Skip to main content
Log in

μPIV measurements of two-phase flows of an operated direct methanol fuel cell

Experiments in Fluids Aims and scope Submit manuscript

Abstract

In direct methanol fuel cells (DMFCs), two-phase flows appear in the channels of the anode side (CO2 bubbles in a liquid water–methanol environment) as well as of the cathode side (water droplets or films in an ambient air flow). CO2 bubbles or water droplets may almost completely fill the cross-section of a channel. The instantaneous effect of the formation of two-phase flows on the cell performance has not been investigated in detail, yet. In the current project, the micro particle image velocimetry (μPIV) technique is used to elucidate the corresponding flow phenomena on the anode as well as on the cathode side of a DMFC and to correlate those phenomena with the performance of the cell. A single-channel DMFC with optical access at the anode and the cathode side is constructed and assembled that allows for μPIV measurements at both sides as well as a detailed time-resolved cell voltage recording. The appearance and evolution of CO2 bubbles on the anode side is qualitatively and quantitatively investigated. The results clearly indicate that the cell power increases when the free cross-section area of the channel is decreased by huge bubbles. Methanol is forced into the porous gas diffusion layer (GDL) between the channels and the membrane is oxidized to CO2, and hence, the fuel consumption is increased and the cell performance rises. Eventually, a bubble forms a moving slug that effectively cleans the channel from CO2 bubbles on its way downstream. The blockage effect is eliminated; the methanol flow is not forced into the GDL anymore. The remaining amount of methanol in the GDL is oxidized. The cell power decreases until enough CO2 is produced to eventually form bubbles again and the process starts again. On the other hand under the investigated conditions, water on the cathode side only forms liquid films on the channels walls rather than channel-filling droplets. Instantaneous changes of the cell power due to liquid water formation could not be observed. The timescales of the two-phase flow on the cathode side are significantly larger than on the anode side. However, the μPIV measurements at the cathode side demonstrate the ability of feeding gas flows in microchannels with liquid tracer particles and the ability to measure in two-phase flows in such a configuration.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12
Fig. 13
Fig. 14
Fig. 15
Fig. 16

References

  • Argyropoulos P, Scott K, Taama W (1999) Carbon dioxide evolution patterns in direct methanol fuel cells. Electrochim Acta 4:3575–3584

    Article  Google Scholar 

  • Bazylak A (2009) Liquid water visualization in PEM fuel cells: a review. Int J Hydrogen Energy 34:3845–3857

    Article  Google Scholar 

  • Bazylak A, Sinton D, Djilali N (2008) Dynamic water transport and droplet emergence in PEMFC gas diffusion layers. J Power Sources 176:240–246

    Article  Google Scholar 

  • Blank M, Burgmann S, Wartmann J (2012) μPIV measurements of the CO2-bubble evolution in the anode flow of an operated direct methanol fuel cell, 16th international symposium on applications of laser techniques to fluid mechanics, Lisbon, Portugal, 09–12 July, 2012

  • Burgmann S, van der Schoot N, Asbach C, Wartmann J, Lindken R (2011) Analysis of tracer particle characteristics for μPIV in wall-bounded gas flows. La Houille Blanche 4:55–61

    Article  Google Scholar 

  • Burgmann S, Blank M, Wartmann J, Heinzel A (2012) Investigation of the effect of CO2-bubbles and slugs on the performance of a DMFC by means of laser-optical flow measurements. Energy Procedia 28:88–101

    Article  Google Scholar 

  • Feser JP, Prasad AK, Advani SG (2007) Particle image velocimetry measurements in a model proton exchange membrane fuel cell. J Fuel Cell Sci Technol 4:328–335

    Article  Google Scholar 

  • Kjeang E, Djilali N, Sinton D (2009) Microfluidic fuel cells: a review. J Power Sources 186:353–369

    Article  Google Scholar 

  • Klinner J, Willert C, Schneider A, Mack-Gardner A (2011) Messung der Strömungsverteilung am Austritt der Bipolarplatten eines Brennstoffzellen-Stacks. tm-Technisches Messen 78 (5):246–252

  • Lebaek J, Andreasen MB, Andresen HA, Bang M, Kaer SK (2010) Particle image velocimetry and computational fluid dynamics analysis of fuel cell manifold. J Fuel Cell Sci Technol 7:0310011–03100110

    Google Scholar 

  • Li X, Sabir I (2005) Review of bipolar plates in PEM fuel cells: flow-field designs. Int J Hydrogen Energy 30:359–371

