Abstract
In this study, the fabrication and characterization of capacitive humidity sensors using cobalt-phthalocyanine (CoPc) as the active material were presented. Thin films of CoPc were deposited by drop casting on glass substrates with pre-deposited aluminum electrodes to form Al/CoPc/Al surface-type humidity sensors. The effect of humidity on the electrical properties of the CoPc film was investigated by measuring capacitance and resistance of the samples at four different frequencies of the applied voltage. It was observed that the capacitance of the sensor increased while the resistance decreased with raising the relative humidity. It was also found that the values of capacitance and resistance decreased with increasing frequency. The optical absorption spectra and optical band gap energy of CoPc films were measured. The structure of CoPc powder and thin films has been studied by X-ray diffraction (XRD), scanning electron microscopy (SEM), and atomic force microscopy (AFM). Results of XRD studies show that the film structure is polycrystalline with the monoclinic structure while thin films have a peak for annealing temperatures with (100) orientation. Also, the surface morphology (grain size and roughness) for CoPc films have been studied by AFM.
Article PDF
Similar content being viewed by others
References
Q. Weng and S. Yang, “Urban air pollution patterns, land use, and thermal landscape: an examination of the linkage using GIS,” Environ Monit Assess, 2006, 117(1–3): 463–489.
Y. Anjaneyulu, I. Jayakumar, V. H. Bindu, P. V. M. Rao, G. Sagareswar, K. V. Ramani, et al., “Real-time remote monitoring of air pollutants and their online transmission to the web using internet protocol,” Environ Monit Assess, 2007, 124(1–3): 371–381.
A. Joyce, J. Adamson, B. Huntley, T. Parr, and R. Baxter, “Standardisation of temperature observed by automatic weather stations,” Environ Monit Assess, 2001, 68(2): 127–136.
Z. M. Rittersma, “Recent achievements in miniaturised humidity sensors — a review of transduction techniques,” Sensors and Actuators A: Physical, 2002, 96(2–3): 196–210.
C. Y. Lee and G. B. Lee, “Humidity sensors: a review,” Sensor Letters, 2005, 3(1–4): 1–15.
Z. Chen and C. Lu, “Humidity sensors: a review of materials and mechanisms,” Sensor Letters, 2005, 3(4): 274–259.
F. Aziz, M. Sayyad, K. S. Karimov, M. Saleem, Z. Ahmad, and S. M. Khan, “Characterization of vanadyl phthalocyanine based surface-type capacitive humidity sensors,” Journal of Semiconductors, 2010, 31(11): 114002.
G. Liang, T. Cui, and K. Varahramyan, “Electrical characteristics of diodes fabricated with organic semiconductors,” Microelectronic Engineering, 2003, 65(3): 279–284.
M. Irimia-Vladu, N. Marjanovic, M. Bodea, G. Hernandez-Sosad, A. M. Ramil, R. Schwödiauer, et al., “Small-molecule vacuum processedmelamine — C60, organic field-effect transistors,” Organic Electronics, 2009, 10(3): 408–415.
G. Garcia-Belmonte, P. P. Boix, J. Bisquert, M. Sessolo, and H. J. Bolink, “Simultaneous determination of carrierlifetime and electron density-of-states in P3HT: PCBM organic solar cells under illumination by impedance spectroscopy,” Solar Energy Materials and Solar Cells, 2010, 94(2): 366–375.
I. Ling and L. Chen, “Organic light-emitting diode performance enhancement via indium tin oxide glass surface modification,” Current Applied Physics, 2010, 10(1): 346–350.
I. Muzikante, V. Parra, R. Dobulans, E. Fonavs, J. Latvels, and M. Bouvet, “A novel gas sensor transducer based on phthalocyanine heterojunction devices,” Sensors, 2007, 7(11): 2984–2996.
P. J. Kivits, R. D. Bont, and J. V. D. Veen, “Vanadyl phthalocyanine: an organic material for optical data recording,” Applied Physics A, 1981, 26(2): 101–105.
A. N. Burgess, K. E. Evans, M. Mackay, and S. J. Abbott, “Comparison of transient thermal conduction in tellurium and organic dye based digital optical storage media,” Journal of Applied Physics, 1987, 61(1): 74–80.
B. Joseph and C. Menon, “Studies on the optical properties and surface morphology of cobalt phthalocyanine thin films,” E-Journal of Chemistry, 2008, 5(1): 86–92.
F. Gutman and L. Lyons, Organic semiconductors. Malabar, Florida: Krieger Publishing Company, 1981.
O. A. Hamadi, “Characteristics of CdO-Si heterostructure produced by plasma-induced bonding technique,” Proc. IMechE PartL: J. Materials: Design and Applications, 2008, 222,L1: 65–71.
O. A. Hammadi, “Photovoltaic properties of thermally-grown Se-doped silicon photodiodes for infrared detection applications,” Photonic Sensors, 2015, 5,2: 152–158.
M. Shah, M. H. Sayyad, and K. S. Karimov, “Fabrication and study of nickel phthalocyanine based surface type capacitive sensors,” World Academy of Science, Engineering and Technology, 2008, 43: 392–394.
Author information
Authors and Affiliations
Corresponding author
Additional information
This article is published with open access at Springerlink.com
Rights and permissions
Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (https://creativecommons.org/licenses/by/4.0), which permits use, duplication, adaptation, distribution, and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made.
About this article
Cite this article
Hussein, M.T., Naji, I.S., Abdulameer, A.F. et al. Capacitive-resistive measurements of cobalt-phthalocyanine organic humidity sensors. Photonic Sens 5, 257–262 (2015). https://doi.org/10.1007/s13320-015-0257-9
Received:
Revised:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13320-015-0257-9