Abstract
In this paper, we examine the nonlinear dynamical responses of a microgyroscope consisting of a rotating microbeam made of nanocrystalline material with attached proof mass, subject to electric actuation, and operating at high frequency. The working principle of this inertial sensor is based on exploiting the transfer of the mechanical energy among two vibrations modes (drive and sense) via the Coriolis effect to measure the rotation rate. A nonlinear reduced-order model (ROM) governing the microbeam dynamics is developed by the application of the differential quadrature method and finite difference method for space and time discretization, respectively. The developed ROM is used to study the nonlinear behavior of the microbeam near the primary resonance for various grain sizes of the nanocrystalline material and under different electric actuation configurations. The operating DC voltage of the drive mode is selected to ensure that the microgyroscope operates away from the pull-in instability. A sensitivity analysis of the microsystem output parameter to the rotation rate when varying the material properties of the microbeam and electric actuation is then performed. The fringing field of the electrostatic force is found to reduce slightly the pull-in voltage and the natural frequency of the microsystem, amplify the motion in the sense direction, and enlarge the dynamic snap-through bandwidth. As for the effect of the material properties, considering a microbeam with bigger grain size of the constituent nanocrystalline silicon is observed to reduce the motion of the sense mode, increase the natural frequency, and shrink the snap-through bandwidth. Furthermore, operating at high base rotation rates while deploying microbeams with small nanocrystalline grain size is found to switch the dynamic behavior of the sense mode from the nearly-linear to the softening type. Finally, introducing bias in the DC voltage applied along the drive and sense directions is observed to degrade the performance of the electrically-actuated microgyroscope.
Similar content being viewed by others
References
Ayed SB, Abdelkefi A, Najar F, Hajj M (2014) Design and performance of variable-shaped piezoelectric energy harvesters. J Intell Mater Syst Struct 25:174–186
Bhadbhade V, Jalili N, Mahmoodi SN (2008) A novel piezoelectrically actuated flexural/torsional vibrating beam gyroscope. J Sound Vib 311:1305–1324
Duan H, Wang J, Huang Z, Karihaloo B (2005) Size-dependent effective elastic constants of solids containing nano-inhomogeneities with interface stress. J Mech Phys Solids 53:1574–1596
Esmaeili M, Jalili N, Durali M (2006) Dynamic modeling and performance evaluation of a vibrating beam microgyroscope under general support motion. J Sound Vib 301:146–164
Fitzsimmons M, Roll A, Burkel E, Sichafus K, Nastasi M, Smith G, Rynn R (1995) The magnetization of a grain boundary in nickel. Nanostruct Mater 6:539–542
Ghayesha MH, Farokhib H, Alici G (2016) Size-dependent performance of microgyroscopes. Int J Eng Sci 100:99–111
Ghommem M, Nayfeh A, Choura S, Najar F, Abdel-Rahman E (2010) Modeling and performance study of a beam microgyroscope. J Sound Vib 329:4970–4979
Ghommem M, Nayfeh A, Choura S (2013) Model reduction and analysis of a vibrating beam microgyroscope. J Vib Control 19:1240–1249
Gleiter H (2000) Nanostructured materials: basic concepts and microstructure. Acta Mater 48:1–29
Lajimi SAM, Heppler GR, Abdel-Rahman EM (2015) Primary resonance of a beam rigid body microgyroscope. Int J Non-Linear Mech 77:364–375
Lajimi SAM, Heppler GR, Abdel-Rahman EM (2017) A mechanical-thermal noise analysis of a nonlinear microgyroscope. Mech Syst Signal Process 83:163–175
Li Y, Fan S, Guo Z, Li J, Cao L (2012) Frequency measurement study of resonant vibratory gyroscopes. J Sound Vib 331:4417–4424
Mohr M, Caron A, Engel P, Bennewitz R, Gluche P, Brhne K, Fecht H (2014) Young’s modulus, fracture strength, and poisson’s ratio of nanocrystalline diamond films. J Appl Phys 116:124308
Mojahedi M, Ahmadian MT, Firoozbakhsh K (2013) Oscillatory behavior of an electrostatically actuated microcantilever gyroscope. Int J Struct Stab Dyn 13:1350030
Mojahedi M, Ahmadian MT, Firoozbakhsh K (2013) The oscillatory behavior, static and dynamic analyses of a micro/nano gyroscope considering geometric nonlinearities and intermolecular forces. Acta Mech Sin 29:851–863
Mojahedi M, Ahmadian MT, Firoozbakhsh K (2014) The influence of the intermolecular surface forces on the static deflection and pull-in instability of the micro/nano cantilever gyroscopes. Composites: Part B 56:336–343
Najar F, Choura S, El-Borgi S, Abdel-Rahman EM, Nayfeh AH (2005) Modeling and design of variable-geometry electrostatic microactuators. J Micromech Microeng 15:419–429
Najar F, Choura S, Abdel-Rahman EM, El-Borgi S, Nayfeh AH (2006) Dynamic analysis of variable-geometry electrostatic microactuators. J Micromech Microeng 16:2449–2457
Nayfeh A, Abdel-Rahman E, Ghommem M (2015) A novel differential frequency micro-gyroscope. J Vib Control 21:872–882
Rasekh M, Khadem S (2013) Design and performance analysis of a nanogyroscope based on electrostatic actuation and capacitive sensing. J Sound Vib 332:6155–6168
Sassen S, Voss R, Schalk J, Stenzel E, Gleissner T, Gruenberger R, Neubauer F, Ficker W, Kupke W, Bauer K, Rose M (2000) Tuning fork silicon angular rate sensor with enhanced performance for automative applications. Sens Actuators 83:80–86
Shaat M, Abdelkefi A (2015a) Modeling the material structure and couple stress effects of nanocrystalline silicon beams for pull-in and bio-mass sensing applications. Int J Mech Sci 101–102:280–291
Shaat M, Abdelkefi A (2015b) Pull-in instability of multi-phase nanocrystalline silicon beams under distributed electrostatic force. Int J Eng Sci 90:58–75
Shaat M, Abdelkefi A (2017) Material structure and size effects on the nonlinear dynamics of electrostatically-actuated nano-beams. Int J Non-Linear Mech 89:25–42
Shaat M, Khorshidi MA, Abdelkefi A, Shariati M (2016) Modeling and vibration characteristics of cracked nano-beams made of nanocrystalline materials. Int J Mech Sci 115–116:574–585
Wang G-F, Feng X-Q, Yu S-W, Nan C-W (2003) Interface effects on effective elastic moduli of nanocrystalline materials. Mater Sci Eng A 363:1–8
Williams CB, Shearwood C, Mellor PH, Mattingley AD, Gibbs MR, Yates RB (1996) Initial fabrication of a micro-induction gyroscope. Microelectron Eng 30:531–534
Yazdi N, Ayazi F, Najafi K (1996) Micromachined inertial sensors. IEEE 86:1640–1659
Younes MI (2011) MEMS linear and nonlinear statics and dynamics. Springer, Berlin
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Ghommem, M., Abdelkefi, A. Nonlinear analysis of rotating nanocrystalline silicon microbeams for microgyroscope applications. Microsyst Technol 23, 5931–5946 (2017). https://doi.org/10.1007/s00542-017-3366-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00542-017-3366-0