Contents

1 Introduction

Palm oil happens to be among the products which causes immense ecological damage. Increase in palm oil production occurs at the expense of biodiversity and damages the ecosystem. Forest cover in the Riau Province in Central Sumatra declined by 65% (4 million hectares) over the past 25 years from 78% in 1982 to 27% in 2007. Of the forest cover lost, 29% was cleared for industrial oil palm plantations (Uryu et al. 2008). Two models predicted that the forest cover would decline to 6 and 15% (assuming full implementation of Riau’s draft provincial land use plan) by 2015. Oil palm plantations would contribute 27% (1.4 million hectares) of all the forest lost since 1982 (Uryu et al. 2008). Due to deforestation, loss of natural habitat, and unsustainable development of palm plantations, Sumatran orangutans, tigers (declined by 70%, from 640 in 1982 to 192 in 2007), and elephants (declined by up to 84%, from an estimated 1067–1617 in 1984 to possibly as few as 210 individuals in 2007) have been critically endangered (Uryu et al. 2008). Burning of trees and forests or peat swamps and also draining of peatlands to increase palm oil acreage release greenhouse gases into the atmosphere that contribute to global warming (Uryu et al. 2008; van der Werf et al. 2009). Hazardous pesticides and fertilizers like the herbicide paraquat pose a serious health hazard to the spray operators (Pesticides Action Network Asia Pacific 2009). Global consumption of palm oil and paper has been driving Riau’s deforestation; it appears to also drive climate change. Reducing CO2 emissions would be far more effective if investments were allocated to the avoidance of deforestation. Furthermore, it has been reported that the consumption of palmitic acid increases the risk of cardiovascular diseases (WHO 2003; Chen et al. 2011), and much of the palm oil consumed in food is oxidized to the extent that when compared to the fresh state poses a health risk. Excessive intake and absorption of saturated fatty acids, other than stearic acid, generally has a negative effect on cardiovascular health.

The food industry currently needs healthier and more stable oils which are solid or semi-solid at room temperature (alternatives to hydrogenation and palm), have a longer shelf life, and without trans fats. Palm oil is one of the few highly saturated vegetable fats which is semi-solid at room temperature. The use of palm oil in the food industry is widespread because of its lower cost, high oxidative stability of the refined oil while frying, long shelf-life, and a reasonable replacement of trans fats from hydrogenated vegetable oils (McNamara 2010; Hayes and Pronczuk 2010) thus contributing to a healthy diet. Palm oil contains several saturated fatty acids (FAs) (lauric (0.1%), myristic (1%), palmitic (44%), stearic (5%)) and unsaturated FAs (oleic (39%), linoleic (10%), and alpha-linolenic (0.3%)). All the solid vegetable fats which can be classified into three groups (lauric, palmitic, and stearic fats) come from tropical species (Garcés et al. 2012).

Hence, a new alternative to palm oil which will be sustainable, easily accessible, cost effective, and compatible with a healthy diet is needed. Modern oilseed biotechnology has therefore targeted the production of fats enriched in saturated FAs mainly stearic acid, in common oil crops (Garcés et al. 2012). Several sunflower mutants with high stearic acid have been isolated by classical breeding and mutagenesis techniques thus avoiding concerns regarding the proliferation of genetically modified organisms in agriculture (Martinez-Force and Garcés 1999). Some of these sunflower mutants express the high-stearic trait on a high-oleic background, and so their oil is enriched in triacylglycerols which are typically present in cocoa butter. Thus, the new high-stearic (HS) and high-stearic-high-oleic (HSHO) sunflower oil could be a reliable source of stearic-rich butter and an alternative to tropical fats. These oils can be fractionated to produce stearins enriched in stearic acid with physical properties similar to cocoa butter and other confectionary fats without hydrogenation or transesterification. These fats can be produced in temperate countries from a well-established crop like sunflower and would be a healthy source of saturated FAs (Garcés et al. 2012).

