Abstract
Aircraft sensors are typically cable powered, imposing a significant weight overhead. The exploitation of temperature variations during flight by a phase change material (PCM) based heat storage thermoelectric energy harvester, as an alternative power source in aeronautical applications, has recently been flight tested. In this work, the applicability of this technology to use cases with smaller and larger size specifications is studied by fabrication, testing and analysis of a scaled-down and a scaled-up prototype. Output energy of 4.1 J/g of PCM from a typical flight cycle is demonstrated for the scaled-down device, and 2.3 J/g of PCM for the scaled-up device. The higher energy density of the scaled down prototypes is attributed to the reduction in temperature inhomogeneity inside the PCM. The impact of super-cooling on performance is analyzed by employing a simulation model extended to include super-cooling effects. It is found that super-cooling may be beneficial for scaling down, in applications with slow temperature fluctuations.
Similar content being viewed by others
References
Bailly N, Dilhac JM, Escriba C, Vanhecke C, Mauran N, Bafleur M (2008) Energy scavenging based on transient thermal gradients: application to structural health monitoring of aircrafts. In: 8th international workshop on micro and nanotechnology for power generation and energy conversion applications (PowerMEMS), Sendai, Japan, pp 205–208
Becker T, Elefsiniotis A, Kiziroglou ME (2015) Thermoelectric energy harvesting in aircraft. In: Briand D, Yeatman E, Roundy S (eds) Micro energy harvesting. Wiley, Weinheim, Germany. doi: 10.1002/9783527672943.ch20
Briand D, Yeatman E, Roundy S (2015) Micro enegy harvesting. Wiley. doi:10.1002/9783527672943
Elefsiniotis A, Samson D, Becker T, Schmid U (2013) Investigation of the performance of thermoelectric energy harvesters under real flight conditions. J Electron Mater 42:2301–2305. doi:10.1007/s11664-012-2411-0
Energizer Holdings Inc. (2016) EN91 AA alkaline battery datasheet, Form No. EBC - 1202N. http://data.energizer.com/PDFs/EN91.pdf. Accessed 2 Mar 2016
Glynne-Jones P, Tudor MJ, Beeby SP, White NM (2004) An electromagnetic, vibration-powered generator for intelligent sensor systems. Sens Actuators A 110:344–349
Kiziroglou M, Elefsiniotis A, Wright S, Toh T, Mitcheson P, Becker T, Yeatman E (2013) Performance of phase change materials for heat storage thermoelectric harvesting. Appl Phys Lett 103:193902
Kiziroglou ME, Wright SW, Toh TT, Mitcheson PD, Becker T, Yeatman EM (2014) Design and fabrication of heat storage thermoelectric harvesting devices. Ind Electron IEEE Trans 61:302–309. doi:10.1109/tie.2013.2257140
Mitcheson PD, Green TC, Yeatman EM, Holmes AS (2004) Architectures for vibration-driven micropower generators. Microelectromech Syst J 13:429–440
Panasonic (2016) Coin type lithium batteries (CR series). Panasonic. http://industrial.panasonic.com/ww/products/batteries/primary-batteries/lithium-batteries/coin-type-lithium-batteries-cr-series. Accessed 09 Feb 2016 2016
Papachristou AA, Kiziroglou ME, Petrou L, Koundouras S, Hatzopoulos AA (2013) Viability of thermoelectric energy harvesting for precision agriculture sensor nodes. In: Paper presented at the 8th Jordanian International Electrical and Electronics Engineering Conference, Amman, Jordan, 16–18 Apr
Samson D, Otterpohl T, Kluge M, Schmid U, Becker T (2010) Aircraft-specific thermoelectric generator module. J Electron Mater 39:2092–2095. doi:10.1007/s11664-009-0997-7
Shenck NS, Paradiso JA (2001) Energy scavenging with shoe-mounted piezoelectrics. IEEE Micro 21:30–42
Sodano HA, Inman DJ, Park G (2005) Comparison of piezoelectric energy harvesting devices for recharging batteries. J Intell Mater Syst Struct 16:799–807. doi:10.1177/1045389x05056681
Toh TT, Wright SW, Kiziroglou ME, Mitcheson PD, Yeatman EM (2014) A dual polarity, cold-starting interface circuit for heat storage energy harvesters. Sens Actuators A 211:38–44. doi:10.1016/j.sna.2014.02.037
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Kiziroglou, M.E., Elefsiniotis, A., Kokorakis, N. et al. Scaling and super-cooling in heat storage harvesting devices. Microsyst Technol 22, 1905–1914 (2016). https://doi.org/10.1007/s00542-016-2889-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00542-016-2889-0