Skip to main content

Advertisement

SpringerLink
Log in

Experimental Study of Formation Damage Caused by Complete Water Vaporization and Salt Precipitation in Sandstone Reservoirs

  • Published:
Transport in Porous Media Aims and scope Submit manuscript

Abstract

Vaporization of water during both gas reservoir development and \(\hbox {CO}_2\) geological sequestration in saline formations can cause salt precipitation with rapid loss of formation porosity and permeability. In this work, laboratory experiments were conducted to evaluate the effects of complete formation water evaporation and salt precipitation on the physical properties of sandstone samples by analyzing the decreases in both core porosity and permeability and the changes of pore distribution after salt precipitation using capillary flow porometry. Experimental results indicated that porosity can be decreased by 14.6 % and permeability can be decreased by 83.3 % due to salt precipitation under the experimental condition (100 \(^{\circ }\hbox {C}\) and 0.101 MPa). The higher the salinity and lower the initial formation permeability, the greater is the decrease in permeability. The permeability reduction can be approximated with a power-law relationship to the porosity reduction. Sodium chloride (NaCl) was the major precipitated salt crystal. The precipitated salt will cause small pores to be blocked, which leads to reduced total pore volume and total effective pore volume. The experimental results also suggested that the impact of salt precipitation on pores with smaller diameter was found to be greater than on those with larger diameter.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12
Fig. 13

Similar content being viewed by others

References

  • Andreb, L., Peyssona, Y., Azaroualb, M.: Well injectivity during \({\rm CO}_{2}\) storage operation in deep saline aquifers-Part 2: numerical simulations of drying, salt deposit mechanisms and role of capillary forces. Int. J. Greenh. Gas Control 22, 301–312 (2014)

    Article  Google Scholar 

  • Alkan, H., Cinar, Y., Ülker, E.B.: Impact of capillary pressure, salinity and in situ conditions on \({\rm CO}_{2}\) injection into saline aquifers. Transp. Porous Media 84, 799–819 (2010)

    Article  Google Scholar 

  • Bacci, G., Korre, A., Durucan, S.: Experimental investigation into salt precipitation during \({\rm CO}_{2}\) injection in Saline Aquifers. Energy Procedia 4, 4450–4456 (2011)

    Article  Google Scholar 

  • Giorgis, T., Carpita, M., Battistelli, A.: 2D modeling of salt precipitation during the injection of dry \({\rm CO}_{2}\) in a depleted gas reservoir. Energy Convers. Manag. 48, 1816–1826 (2007)

    Article  Google Scholar 

  • Golghanddashti, H., Saadat, M., Abbasi, S., Shahrabadi, A.: Experimental investigation of water vaporization and its induced formation damage associated with underground gas storage. J. Porous Media 16(2), 89–96 (2013)

    Article  Google Scholar 

  • Grattoni, C., Guise, P., Phillips, G., Fisher, Q., Knipe, R.: Evaluation of water evaporation and salt precipitation due to flow in gas reservoirs. SCA2009-14 (2009)

  • Halisch, M., Vogt, E., Muller, C., et al.: Capillary flow porometry-assessment of an alternative method for the determination of flow relevant parameters of porous rocks. SCA2013-007 (2013)

  • Izgec, O., Demiral, B., Bertin, H., Akin, S.: \({\rm CO}_2\) injection into saline carbon aquifer formations I: laboratory investigation. Transp. Porous Med 72, 1–24 (2008)

    Article  Google Scholar 

  • Jena, A., Gupta, K.: Advances in pore structure evaluation by porometry. Chem. Eng. Technol. 33(8), 1241–1250 (2010)

  • Kleinitz, W., Koehler, M., Dietzsch, G.: The precipitation of salt in gas producing wells. SPE 68953 (2001)

  • Kim, K.Y., Han, W.S., Oh, J., Kim, T., Kim, J.C.: Characteristics of salt-precipitation and the associated pressure build-up during \({\rm CO}_{2}\) storage in saline aquifers. Transp. Porous Med 92, 397–418 (2012)

    Article  Google Scholar 

  • Pange, M.K.R., Ziauddin, M.: Two-scale continuum model for simulation of wormhole in carbonate acidization. AIChEJ 51(12), 3231–3248 (2005)