The most advance breeding program came from the Advanta Seeds Company. A high-stearate (15 to 20%) sunflower oil in a high-oleic background is being commercialized under the brand name “Nutrisun” (Figs. 1 and 2).

Fig. 1
figure 1

A field trial of a sunflower crop in France. Photo credit: Terres Inovia

Fig. 2
figure 2

Characteristics of Nutrisun oil. Typical fatty acid composition of Nutrisun oil with high proportions of stearic and oleic acids and low proportions of palmitic acid making it a stable and healthy oil. The numbers represent the percent of the individual fatty acids. Data obtained from Advanta Seeds

High levels of saturated and low levels of polyunsaturated FAs made this HSHO sunflower oil more viscous and resistant to oxidation than those from common or high-oleic sunflower crops. The melting point of HSHO sunflower oils is also higher as it contains higher proportions of solid fats than common or high-oleic sunflower oils. However, this increase in the melting point was not close enough to those of high-stearic tropical butters like shea or cocoa butter. Different types of stearin fats, obtained by dry or solvent fractionation of HSHO sunflower oils, can have a high solid fat content at temperatures >30 °C which is even higher than cocoa butter or other high saturated tropical fats. This means that the HSHO oil itself cannot be used for confectionary applications and needs further processing before it can be a source for these fats. However, the solid fat content in Nutrisun can range from those of the original HSHO to hard stearin fractions with solid fat content values closer to shea and cocoa butter (Fig. 3) and has no trans fats. As an annual crop, Nutrisun oil has the potential of becoming the best competitive source of natural stearic acid when compared to other stearic sources and vegetable oils (Figs. 3 and 4). Nutrisun oil also has similar disaturated triacylglycerol content due to the presence of disaturated triacylglycerols rich in stearic acid and improved melting point due to the presence of arachidic and behenic acids in these disaturated triacylglycerols. Furthermore, these fats are also healthier than the actual fats made from palm, palm kernel, and coconut oils, or hydrogenated and transesterified vegetable oils. The olein fraction is also very stable and can be a perfect substitute for nonfractionated oil in frying and bakery applications.

Fig. 3
figure 3

Comparison of Nutrisun oil with other stearic sources. Nutrisun oil has the highest proportion of stearic acid and is the best source of natural stearic acid when compared with other stearic sources. (A) Nutrisun stearin. (B) Illipi butter. (C) Shea butter. (D) Cocoa butter. (E) Palm stearin. The numbers in the concentric circles represent the percentages of the fatty acids

Fig. 4
figure 4

Comparison of Nutrisun oil with other vegetable oils. Nutrisun oil has the highest proportion of stearic acid and is the best source of natural stearic acid when compared with other vegetable oils. (A) Nutrisun HSHO. (B) Olive. (C) Rapeseed. (D) Rice tran. (E) Palm. (F) Regular sunflower. (G) Corn. (H) Soybean. The numbers in the concentric circles represent the percentages of the fatty acids

Synthesis of FAs in developing sunflower seeds takes place in the plastids and the endoplasmic reticulum (ER). From all the enzymes that participate to metabolize FAs, stearoyl-ACP desaturase (SAD, which has two isoforms in sunflower), oleoyl-CoA desaturase (OLD), and thioesterases (FAT A and B) are being highlighted. The SAD enzyme, which is located in the plastid, catalyzes the conversion of stearic to oleic acid through one unsaturation step at carbon-9 in the fatty acid hydrocarbonated chain. The OLD enzyme is in the ER and catalyzes the transformation of oleic to linoleic acid through the addition of a second unsaturation step at carbon-12. The FAT enzymes regulate the transportation of the FAs synthesized in the plastid (palmitic, stearic, and oleic acids) to the ER (Martinez-Force and Garcés 2000).

2 Agronomic aspects

2.1 Planting date, density, and plant establishment

Previous studies on conventional and high-oleic sunflower hybrids have revealed that planting date, between-row distance, and plant density might affect the grain and oil yield and oil composition of high-stearic and high-stearic-high-oleic sunflower crops.

