Abstract
In the present study, ZnO and Al:ZnO (AZO) thin films were prepared by reactive RF sputtering on quartz substrates at a constant oxygen partial pressure and a typical sputtering power. Films were annealed at different temperatures in argon ambient in the oven to study their various structural and optical properties. It was understood that introducing Al into ZnO structure would affect the ZnO crystalline structure noticeably. It was observed that annealing had great influence on various properties of thin films while ZnO film showed low crystallinity, Al doping into ZnO structure pronounced significant improvement in both crystallinity and particle sizes. It was found that crystal structures, average crystalline sizes, and topology of all thin films were modified enormously by post-annealing. It was shown that films transparency fluctuated by annealing, in which the transparency of AZO thin film annealed at 500 °C was much greater than others. Annealing led to decrease optical band gap of all annealed films from 3.31 to 3.26 eV for ZnO and 4 to 3.4 eV for AZO films. Photoluminescence manifested that blue emission in as-deposited film led to two different blue and violet emissions in all AZO and ZnO films. It was identified that the emission intensity of AZO film annealed at 500 °C was 12 times more than other ZnO and AZO films.
Similar content being viewed by others
References
X.-H. Lu, D. Wang, G.-R. Li, C.-Y. Su, D.-B. Kuang, Y.-X. Tong, Controllable electrochemical synthesis of hierarchical ZnO nanostructures on FTO Glass. J. Phys. Chem. C 113, 13574–13582 (2009)
L. Zhang, K. Jin, S. Li, L. Wang, Y. Zhang, X. Li, Synthesis of flower-Like ZnO films and their photovoltaic properties for dye-sensitized solar cells. J. Electr. Mater. 44, 244–251 (2015)
K. Pradhan, R.M. Mundle, K. Santiago, J.R. Skuza, B. Xiao, K.D. Song, M. Bahoura, R. Cheaito, P.E. Hopkins, Extreme tunability in aluminum doped Zinc Oxide plasmonic materials for near-infrared applications, Sci. Rep. 4 (2014)
T. Minami, Y. Nishi, T. Miyata, Effect of the thin Ga2O3 layer in n + -ZnO/n-Ga2O3/p-Cu2O heterojunction solar cells. Thin Solid Films 549, 65–69 (2013)
H. Masui, S. Nakamura, S.P. DenBaars, U.K. Mishra, Nonpolar and semipolar iii-nitride light-emitting diodes: achievements and challenges. Electron Devices IEEE Trans. 57, 88–100 (2010)
X. Jiang, F.L. Wong, M.K. Fung, S.T. Lee, Aluminum-doped zinc oxide films as transparent conductive electrode for organic light-emitting devices. Appl. Phys. Lett. 83, 1875–1877 (2003)
L. Chow, O. Lupan, G. Chai, H. Khallaf, L.K. Ono, B. Roldan Cuenya, I.M. Tiginyanu, V.V. Ursaki, V. Sontea, A. Schulte, Synthesis and characterization of Cu-doped ZnO one-dimensional structures for miniaturized sensor applications with faster response. Sens. Actuators A 189, 399–408 (2013)
W. Li, J. Chen, H. Cui, F. Liu, X. Hao, Inhibiting MoS2 formation by introducing a ZnO intermediate layer for Cu2ZnSnS4 solar cells. Mater. Lett. 130, 87–90 (2014)
P. Yang, H. Yan, S. Mao, R. Russo, J. Johnson, R. Saykally, N. Morris, J. Pham, R. He, J.H. Choi, Controlled growth of ZnO nanowires and their optical properties. Adv. Funct. Mater. 12, 323 (2002)
S. Sadjadi, M. Eskandari, Ultrasonic assisted synthesis of imidazo[1,2-a]azine catalyzed by ZnO nanorods. Ultrason. Sonochem. 20, 640–643 (2013)
Z. Zang, M. Wen, W. Chen, Y. Zeng, Z. Zu, X. Zeng, X. Tang, Strong yellow emission of ZnO hollow nanospheres fabricated using polystyrene spheres as templates. Mater. Des. 84, 418–421 (2015)
Z. Zang, X. Tang, Enhanced fluorescence imaging performance of hydrophobic colloidal ZnO nanoparticles by a facile method 619, 98–101 (2015)
Y. Sun, D.J. Riley, M.N.R. Ashfold, Mechanism of ZnO nanotube growth by hydrothermal methods on ZnO film-coated Si substrates. J. Phys. Chem. B 110, 15186–15192 (2006)
S. Ţălu, S. Stach, S. Solaymani, R. Moradian, A. Ghaderi, M.R. Hantehzadeh, S.M. Elahi, Ż. Garczyk, S. Izadyar, Multifractal spectra of atomic force microscope images of Cu/Fe nanoparticles based films thickness. J. Electroanal. Chem. 749, 31–41 (2015)
S. Ţălu, S. Stach, T. Ghodselahi, S. Solaymani, A. Ghaderi, A. Boochani, Ż. Garczyk, Topographic characterization of Cu–Ni NPs @ a-C: H films by AFM and multifractal analysis. J Phys. Chem. B 119(17), 5662–5670 (2015)