    Article  Google Scholar 

  • Peyssona, Y., Andréb, L., Azaroualb, M.: Well injectivity during \({\rm CO}_{2}\) storage operations in deep saline aquifers-Part 1: experimental investigation of drying effects, salt precipitation and capillary forces. Int. J. Greenh. Gas Control 22, 291–300 (2014)

    Article  Google Scholar 

  • Peysson, Y., Bazin, B., Kohler, M.E., Youssef, S.: Permeability alteration due to salt precipitation by drying in the context of \({\rm CO}_{2}\) injection. Energy Procedia 4, 4387–4394 (2011)

    Article  Google Scholar 

  • Pruess, K., Müller, N.: Formation dry-out from CO2 injection into saline aquifers: 1. Effects of solids precipitation and their mitigation. Water Resour. Res. 45 (2009)

  • Tang, R., Etzion, Y.: Comparative studies on the water evaporation rate from a wetted surface and that from a free water surface. Build. Environ. 39(1), 77–86 (2004)

    Article  Google Scholar 

  • Tambach, T.J., Loevem, D., Hofstee, C., Plug, W.J., Maas, J.G.: Effect of \({\rm CO}_{2}\) injection on brine flow and salt precipitation after gas field production. Transp. Porous Med (2014). doi:10.1007/s11242-014-0283-x

  • Tsypkin, G.G.: Salt precipitation during solution evaporation in low-permeability rocks. Fluid Dyn. 44(5), 733–739 (2009)

    Article  Google Scholar 

  • Vanorio, T., Nur, A., Ebert, Y.: Rock physical analysis and time-lapse rock imaging of geochemical effects due to the injection of \({\rm CO}_{2}\) into reservoir rocks. Geophysics 76(5), 023–033 (2011)

  • Van Dorp, Q.T., Slijkhuis, M., Zitha, P.L.J.: Salt precipitation in gas reservoirs. SPE 122140 (2009)

  • Wang, Y., Mackie, E., Rohan, J. et al.: Experimental study on halite precipitation during \({\rm CO}_{2}\) sequestration. SCA2009-25 (2009)

  • Wang, Y., Luce, T., Ishizawa, C., et al.: Halite precipitation and permeability assessment during supercritical \({\rm CO}_{2}\) core flood. SCA2010-18 (2010)

  • Wei, B.H., Zhang, T.G., Liu, X.N., et al.: SY/T5162-1997. Analytical method of rock sample by scanning electron microscope. The Oil and Gas Industry Standard of the People’s Republic of China. (1997) (Chinese)

  • Zeidouni, M., Darvish, M.P., Keith, D.: Analytical solution to evaluate salt precipitation during \({\rm CO}_{2}\) injection in saline aquifers. Int. J. Greenh. Gas Control 3, 600–611 (2009)

    Article  Google Scholar 

  • Zuluage, E., Monsalve, J.C.: Water vaporization in gas reservoirs. SPE 84829 (2003), http://dx.doi.org/10.2118/84829-MS

Download references

Acknowledgments

This work was supported by the Major State Basic Research Development Program of China (2014CB239205), the National Natural Science Foundation of China (51274173), and the National Science and Technology Major Project (2011ZX05016-006).

Author information

Authors and Affiliations

  1. The State Key Laboratory of Oil & Gas Reservoir Geology and Exploitation Engineering, Southwest Petroleum University, Chengdu, 610500, China

    Yong Tang, Ruizhi Yang & Zhimin Du

  2. Faculty of Engineering and Applied Science, University of Regina, Regina, SK, S4S 0A2, Canada

    Fanhua Zeng

Authors
  1. Yong Tang
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Ruizhi Yang
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Zhimin Du
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Fanhua Zeng
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Yong Tang.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Tang, Y., Yang, R., Du, Z. et al. Experimental Study of Formation Damage Caused by Complete Water Vaporization and Salt Precipitation in Sandstone Reservoirs. Transp Porous Med 107, 205–218 (2015). https://doi.org/10.1007/s11242-014-0433-1

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11242-014-0433-1

Keywords

Search

Navigation