Tests were carried out in a 2-year experiment (2009 and 2010) on the HSHO commercial hybrid (HS03) in Advanta’s Biotechnology Center at Balcarce in Argentina. The HSHO sunflower hybrid used in the experiment was characterized as having short stature, medium yield potential, and early medium maturity. The evaluated factors were two planting dates (22nd and 25th October and 23rd and 25th November) in 2009 and 2010, two between-row-distance treatments (0.70, 0.52 m), and three plant density levels (40,000, 65,000 and 90,000 plants per hectare).

Weather conditions benefited the growth and development of Nutrisun HSHO sunflower hybrids in 2010 compared to 2009 for both planting dates at Balcarce in Argentina. Grain yields in 2010 were double of those in 2009 (2022.1 vs. 4035.9 kg/ha, Table 1) which agrees with previous studies (Flagella et al. 2002). Rainfall was greater throughout the growing season in 2010 compared to 2009 and may explain the increased yield in 2010 as the rainfall for early planting dates in October in 2009 was inadequate. Although in 2009 rains were more abundant early and late in the season, almost no difference was observed between years in the period −10/+20 days around flowering for November planting date. The planting year and the interaction between planting year and date and their effect on grain and oil yield were significant (Table 1). Sunflower plots sown in October always had better yield than those planted in November (Table 1). Also, oil yield was greater for October planting dates and the difference among planting dates varied across years (Table 1) which was similar to what was reported by other researchers (Zheljazkov et al. 2009). The oil content proportions were 41.4 and 36.2% for October and November. The effect of early planting date on oil content derives from the most favorable conditions for incident radiation and temperature during the growing season. Oil content was observed to significantly decrease when sunflower was planted in November as well as when plant density was reduced. Seed oil content was the only variable affected by plant density (41.4, 42.5, and 42.5% for the 40, 65, and 90,000 plants/ha). Previous studies (Aguirrezabal and Pereyra 1998) showed that seed oil content remains almost constant across different plant densities whereas the other components of the kernel (i.e., hull, proteins) vary leading to changes in seed oil percentage. Seed oil composition was also affected by year and planting date. The stearic acid content was higher for early planting dates in 2009 but lower in 2010; the opposite response was true for the oleic acid content. Neither row spacing nor plant density affected the proportions of stearic or oleic acids. Although stearic and oleic acid content was affected by planting date, which might have been a consequence of different weather conditions. Studies show that genotype and weather seem to have a direct impact on oil content and fatty acid composition, and since HSHO sunflower hybrids have improved yield and oil content potential, further research to understand these interactions is needed (Cánepa et al. 2012).

Table 1 Nutrisun hybrid performance in 2011, 2012, and 2013 (Cánepa et al. 2012)

Recently, sunflower hybrids differing in oil composition have been developed to provide for different industrial and human needs. France is probably the leading country for the oleic type (>75%) sunflower cultivation covering 54 and 57% of the total acreage in 2010 and 2011. The 5-year ONIDOL/TERRES INOVIA survey from 2006 to 2010 showed that the mean oleic acid content in France ranged between 85.4 and 86.7% (Labalette et al. 2012). These oils are characterized by the relative amount of saturated, mono-, and polyunsaturated fatty acids. Fatty acid composition varied depending on year, location, genotype, cultural practices, and environmental conditions (primarily temperature).

2.2 Climate

2.2.1 Drought and high temperatures

In the high stearic acid containing CAS-14 mutant, the stearic acid content increased with increasing temperatures. The highest stearic acid seeds were obtained from the plants that produced the seeds during the period of maximum summer temperatures (35–40 °C during the day and 20–25 °C at night) (Fernandez-Moya et al. 2002) whereas in the medium stearic containing CAS-3 and CAS-4 mutants, and a high stearic acid containing line ADV-3512, the stearic acid proportions decreased at high temperatures (Izquierdo et al. 2013). The CAS-14 mutant line has more stearic acid (37.3%) than the previous high-stearic-acid sunflower mutants like CAS-3 which had 28.8% stearic acid (Fernandez-Moya et al. 2002; Osorio et al. 1995). Due to the sensitivity of desaturases to temperature, high temperatures increase the content of mono-unsaturated fatty acids (C18:1) (Merrien et al. 2005).

