Toxicological Reviews

, Volume 22, Issue 1, pp 13–27

Occupational Methaemoglobinaemia

Mechanisms of Production, Features, Diagnosis and Management Including the Use of Methylene Blue

Authors

    • National Poisons Information Service (Birmingham Centre)City Hospital
Review Article

DOI: 10.2165/00139709-200322010-00003

Cite this article as:
Bradberry, S.M. Toxicol Rev (2003) 22: 13. doi:10.2165/00139709-200322010-00003

Abstract

Methaemoglobin is formed by oxidation of ferrous (FeII) haem to the ferric (FIII) state and the mechanisms by which this occurs are complex. Most cases are due to one of three processes. Firstly, direct oxidation of ferrohaemoglobin, which involves the transfer of electrons from ferrous haem to the oxidising compound. This mechanism proceeds most readily in the absence of oxygen. Secondly, indirect oxidation, a process of co-oxidation which requires haemoglobin-bound oxygen and is involved, for example, in nitrite-induced methaemoglobinaemia. Thirdly, biotransformation of a chemical to an active intermediate that initiates methaemoglobin formation by a variety of mechanisms. This is the means by which most aromatic compounds, such as amino- and nitro-derivatives of benzene, produce methaemoglobin.

Methaemoglobinaemia is an uncommon occupational occurrence. Aromatic compounds are responsible for most cases, their lipophilic nature and volatility facilitating absorption during dermal and inhalational exposure, the principal routes implicated in the workplace.

Methaemoglobinaemia presents clinically with symptoms and signs of tissue hypoxia. Concentrations around 80% are life-threatening. Features of toxicity may develop over hours or even days when exposure, whether by inhalation or repeated skin contact, is to relatively low concentrations of inducing chemical(s). Not all features observed in patients with methaemoglobinaemia are due to methaemoglobin formation. For example, the intravascular haemolysis caused by oxidising chemicals such as chlorates poses more risk to life than the methaemoglobinaemia that such chemicals induce.

If an occupational history is taken, the diagnosis of methaemoglobinaemia should be relatively straightforward. In addition, two clinical observations may help: firstly, the victim is often less unwell than one would expect from the severity of ‘cyanosis’ and, secondly, the ‘cyanosis’ is unresponsive to oxygen therapy. Pulse oximetry is unreliable in the presence of methaemoglobinaemia. Arterial blood gas analysis is mandatory in severe poisoning and reveals normal partial pressures of oxygen (pO2) and carbon dioxide (pCO2,), a normal ‘calculated’ haemoglobin oxygen saturation, an increased methaemoglobin concentration and possibly a metabolic acidosis.

Following decontamination, high-flow oxygen should be given to maximise oxygen carriage by remaining ferrous haem. No controlled trial of the efficacy of methylene blue has been performed but clinical experience suggests that methylene blue can increase the rate of methaemoglobin conversion to haemoglobin some 6-fold. Patients with features and/or methaemoglobin concentrations of 30–50%, should be administered methylene blue 1–2 mg/kg/bodyweight intravenously (the dose depending on the severity of the features), whereas those with methaemoglobin concentrations exceeding 50% should be given methylene blue 2 mg/kg intravenously. Symptomatic improvement usually occurs within 30 minutes and a second dose of methylene blue will be required in only very severe cases or if there is evidence of ongoing methaemoglobin formation. Methylene blue is less effective or ineffective in the presence of glucose-6-phosphate dehydrogenase deficiency since its antidotal action is dependent on nicotinamide-adenine dinucleotide phosphate (NADP+). In addition, methylene blue is most effective in intact erythrocytes; efficacy is reduced in the presence of haemolysis. Moreover, in the presence of haemolysis, high dose methylene blue (20–30 mg/kg) can itself initiate methaemoglobin formation.

Supplemental antioxidants such as ascorbic acid (vitamin C), N-acetylcysteine and tocopherol (vitamin E) have been used as adjuvants or alternatives to methylene blue with no confirmed benefit. Exchange transfusion may have a role in the management of severe haemolysis or in G-6-P-D deficiency associated with life-threatening methaemoglobinaemia where methylene blue is relatively contraindicated.

Copyright information

© Adis Data Information BV 2003