S.T. Tan, B.J. Chen, X.W. Sun, W.J. Fan, H.S. Kwok, X.H. Zhang, S.J. Chua, Blueshift of optical band gap in ZnO thin films grown by metal-organic chemical-vapor deposition, J. Appl. Phys. 98 (2005)
A. Ghaderi, S.M. Elahi, S. Solaymani, M. Naseri, M. Ahmadirad, S. Bahrami, A.E. Khalili, Thickness dependence of the structural and electrical properties of ZnO thermal-evaporated thin films. PRAMANA J. Phys 77(6), 1–8 (2011)
P. Jin, S. Nakao, S.X. Wang, L.M. Wang, Localized epitaxial growth of α-Al2O3 thin films on Cr2O3 template by sputter deposition at low substrate temperature. Appl. Phys. Lett. 82, 1024–1026 (2003)
T.L. Yang, D.H. Zhang, J. Ma, H.L. Ma, Y. Chen, Transparent conducting ZnO: Al films deposited on organic substrates deposited by r.f. magnetron-sputtering. Thin Solid Films 326, 60–62 (1998)
Y. Lin, J. Xie, H. Wang, Y. Li, C. Chavez, S. Lee, S.R. Foltyn, S.A. Crooker, A.K. Burrell, T.M. McCleskey, Q.X. Jia, Green luminescent zinc oxide films prepared by polymer-assisted deposition with rapid thermal process. Thin Solid Films 492, 101–104 (2005)
L.B. Duan, X.R. Zhao, J.M. Liu, W.C. Geng, H.Y. Xie, H.N. Sun, Effect of annealing ambient on the structural, optical and electrical properties of (Mg, Al)-codoped ZnO thin films. Phys. Scr. 85, 035709 (2012)
Z. Liang, X. Yu, B. Lei, P. Liu, W. Mai, Novel blue-violet photoluminescence from sputtered ZnO thin films. J. Alloy. Compd. 509, 5437–5440 (2011)
S. Cho, J. Ma, Y. Kim, Y. Sun, G.K.L. Wong, J.B. Ketterson, Photoluminescence and ultraviolet lasing of polycrystalline ZnO thin films prepared by the oxidation of the metallic Zn. Appl. Phys. Lett. 75, 2761–2763 (1999)
H. Chen, H.-J. Jin, C.-B. Park, Influence of hydrogen on Al-doped ZnO thin films in the process of deposition and annealing. Trans. Electr. Electron. Mater. 10, 93–96 (2009)
E.S. Shim, H.S. Kang, S.S. Pang, J.S. Kang, I. Yun, S.Y. Lee, Annealing effect on the structural and optical properties of ZnO thin film on InP. Mater. Sci. Eng. B 102, 366–369 (2003)
F.K. Shan, G.X. Liu, W.J. Lee, B.C. Shin, The role of oxygen vacancies in epitaxial-deposited ZnO thin films. J. Appl. Phys. 101, 053106 (2007)
B.D. Cuility, Elements of X-ray Diffraction (Addison-Wesley, Reading, Mass, 1959)
P. Chand, A. Gaur, A. Kumar, Structural, optical and ferroelectric behavior of CuO nanostructures synthesized at different pH values. Superlattices Microstruct. 60, 129–138 (2013)
H. Morkoç, U. Özgür, Zinc oxide fundamentals, materials and device technology (Wiley-VCH, Weinheim, 2009)
J.M. Yuk, J.W. Shin, J.Y. Lee, D.I. Son, J.H. Jung, T.W. Kim, J.Y. Kim, W.K. Choi, Effect of thermal annealing on the formation of preferential c-axis orientation and an interfacial layer for ZnO thin films grown on an n-Si (001) substrate. J. Korean Phys. Soc. 50, 4 (2007)
S. Salleh, M.N. Dalimin, H.N. Rutt, Structural and surface characterization of cold deposited zinc sulfide thin films, in 3rd International Conference on Solid State Science and Technology (ICSSST2010), Universiti Malaysia Sarawak, 2010
K.-S. Hwang, Y.-J. Lee, S. Hwangbo, Growth, structure and optical properties of amorphous or nano-crystalline ZnO thin films prepared by prefiring-final annealing. J. Ceram. Process. Res. 8, 7 (2007)
M. Fox, Optical properties of solids (OUP, Oxford, 2010)
J. Tauc, R. Grigorovici, A. Vancu, Optical properties and electronic structure of amorphous Germanium. Phys. Status Solidi 15, 627–637 (1966)
M.H. Cohen, H. Fritzsche, S.R. Ovshinsky, Simple band model for amorphous semiconducting alloys. Phys. Rev. Lett. 22, 1065–1068 (1969)
Y. Lin, J. Xie, H. Wang, Y. Li, C. Chavez, S. Lee, S.R. Foltyn, S.A. Crooker, A.K. Burrell, T.M. McCleskey, Q.X. Jia, Thin Solid Films 101, 492 (2005)
Sunglae Cho, Jing Ma, Yunki Kim, Yi Sun, G.K.L. George, J.B. Ketterson, Appl. Phys. Lett. 75, 2761 (1999)
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors report no conflict of interests. The authors alone are responsible for the content and writing of the paper.
Rights and permissions
About this article
Cite this article
Dejam, L., Mohammad Elahi, S., Nazari, H.H. et al. Structural and optical characterization of ZnO and AZO thin films: the influence of post-annealing. J Mater Sci: Mater Electron 27, 685–696 (2016). https://doi.org/10.1007/s10854-015-3804-7
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10854-015-3804-7