An effect of temperature on the high-stearic-acid sunflower mutants was observed. Temperatures higher than 30/20 °C (day/night temperatures) were required for the expression of the phenotype of the CAS-14 mutant. Seeds from CAS-14 plants were subjected to three different high temperature treatments and seeds were collected for fatty acid half-seed analysis. As expected, the stearic acid content increased with temperature, mainly from 30/20 to 35/22 °C (14.2 and 34.0%, respectively). The maximum stearic acid (37.3%) content was obtained at 39/24 °C (Fernandez-Moya et al. 2002). A similar effect was found in the contents of the other saturated fatty acids: palmitic, arachidic, and behenic acids. Thus, a new type of temperature regulation on the stearate desaturation must be occurring.

The relationship between the growth temperature and the stearic acid content found in CAS-14 was the opposite of what was previously observed in normal sunflower oils, in which more stearic acid was produced at low temperatures (Lajara et al. 1990). In a study covering 33 field locations in Spain, it was observed that the stearic acid content decreased progressively from 6 to 3.2% from Northern Spain (colder weather) to Southern Spain (warmer weather). Also, in the medium stearic acid mutants CAS-4 and CAS-8, an inverse relationship between growth temperature and stearic acid proportions was reported. At 30/20 °C day/night temperature, these mutants had 11–12% stearic acid, whereas at 20/10 °C, they contained 18–20% stearic acid (Martínez-Force et al. 1998). In another study by Izquierdo et al. (2013) with the CAS-3 mutant, the stearic acid content at 16/16 °C was higher than at 26/26 °C (26.2 vs. 18.4%) during the grain filling period. This study also found the highest variation in the fatty acid composition in the CAS-3 mutant. This pattern was also observed in another treatment (16/16, 26/16, 26/26, and 32/26 °C) where the stearic acid content was higher for two (CAS-3 and ADV-3512) of the three high-stearic inbred lines and two (ADV-3807 and ADV-2803) of the three HSHO inbred lines at lower temperatures. A reduction of approximately 10% in the concentration of stearic acid was observed between extreme treatments (Izquierdo et al. 2013).

2.3 Yield

Nutrisun medium-stearic-high-oleic (MSHO) hybrid MS06 and HSHO hybrid (HS03) developed by the Instituto de la Grasa of Sevilla, CSIC (Superior Council of Scientific Research) in Spain and Advanta Seeds were grown in France in 2011, 2012, and 2013 and HS03 was grown at Balcarce in Argentina in 2009 and 2010 and the yields are shown in Table 1. The first Nutrisun crop was harvested in Argentina in 2008, then in Spain in 2009, and the USA in 2010.

A field experiment was conducted in 2014 in the Atlantic border region (Surgères) in France (Fig. 5). The performance of the stearic Nutrisun hybrid was the same as the other sunflower types.

Fig. 5
figure 5

Comparison of the performances of the Nutrisun hybrids, oleic, and conventional sunflowers in the west Atlantic region in France in 2014. The field experiment showed that the performance of the stearic Nutrisun hybrid was the same as the other sunflower types

3 Breeding

The novel fatty acid traits are in all cases governed by a reduced number of genes and can be easily managed in breeding programs aimed at developing cultivars incorporating these traits (Fernández-Martínez et al. 2007). High-stearic-acid oils on standard backgrounds or high-oleic backgrounds suitable for the production of more healthy margarines obtained through conventional plant breeding have been commercialized or are foreseeable in a few years (Fernández-Martínez et al. 2007).

Some breeding objectives are associated with the traits or properties desired by the food industry like oil with high-stearic acid is desirable for preparation of margarine and other specialty products and also because it does not increase the serum cholesterol level.