    Article  Google Scholar 

  • Li H, Tang Y, Wang Z, Shi Z, Wu S, Song D, Zhang J, Fatih K, Zhang J, Wang H, Liu Z, Abouatallah R, Mazza A (2008) A review of water flooding issues in the proton exchange membrane fuel cell. J Power Sources 178:103–117

    Article  Google Scholar 

  • Liao Q, Zhu X, Zheng X, Ding Y (2007) Visualization study on the dynamics of CO2 bubbles in anode channels and performance of a DMFC. J Power Sources 171:644–665

    Article  Google Scholar 

  • Lindken R, Burgmann S (2012) Laser-optical methods for transport studies in low temperature fuel cells. In: Hartnig C, Roth C (eds) Polymer electrolyte membrane and direct methanol fuel cell technology, vol 2: in situ characterization techniques for low temperature fuel cells. Woodhead Publishing Limited, Sawston, pp 425–461

    Chapter  Google Scholar 

  • Lindken R, Rossi M, Grosse S, Westerweel J (2009) Micro particle image velocimetry (μPIV): recent developments, applications, and guidelines. Lab Chip 9:2551–2567

    Article  Google Scholar 

  • Lu G, Wang C (2004) Electrochemical and flow characterization of a direct methanol fuel cell. J Power Sources 134:33–40

    Article  Google Scholar 

  • Martin J, Oshkai P, Djilali N (2005) Flow structures in a U-shaped fuel cell flow channel: quantitative visualization using PIV. J Fuel Cell Sci Technol 2:70–80

    Article  Google Scholar 

  • Meinhart CD, Wereley ST, Santiago JG (2000) A PIV algorithm for estimating time-averaged velocity fields. J Fluids Eng Trans ASME 122:285–289

    Article  Google Scholar 

  • Minor G, Zhu X, Oshkai P, Sui P, Djilali N (2008) Water transport dynamics in fuel cell micro-channels. In: Kakac S, Pramuanjaroenkij A, Vasiliev L (eds) Mini-micro fuel cells: fundamentals and applications. Springer, Berlin, pp 153–170

    Chapter  Google Scholar 

  • Olsen M, Adrian R (2000) Out-of-focus effects on particle image visibility and correlation in microscopic particle-image velocimetry. Exp Fluids 29(1, Suppl):166–174

    Article  Google Scholar 

  • Sugii Y, Okamoto K (2006) Velocity measurement of gas flow using micro PIV technique in polymer electrolyte fuel cell. Proceedings of ICNMM2006 4th international conference on nanochannels, microchannels and minichannels, Limerick, Ireland

  • Tatsumi K, Nishitani K, Fukuda K, Katsumoto Y, Nakabe K (2010) Measurement of electroosmotic flow velocity and electric field in microchannels by micro particle image velocimetry. Meas Sci Technol 21, 105402, p 11

    Google Scholar 

  • van der Schoot N, Lindken R, Sharp KV, Peil S, Wartmann J, Westerweel J (2008) PIV-Messungen zur Untersuchung in Brennstoffzellen. Proceedings of “Lasermethoden in der Strömungsmesstechnik”, Karlsruhe, Germany

  • Wang C (2004) Fundamental models for fuel cell engineering. Chem Rev 104:4727–4766

    Article  Google Scholar 

  • Wereley ST, Meinhart CD (2009) Recent advances in micro particle image velocimetry. Annu Rev Fluid Mech 42:557–576

    Article  Google Scholar 

  • Yang H, Zhao T, Ye Q (2005) In situ visualization study of CO2 gas bubble behavior in DMFC anode flow fields. J Power Sources 139:79–90

    Article  Google Scholar 

  • Yoon S, Ross J, Mench M, Sharp KV (2006) Gas-phase particle image velocimetry (PIV) for application to the design of fuel cell reactant flow channels. J Power Sources 160:1017–1025

    Article  Google Scholar 

Download references

Acknowledgments

This work is part of the research projects IGF 16338 N/1 (12-01-2009 to 04-30-2012) and IGF 407 ZBG (01-01-2012 to 06-30-2014), funded by the Confederation of Industrial Research Associations (AiF) within the support program “Industrial Joint Research (IGF)” of the Federal Ministry of Economics and Technology.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Sebastian Burgmann.

Additional information

This article is part of the Topical Collection on Application of Laser Techniques to Fluid Mechanics 2012.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Burgmann, S., Blank, M., Panchenko, O. et al. μPIV measurements of two-phase flows of an operated direct methanol fuel cell. Exp Fluids 54, 1513 (2013). https://doi.org/10.1007/s00348-013-1513-7

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1007/s00348-013-1513-7

Keywords

Navigation