Abstract
The series of adducts of magnesium beta-diketonates with diamimes namely Mg(thd)2(tmeda) 1 and four new complexes Mg(thd)2(tmpda) 2, Mg(thd)2(pda) 3, Mg(ptac)2(tmeda) 4, Mg(tfac)2(tmeda) 5 [beta-diketonates = R1C(O)CHC(O)R2: thd (R1 = R2 = tBu), ptac (R1 = tBu, R2 = CF3), tfac (R1 = Me, R2 = CF3); diamines = R2N(CH2) n NR2: tmeda (n = 2, R = Me), tmpda (n = 3, R = Me), pda (n = 3, R = H)] were synthesized in order to investigate the influence of both ligand types on the thermochemical properties of these compounds. The thermal behavior of the complexes in the condensed phase was investigated by thermogravimetry and differential scanning calorimetry; the thermodynamic parameters of phase transitions were determined. The saturated vapor pressure of solid complexes Mg(thd)2(tmeda) and Mg(tfac)2(tmeda) were measured by the transmission method giving the enthalpies and entropies of sublimation processes. The reliable thermodynamic data for compound Mg(thd)2(tmeda) were obtained with the assistance of X-ray diffraction and the static method of saturated and unsaturated vapor pressure measurements.
Similar content being viewed by others
References
Vallet-Regi M, Labeau M, Garcia E, Cabanas MV, González-Calbet JM, Delabouglise G. Thin films of magnesium oxide by modified CVD: a buffer layer for HTCS films. Physica C. 1991;180:57–60.
Boo JH, Lee SB, Yu KS, Koh W, Kim Y. Growth of magnesium oxide thin films using single molecular precursors by metal–organic chemical vapor deposition. Thin Solid Films. 1999;341:63–7.
Wang L, Yang Y, Ni J, Stern CL, Marks TJ. Synthesis and characterization of low-melting, highly volatile magnesium MOCVD precursors and their implementation in MgO thin film growth. Chem Mater. 2005;17:5697–704.
Raj AME, Jayachandran M, Sanjeeviraja C. Fabrication techniques and material properties of dielectric MgO thin films—a status review. CIRP J Manuf Sci Technol. 2010;2:92–113.
Huang R, Kitai AH. Temperature dependence of the growth orientation of atomic layer growth MgO. Appl Phys Lett. 1992;61:1450–2.
Sung MM, Kim C, Kim CG, Kim Y. Epitaxial growth of MgO films on Si (111) by metal organic chemical vapor deposition. J Cryst Growth. 2000;210:651–4.
Davies HO, Jones AC, Leedham TJ, Crosbie MJ, Wright PJ, Boag NM, Thompson JR. Synthesis and structural characterization of a novel magnesium β-diketonatoalkoxide complex: a new precursor for the MOCVD of MgO. Chem Vap Depos. 2000;2000(6):71–5.
Putkonen M, Johansson LS, Rauhala E, Niinistö L. Surface-controlled growth of magnesium oxide thin films by atomic layer epitaxy. J Mater Chem. 1999;9:2449–52.
Matthews JS, Just O, Obi-Johnson B, Rees WS. CVD of MgO from a Mg(β-ketoiminate)2: preparation, characterization, and utilization of an intramolecularly stabilized, highly volatile, thermally robust precursor. Chem Vap Depos. 2000;6:129–32.
Hill MR, Jones AW, Russell JJ, Roberts NK, Lamb RN. Dialkylcarbamato magnesium cluster complexes: precursors to the single-source chemical vapour deposition of high quality MgO thin films. J Mater Chem. 2004;14:3198–202.
Putkonen M, Sajavaara T, Niinistö L. Enhanced growth rate in atomic layer epitaxy deposition of magnesium oxide thin films. J Mater Chem. 2000;10:1857–61.
Carta G, El Habra N, Crociani L, Rossetto G, Zanella P, Zanella A, Paolicci G, Barreca D, Tondello E. CVD of MgO thin films from bis(methylcyclopentadienyl)magnesium. Chem Vap Depos. 2007;13:185–9.
Babcock JR, Benson DD, Wang A, Edleman NL, Belot JA, Metz MV, Marks TJ. Polydentate amines as CVD precursor ancillary ligands. Epitaxial MgO thin-film growth using a highly volatile, thermally and air-stable magnesium precursor. Chem Vap Depos. 2000;6:180–3.
Carta G, El Habra N, Rossetto G, Zanella P, Casarin M, Barreca D, Maragno G, Tondello E. MgO and CaO stabilized ZrO2 thin films obtained by metal organic chemical vapor deposition. Surf Coat Technol. 2007;201:9289–93.