Several Helianthus annuus cultivars with high-stearic acid content were generated to increase the variability of the trait in the standard lines by using mutagenesis or crossing screened mutants with high stearic acid proportions with standard lines (Table 2). Furthermore, high-stearic-high-oleic (HSHO) sunflower oil called Nutrisun™ developed by Advanta Seeds was obtained through conventional breeding (non-GMO), molecular marker-assisted selection, and analytical techniques which allowed for a more efficient selection of the individuals of interest (Pleite et al. 2006).

Table 2 The phenotype based on the fatty acid composition (%) of the seed oil of the principal induced and natural mutant cultivars of sunflower, in comparison with the standard type

Mutagenesis has been successfully used for developing variation in the fatty acid profile of sunflower. The mutants CAS-8, CAS-4, and CAS-3 with medium to high stearic acid proportions (Osorio et al. 1995) and CAS-14 with very high stearic acid proportions (Fernandez-Moya et al. 2002) have been developed. Further, CAS-29 and CAS-30 also have very high stearic acid proportions (Fernandez-Moya et al. 2005) and CAS-19 and CAS-20 have medium stearic acid proportions (Pérez-Vich et al. 2004) (Table 3). All these traits are usually under embryonic control by few genes (Fernandez-Martínez et al. 2004) which facilitate their management in breeding programs. For example, three genes (Es1, Es2, and Es3) are involved in the control of high stearic acid proportions and one or two genes in the control of low levels of these fatty acids. Moreover, in recent years, molecular markers have been developed for high stearic and high oleic acid proportions (Pérez-Vich et al. 2002). The use of these molecular markers will contribute towards improving breeding efficiency (Fernández-Martínez et al. 2007).

Table 3 Fatty acid composition in high stearic acid, parental, and standard lines of sunflower, regular sunflower, and palm

In several studies, the molecular nature of high stearic acid mutants were investigated in order to increase the stearic acid proportions for improved quality of sunflower oil, which is a desirable breeding objective for food-processing applications (Pérez-Vich et al. 2006).

Molecular markers have enabled detailed characterization of the CAS-3 mutant. Classical genetic studies indicate that the two partially recessive genes (Es1 and Es2) are involved in the genetic control of the high C18:0 trait in this line (C18:0 genotype es1es1es2es2) (Pérez-Vich et al. 1999). The Es1 locus has the greatest effect on C18:0 levels, but both Es loci had an additive effect on the proportions of C18:0 (Pérez-Vich et al. 1999, 2004a). Candidate gene and quantitative trait loci (QTL) analysis revealed the co-location of a major QTL affecting stearic acid proportions with a gene of known function in the seed fatty acid biosynthetic pathway. A stearoyl-acyl carrier protein desaturase locus (SAD17A) which desaturates stearate to oleate in the de novo biosynthesis of fatty acids in the stroma of seed plastids was found to co-segregate with Es1 (Pérez-Vich et al. 2002). Using RFLP-AFLP linkage maps constructed from two different mapping populations derived from CAS-3, the SAD17A locus was mapped to the linkage group (LG) 1 of the sunflower genetic map, according to the LG nomenclature of Berry et al. (1997), and was found to underlie the major QTL affecting the concentration of C18:0. This QTL explained around 80% of the phenotypic variance of stearic acid (Pérez-Vich et al. 2002). Other minor QTL affecting stearic acid content which mapped to LG3, LG7, and LG13 were also identified in this study. However, these QTL were neither consistent across mapping populations nor with the various methods used to perform the QTL analyses. Therefore, none of the minor QTL was considered as strong candidates for the Es2 locus (Pérez-Vich et al. 2002).

