s10570-008-9211-y
Ishii D, Tatsumi D, Matsumoto T (2008) Effect of solvent exchange on the supramolecular structure, the molecular mobility and the dissolution behavior of cellulose in LiCl/DMAc. Carbohydr Res 343:919–928. doi:10.1016/j.carres.2008.01.035
Johari GP, Smyth CP (1969) Microwave absorption and molecular structure in liquids. LXXVI. Relaxation behavior of several primary alcohols in dilute benzene and p-dioxane solutions. J Am Chem Soc 91:6215–6220. doi:10.1021/ja01051a001
Kumbharkhane AC, Shinde MN, Mehrotra SC, Oshiki N, Shinyashiki N, Yagihara S, Sudo S (2009) Structural behavior of alcohol-1,4-dioxane mixtures through dielectric properties using TDR. J Phys Chem A 113:10196–10201. doi:10.1021/jp904845p
Lennholm H, Larsson T, Iversen T (1994) Determination of cellulose Iα and Iβ in lignocellulosic materials. Carbohydr Res 261:119–131. doi:10.1016/0008-6215(94)80011-1
Liang CY, Marchessault RH (1959a) Infrared spectra of crystalline polysaccharides. I. Hydrogen bonds in native celluloses. J Polym Sci 37:385–395. doi:10.1002/pol.1959.1203713209
Liang CY, Marchessault RH (1959b) Infrared spectra of crystalline polysaccharides. II. Native celluloses in the region from 640 to 1700 cm−1. J Polym Sci 39:269–278. doi:10.1002/pol.1959.1203913521
Liebert T (2010) Cellulose solvents—remarkable history, bright future. In: Liebert T, Heinze T, Edgar KJ (eds) Cellulose solvents: for analysis, shaping and chemical modification. American Chemical Society, Washington, DC, pp 3–54
Malherbe FE, Bernstein HJ (1952) The infrared and Raman spectra of p-dioxane. J Am Chem Soc 74:4408–4410. doi:10.1021/ja01137a051
Marson GA, El Seoud OA (1999a) Cellulose dissolution in lithium chloride/N,N-dimethylacetamide solvent system: relevance of kinetics of decrystallization to cellulose derivatization under homogeneous solution conditions. J Polym Sci Polym Chem 37:3738–3744. doi:10.1002/(SICI)1099-0518(19991001)37:19<3738:AID-POLA11>3.0.CO;2-R
Marson GA, El Seoud OA (1999b) A novel, efficient procedure for acylation of cellulose under homogeneous solution conditions. J Appl Polym Sci 74:1355–1360. doi:10.1002/(SICI)1097-4628(19991107)74:6<1355:AID-APP5>3.0.CO;2-M
McCormick CL, Callais PA, Hutchinson BH (1985) Solution studies of cellulose in lithium chloride and N,N-dimethylacetamide. Macromolecules 18:2394–2401. doi:10.1021/ma00154a010
Nelson ML, O’Connor RT (1964a) Relation of certain infrared bands to cellulose crystallinity and crystal latticed type. Part I. Spectra of lattice types I, II, III and of amorphous cellulose. J Appl Polym Sci 8:1311–1324. doi:10.1002/app.1964.070080322
Nelson ML, O’Connor RT (1964b) Relation of certain infrared bands to cellulose crystallinity and crystal lattice type. Part II. A new infrared ratio for estimation of crystallinity in celluloses I and II. J Appl Polym Sci 8:1325–1341. doi:10.1002/app.1964.070080323
Park S, Baker JO, Himmel ME, Parilla PA, Johnson DK (2010) Cellulose crystallinity index: measurement techniques and their impact on interpreting cellulase performance. Biotech Biofuels 3:1–10. doi:10.1186/1754-6834-3-10
Pinkert A, Marsh KN, Pang S, Staiger MP (2009) Ionic liquids and their interaction with cellulose. Chem Rev 109:6712–6728. doi:10.1021/cr9001947
Potthast A, Rosenau T, Sixta H, Kosma P (2002a) Degradation of cellulosic materials by heating in DMAc/LiCl. Tetrahedron Lett 43:7757–7759. doi:10.1016/S0040-4039(02)01767-7
Potthast A, Rosenau T, Buchner R, Röder T, Ebner G, Bruglachner H, Sixta H, Kosma P (2002b) The cellulose solvent system N,N-dimethylacetamide/lithium chloride revisited: the effect of water on physicochemical properties and chemical stability. Cellulose 9:41–53. doi:10.1023/A:1015811712657
Potthast A, Rosenau T, Sartori J, Sixta H, Kosma P (2003) Hydrolytic processes and condensation reactions in the cellulose solvent system N, N-dimethylacetamide/lithium chloride. Part 2: degradation of cellulose. Polymer 44:7–17. doi:10.1016/S0032-3861(02)00751-6