Hatanpää T, Kansikas J, Mutikainen I, Leskelä M. Ancillary ligand effect on the properties of “Mg(thd)2” and crystal structures of [Mg(thd)2(ethylenediamine)]2,[Mg(thd)2(tmeda)], and [Mg(thd)2(trien)]. Inorg Chem. 2001;40:788–94.
Catalano MR, Malandrino G. Multifunctional manganese single source precursor for the selective deposition of MnF2 or Mn3O4. Phys Procedia. 2013;46:118–26.
Maria M, Selvakumar J, Raghunathan VS, Mathews T, Nagaraja KS. Temperature dependence vapour pressure measurements of Mg(tmhd)2(tmeda) [(tmhd = 2,2,6,6-tetramethyl-3,5-heptanedione, tmeda = N,N,N′,N′-tetramethylethylenediamine]. Thermochim Acta. 2008;474:87–90.
Morozova NB, Zharkova GI, Stabnikov PA, et al. Synthesis and physicochemical study of b-diketonates of alkaline earth metals [in Russian]. Novosibirsk; 1989 (Preprint, Institute of Inorganic Chemistry, Siberian Branch, USSR Academy of Sciences, N 89-08).
Fadeeva VP, Tikhova VD, Nikulicheva ON. Elemental analysis of organic compounds with the use of automated CHNS analyzers. J Anal Chem. 2008;63:1094–106.
Fadeeva VP, Tikhova VD, Nikulicheva ON, Oleynik II, Oleynik IV. Composition determination of post-metallocene olefin polymerization catalysts. J Struct Chem. 2010;51:S186–91.
Nakamoto K. Infrared and Raman spectra of inorganic and organic compounds. New York: Wiley; 1997.
Basova TV, Kiselev VG, Filatov ES, Sheludyakova LA, Igumenov IK. Experimental and theoretical study of vibrational spectra of palladium(II) β-diketonates. Vib Spectrosc. 2012;61:219–25.
Kubaschewski O, Evans EL. Metallurgical thermochemistry. London: Pergamon Press; 1951.
Morozova NB, Zharkova GI, Semyannikov PP, Sysoev SV, Igumenov IK, Fedotova NE, Gelfond NV. Vapor pressure of precursors for CVD on the base of platinum group metals. J Phys IV. 2001;11:Pr3-609-616.
Zelenina LN, Titov VA, Chusova TP, Stenin YG, Titov AA. On the thermodynamic properties of germanium-iodide compounds. J Chem Thermodyn. 2003;35:1601–12.
Titov VA, Kokovin GA. In: Kokovin GA, editor. Mathematics in general thermodynamics. Novosibirsk: Nauka; 1980. p. 98–105.
Vikulova ES, Piryazev DA, Zherikova KV, Alferova NI, Morozova NB, Igumenov IK. Crystal structure of two complexes containing tris-(β-diketonato)magnate anion. J Struct Chem. 2013;54:883–9.
Sartori A, El Habra N, Bolzan M, Rossetto G, Sitran S, Barreca D, Gasparotto A, Casarin M. Stability study of a magnesium β-diketonate as precursor for chemical vapor deposition of MgO. Chem Mater. 2011;23:1113–9.
Igumenov IK, Basova TV, Belosludov VR. Volatile precursors for films deposition: vapor pressure, structure and thermodynamics. In: Mizutani T, editor. Application of thermodynamics to biological and material science. Rijeka: InTech; 2011. p. 521–46.
Morozova NB, Zherikova KV, Semyannikov PP, Trubin SV, Igumenov IK. Study of temperature dependencies of saturated vapor pressure of ruthenium(III) beta-diketonate derivatives. J Therm Anal Calorim. 2009;98:395–9.
Zherikova KV, Morozova NB, Zelenina LN, Sysoev SV, Chusova TP, Igumenov IK. Thermal properties of hafnium(IV) and zirconium(IV) β-diketonates. J Therm Anal Calorim. 2008;92:729–34.
Acknowledgements
The work was supported by RFBR grant № 12-03-31277 mol_a.
Author information
Authors and Affiliations
Corresponding author
Electronic supplementary material
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
Vikulova, E.S., Zherikova, K.V., Korolkov, I.V. et al. Thermal properties of mixed-ligand magnesium complexes with beta-diketonates and diamimes as potential MOCVD precursors. J Therm Anal Calorim 118, 849–856 (2014). https://doi.org/10.1007/s10973-014-3997-7
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10973-014-3997-7