Another QTL study for high stearic acid proportions in sunflower was performed (Perez-Vich et al. 2004a). The sunflower line CAS-20 (C18:0 genotype Es1Es1es2es2), developed from the high C18:0 mutant line CAS-3 (C18:0 genotype es1es1es2es2; 25% C18:0), had increased C18:0 levels in its seed oil (8.6%). QTL conferring increased C18:0 proportions in CAS-20 was mapped in a F2 mapping population developed from crosses between HA-89 (wild-type Es1Es1Es2Es2) with low C18:0 and CAS-20 (C18:0 genotype Es1Es1es2es2), which segregated independent of the macromutation at Es1 controlling high C18:0 proportions in CAS-3. A genetic map of 17 LGs comprising of 80 RFLP and 19 SSR marker loci from this population was used to identify the QTL controlling the fatty acid composition. Three QTL affecting C18:0 proportions were identified on LG3, LG11, and LG13, with all the alleles for increased C18:0 proportions inherited from CAS-20. In total, these QTL explained 43.6% of the total phenotypic variance of C18:0 and have been attributed to the segregation of the Es2 locus. Furthermore, four candidate genes (two stearate desaturase genes, SAD6 and SAD17, FAT A and FAT B thioesterase genes) involved in C18:0 biosynthesis and an oleate-desaturase (OLD)-like gene were mapped in this study. Based on the positional information, it was suggested that the QTL on LG11 was a SAD6 locus. The results showed that the increased C18:0 proportions in sunflower seed oil are a complex trait, and the markers flanking these QTL constitute a powerful tool for plant breeding programs.

In another study (Pérez-Vich et al. 2006), the molecular nature of the high stearic acid mutant (CAS-14) line (>35% vs. <6% in currently grown sunflower hybrids) which is controlled by the Es3 gene was investigated. However, the expression of the high stearic acid trait in CAS-14 is strongly influenced by temperature during seed maturation. Two F2 mapping populations were developed from crosses between CAS-14 and P21, a nuclear male sterile line with the Ms11 gene controlling this trait, and between CAS-14 and CAS-3. One hundred thirty-three individuals from P21 × CAS-14 and 164 individuals from CAS-3 × CAS-14 were phenotyped for fatty acid composition using gas-liquid chromatography from the F2 and F3 generations, and they were then genotyped with SSR and insertion-deletion markers. Bulk segregant analysis in the P21 × CAS-14 population identified two markers on LG 8 putatively linked to Es3. Es3 mapped to the distal half of LG8 and was flanked by the SSR markers ORS243 and ORS1161 at genetic distances of 0.5 and 3.9 cM. The Ms11 gene was also mapped to LG8 and the genetic distance between this gene and Es3 was found to be 7.4 cM. In the CAS-3 × CAS-14 population, two QTLs were identified on LG1 and LG8, which underlie the Es1 gene from CAS-3 and the Es3 gene from CAS-14. A significant epistatic interaction between these two QTLs was found. Results from this study provided a basis for determining CAS-14 breeding strategies.

The selection for QTLs using genetic markers can be effective if a significant association is found between the quantitative trait and the genetic markers and these associations can be used to develop improved lines or populations (MAS). QTL regions obtained from one population can later be introgressed into other varieties, which may be more suited for specific environments (Dudley 1993).

4 Uses

Increased levels of C18:0 have an additional advantage over other saturated FAs because of its neutral effect on serum lipoprotein cholesterol (Pearson 1994). Individual saturated FAs like lauric (C12:0), myristic (C14:0) and palmitic (C16:0) acids increase LDL (bad) cholesterol whereas stearic (C18:0) acid has no effect (FAO 2010).

At present, stearic acid is the only option for making safe solid fats (Crupkin and Zambelli 2008; Valenzuela et al. 2011). Increasing saturated FAs produces oil that can be used in food and cosmetic products by decreasing the need for substantial amounts of hydrogenation (Fernández-Martínez et al. 2007). The manufacture of margarine and other specialty products requires solid or semi-solid fats, but standard sunflower oil, comprising primarily of unsaturated FAs, is liquid at room temperature. Hence, prior to its utilization in the food industry usually chemical hardening to change to a solid or semi-solid state, generally by hydrogenation or transesterification is needed. However, trans-fatty acids produced during these processes are harmful and related to heart diseases (Ascherio and Willett 1997). Hence, increased levels of saturated fats are desirable for the margarine and other related industries for the development of solid or semi-solid fats with the purpose of avoiding harmful chemical processes like hydrogenation or transesterification (Ascherio and Willett 1997; Kritchevsky et al. 1995).