Ramos LA, Assaf JM, El Seoud OA, Frollini E (2005) Influence of the supramolecular structure and physicochemical properties of cellulose on its dissolution in a lithium chloride/N,N-dimethylacetamide solvent system. Biomacromolecules 6:2638–2647. doi:10.1021/bm0400776
Ramos LA, Morgado DL, El Seoud OA, da Silva VC, Frollini E (2011) Acetylation of cellulose in LiCl-N, N-dimethylacetamide: first report on the correlation between the reaction efficiency and the aggregation number of dissolved cellulose. Cellulose 18:385–392. doi:10.1007/s10570-011-9496-0
Raus V, Štěpánek M, Uchman M, Šlouf M, Látalová P, Čadová E, Netopilík M, Kříž J, Dybal J, Vlček P (2011) Cellulose-based graft copolymers with controlled architecture prepared in a homogeneous phase. J Polym Sci Pol Chem 49:4353–4367. doi:10.1002/pola.24876
Regiani AM, Frollini E, Marson GA, Arantes GM, El Seoud OA (1999) Some aspects of acylation of cellulose under homogeneous solution conditions. J Polym Sci Pol Chem 37:1357–1363. doi:10.1002/(SICI)1099-0518(19990501)37:9<1357:AID-POLA16>3.0.CO;2-Y
Röder T, Morgenstern B, Schelosky N, Glatter O (2001) Solutions of cellulose in N,N-dimethylacetamide/lithium chloride studied by light scattering methods. Polymer 42:6765–6773. doi:10.1016/S0032-3861(01)00170-7
Sengwa R, Sankhla S (2007) Characterization of heterogeneous interaction in binary mixtures of ethylene glycol oligomer with water, ethyl alcohol and dioxane by dielectric analysis. J Mol Liq 130:119–131. doi:10.1016/j.molliq.2006.05.011
Sjöholm E, Gustafsson K, Pettersson B, Colmsjö A (1997) Characterization of the cellulosic residues from lithium chloride/N,N-dimethylacetamide dissolution of softwood kraft pulp. Carbohydr Polym 32:57–63. doi:10.1016/S0144-8617(96)00129-4
Strlič M, Kolar J (2003) Size exclusion chromatography of cellulose in LiCl/N, N-dimethylacetamide. J Biochem Biophys Methods 56:265–279. doi:10.1016/S0165-022X(03)00064-2
Sugiyama J, Persson J, Chanzy H (1991) Combined infrared and electron diffraction study of the polymorphism of native celluloses. Macromolecules 24:2461–2466. doi:10.1021/ma00009a050
Swatloski RP, Spear SK, Holbrey JD, Rogers RD (2002) Dissolution of cellulose with ionic liquids. J Am Chem Soc 124:4974–4975. doi:10.1021/ja025790m
Urban MW (1996) Attenuated total reflectance spectroscopy of polymers theory and practice. American Chemical Society, Washington, DC
Vlček P, Janata M, Látalová P, Kríž J, Čadová E, Toman L (2006) Controlled grafting of cellulose diacetate. Polymer 47:2587–2595. doi:10.1016/j.polymer.2006.02.067
Vlček P, Janata M, Látalová P, Dybal J, Špírková M, Toman L (2008) Bottlebrush-shaped copolymers with cellulose diacetate backbone by a combination of ring opening polymerization and ATRP. J Polym Sci Pol Chem 46:564–573. doi:10.1002/pola.22406
Vlček P, Raus V, Janata M, Kříž J, Sikora A (2011) Controlled grafting of cellulose esters using SET-LRP process. J Polym Sci Pol Chem 49:164–173. doi:10.1002/pola.24431
Yan L, Ishihara K (2008) Graft copolymerization of 2-methacryloyloxyethyl phosphorylcholine to cellulose in homogeneous media using atom transfer radical polymerization for providing new hemocompatible coating materials. J Polym Sci Pol Chem 46:3306–3313. doi:10.1002/pola.22670
Acknowledgments
This work has been supported by the Grant Agency of the Czech Republic (grants P108/12/0703 and 106/09/1348). The authors thank Prof. Antje Potthast and Dr. Ute Henniges for provision of cellulose samples, carrying out the SEC MALLS analyses, and helpful discussion of the results. The authors also acknowledge Mrs. Brunclíková for the measurement of ATR FTIR spectra.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Raus, V., Šturcová, A., Dybal, J. et al. Activation of cellulose by 1,4-dioxane for dissolution in N,N-dimethylacetamide/LiCl. Cellulose 19, 1893–1906 (2012). https://doi.org/10.1007/s10570-012-9779-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10570-012-9779-0