Abstract
The objective of the current study is to perform a careful investigation of the (Fe) and (W) solvus and of the intermetallic compounds in the Fe-W system as it could have a significant impact on higher-order systems based on this binary system. Two key alloys, Fe-14 at. pct W and Fe-50 at. pct W, and a diffusion couple were synthesized based on the literature. They were studied by long time annealing experiments with a selected heat treatment route, X-Ray diffraction analysis, and electron microprobe analysis with a careful control of impurity levels of C, Si, and O. The two intermetallic phases μ-Fe7W6 and λ-Fe2W are characterized and the composition range of the μ-Fe7W6 phase is specified. The phase previously reported as FeW is most probably a ternary carbide with low carbon content. An accurate determination of the solubility of W in αFe and of Fe in αW is presented.
Similar content being viewed by others
References
W. P. Sykes and K. R. Van Horn: Trans. AIME, 1933, vol. 105, pp. 198-214.
G. V. Raynor and V. G. Rivlin: Int. Metals Reviews, 1981, vol. 4, pp. 213-249.
S.V. Nagender Naidu, A.M. Sriramamurthy, and P. Rama Rao: Phase Diagrams of Binary Tungsten Alloys, Indian Institute of Metals, Calcutta, 1998, pp. 89–101.
E. T. Henig, H. Hofmann, G. Petzow (1981) In: HM Ortner (ed) Plansee seminar. Metallwerk Plansee, Reutte, pp. 335-359
H. Hofmann: Diplomarbeit, TU Berlin, 1980.
H. Hofmann: Dissertation Thesis, TU Berlin, 1983.
C. S. Smith: J. Appl. Phys, 1941, vol. 12, pp. 817-822.
E. P. Abrahamson II and S.L. Lopata: Trans. AIME, 1966, vol. 236, pp. 76-87.
E. P. Sinha and W. Hume-Rothery: J. Iron and Steel Inst., 1967, vol. 205, pp. 1145-1149.
G. Kirchner, H. Harvig and B. Uhrenius: Metall. Trans., 1973, vol. 4, pp. 1059-1067.
T. Takayama, M. Y. Wey and T. Nishizawa: Trans. Jpn Inst. Met, 1981, vol. 22, pp. 315-325.
P. Gustafson: Metall. Trans., 1987, vol. 18A, pp. 175-188.
P. Galimberti: PhD Thesis, Grenoble, INP, 2007.
G. V. Raynor and V. G. Rivlin: Int. Metals Reviews, 1983, vol. 28, pp. 122-129.
G. Kostakis: Z. Metallkde, 1985, vol. 76, pp. 34-36.
P.Y. Hou and J. Stringer: Oxid. Met., 1990, vol. 33, pp. 357-369.
R. Durham, B. Gleeson and D.J. Young: Mat. and corrosion, 1998, vol. 49, pp. 855-863.
W. P. Sykes: Trans. AIME, 1926, vol. 73, pp. 968-1008.
E.P. Chartkoff and W. P. Sykes: Trans. AIME, 1930, vol. 89, pp. 566-573.
W. P. Sykes: Metals Handbook, ASM, 1948, Cleveland, OH, pp. 1220.
R. Cury, J.-M. Joubert, S. Tusseau-Nenez, E. Leroy, A. Allavena-Valette : Intermetallics, 2009, vol. 17, pp. 174-178.
B. C. Muddle: Metall. Trans. A, 1984, vol. 15A, pp. 1089-1098.
J. B. Posthill and D. V. Edmonds: Metall. Trans. A, 1986, vol. 17A, pp. 1921-1934.
J.-M. Joubert, N. Dupin: Intermetallics, 2004, vol. 12, pp. 1373-1380.
W. P. Sykes: Trans. ASM, 1936, vol. 24, pp. 541-550.
Author information
Authors and Affiliations
Corresponding author
Additional information
Manuscript submitted August 3, 2012.
Rights and permissions
About this article
Cite this article
Antoni-Zdziobek, A., Commeau, T. & Joubert, JM. Partial Redetermination of the Fe-W Phase Diagram. Metall Mater Trans A 44, 2996–3003 (2013). https://doi.org/10.1007/s11661-013-1658-2
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11661-013-1658-2