5 Potential of the crop

As an annual crop of HSHO oil, Nutrisun has the potential of becoming the best competitive source of natural stearic acid. The production of a natural sunflower oil with relatively high stearic (18%) and oleic (70%) acid proportions not only serves the purpose of avoiding the hydrogenation process and the use of oils with unhealthy saturated fats (myristic, lauric, palmitic) as the proportions of palmitic acid is low (4%), but gives more oxidative stability to the sunflower oil. Its higher oxidative stability due to the low content(<4%) of polyunsaturated fatty acids increases shelf life and yields and provides trans-free alternative for industrial frying processes, and the neutral taste does not affect the taste of food cooked in it. Regular sunflower oil is a liquid at temperatures >−10 °C while HSHO begins to have solid fat at temperatures <15 °C. Stearic acid is the only saturated fatty acid that does not affect the plasmatic levels of LDL (bad) and HDL (good) cholesterol. Foods that are high in stearic acid, such as dark chocolate and shea nut oil, need not be considered as harmful as foods high in other saturated fatty acids or trans fatty acids. Furthermore, limiting the energy from the cholesterol-raising fats to less than 5 to 7% will help to maintain blood cholesterol at desirable concentrations.

The presence of high proportions of stearic acid allows the use of HSHO sunflower oil or its derived products (oleins and stearins) from the fractional crystallization process (Bootello et al. 2011) in applications requiring solid fats instead of trans or other saturated fats: for example, in margarines, toppings and fillings, fried snacks, confectionery coatings, and for bread products in the bakery (Dubinsky and Garces Mancheño 2011). The oil stability index of Nutrisun at 110 °C is 1.6 and six times greater than high-oleic and regular sunflower oil (Fig. 6). Thus, HSHO sunflower oil offers the possibility of replacing the use of partially hydrogenated oils, eliminating trans fats and maintaining the same oxidative stability. HSHO sunflower oil began to be marketed in 2008 for tests in the food industry, mainly in industrial frying. Those tests showed significant improvements in terms of performance, stability, quality, and functionality and produced food with an organoleptic profile completely acceptable to consumers.

Fig. 6
figure 6

Comparison of the oxidative stability index (OSI) values of high-stearic-high-oleic (HSHO) sunflower oil with other commercial oils shows that the OSI of HSHO is high, indicating significant improvements in performance, stability, quality, and functionality, and the possibility of replacing the use of partially hydrogenated oils and eliminating trans fats while maintaining the same oxidative stability. Adapted from Dubinsky and Garces Mancheño (2011)

The “know-how” of the farmers in producing sunflower crops and their ability to produce two types of sunflowers (conventional and oleic) through separate organization will enable them to grow stearic sunflower on a larger scale across the world in future. Since Nutrisun HSHO is a natural product obtained from sunflower seeds using the most advanced technology, it can be produced in similar conditions across the globe ensuring the availability of the product in both the hemispheres. Agronomic characteristics and effects of abiotic stress on the fatty acid profiles will need to be considered.

6 Conclusion

The problems and challenges of global climate change due to release of greenhouse gases from burning forests, peatland swamps, and draining of peatlands for palm oil cultivation, loss of biodiversity due to loss of natural habitat, suggest that we are in urgent need of an alternate sustainable, healthier stearate sunflower oil. Methods and technology developed for producing HSHO sunflower oil and the availability of mutants with high stearic acid content will be very useful to develop sunflower oil with higher proportion of stearic acid and provide a healthy and stable substitute to palm oil. The high-stearic sunflower oil will help fight cardiovascular diseases and bring health benefits to the consumers by the progressive replacement of hydrogenated and trans-fat-rich oils in human food. It will provide stable, healthy, and solid cooking oils. The high-stearic-high-oleic sunflower seeds produced by Advanta seeds can be obtained by conventional breeding techniques (non-GMO) and are similar to conventional sunflower. Hence, in the near future, it will be possible to develop a greater variety and quantity of healthy high-stearic sunflower oil.