Abstract
The high energy input required for harvesting microalgae means that commercial production of microalgal biodiesel is economically unfeasible. In this study, we investigated the flocculation efficiency and synergistic mechanisms of novel coupled flocculants, AlCl3 and compound bioflocculants (CBF), to overcome this difficulty. AlCl3 flocculation was found to be very sensitive to pH, and flocculation efficiency increased from 55 to 95 % when pH increased from 4 to 10. CBF was environmental friendly, less reliant on pH, but had a relatively low flocculation of 75 % in optimum conditions. The harvesting efficiency of Chlorella regularis can achieve a satisfactory level of 96.77 % even in neutral conditions, with a CBF dosage of 0.26 g/L, AlCl3 dosage of 0.18 g/L, and coagulant aid (CaCl2) dosage of 0.12 g/L. Interestingly, compared with the use of single flocculant, the dosage of CBF, AlCl3, and coagulant aid (CaCl2) were reduced by about 52, 49, and 66 %, respectively. Besides, the aluminum (Al) ion content of the supernatant decreased significantly to a residue of only 0.03 mg/L, therefore meeting the downstream process needs easily. Patching and bridging played key roles in coupled flocculant flocculation, in which AlCl3 mainly carried out the electrical neutralization. This work provides new insight into an efficient, economical, and environmentally friendly protocol for microalgae harvesting.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
APHA Wef. Standard methods for the examination of water and wastewater. 1998. Washington DC: American Public Health Association, American Water Work Association, Water Environment Federation
Barros AI, Gonçalves AL, Simões M, Pires JC (2015) Harvesting techniques applied to microalgae: a review. Renew Sust Energ Rev 41:1489–1500. doi:10.1016/j.rser.2014.09.037
Chen CY, Yeh KL, Aisyah R, Lee DJ, Chang JS (2011) Cultivation, photobioreactor design and harvesting of microalgae for biodiesel production: a critical review. Bioresour Technol 102:71–81. doi:10.1016/j.biortech.2010.06.159
Chisti Y (2007) Biodiesel from microalgae. Biotechnol Adv 25:294–306. doi:10.1016/j.biotechadv.2007.02.001
Danquah MK, Ang L, Uduman N, Moheimani N, Forde GM (2009b) Dewatering of microalgal culture for biodiesel production: exploring polymer flocculation and tangential flow filtration. J Chem Technol Biotechnol 84:1078–1083. doi:10.1002/jctb.2137
Danquah MK, Gladman B, Moheimani N, Forde GM (2009a) Microalgal growth characteristics and subsequent influence on dewatering efficiency. Chem Eng J 151:73–78. doi:10.1016/j.cej.2009.01.047
Drinking Water Standards and Health Advisories. 2004. Environmental Protection Agency Washington, DC. USA
Duan JM, Gregory J (2003) Coagulation by hydrolysing metal salts. Adv Colloid Interf Sci 100:475–502. doi:10.1016/S0001-8686(02)00067-2
de Alva MS, Luna-Pabello VM, Cadena E, Ortíz E (2013) Green microalga Scenedesmus acutus grown on municipal wastewater to couple nutrient removal with lipid accumulation for biodiesel production. Bioresour Technol 146:744–748. doi:10.1016/j.biortech.2013.07.061
Gonçalves AL, Pires JC, Simões M (2013) Green fuel production: processes applied to microalgae. Environ Chem Lett 11:315–324. doi:10.1007/s10311-013-0425-3
Gong WX, Wang SG, Sun XF, Liu XW, Yue QY, Gao BY (2008) Bioflocculant production by culture of Serratia ficaria and its application in wastewater treatment. Bioresour Technol 99:4668–4674. doi:10.1016/j.biortech.2007.09.077
Grima EM, Belarbi EH, Fernández FA, Medina AR, Chisti Y (2003) Recovery of microalgal biomass and metabolites: process options and economics. Biotechnol Adv 20:491–515. doi:10.1016/S0734-9750(02)00050-2
Gudin C, Thepenier C (1986) Bioconversion of solar energy into organic chemicals by microalgae. Adv Biotechnol Process 6:73–110
Lee AK, Lewis DM, Ashman PJ (2010) Energy requirements and economic analysis of a full-scale microbial flocculation system for microalgal harvesting. Chem Eng Res Des 88:988–996. doi:10.1016/j.cherd.2010.01.036
Ma XC, Zheng HL, Addy M, Anderson E, Liu YH, Chen P, Ruan R (2016) Cultivation of Chlorella vulgaris in wastewater with waste glycerol: strategies for improving nutrients removal and enhancing lipid production. Bioresour Technol 207:252–261. doi:10.1016/j.biortech.2016.02.013
Mukherjee S, Pariatamby A, Sahub JN, Guptac BS (2013) Clarification of rubber mill wastewater by a plant based biopolymer-comparison with common inorganic coagulants. J Chem Technol Biotechnol 88:1864–1873. doi:10.1002/jctb.4041
Papazi A, Makridis P, Divanach P (2010) Harvesting Chlorella minutissima using cell coagulants. J Appl Phycol 22:349–355. doi:10.1007/s10811-009-9465-2
Pirwitz K, Rihko-Struckmann L, Sundmacher K (2015) Comparison of flocculation methods for harvesting Dunaliella. Bioresour Technol 196:145–152. doi:10.1016/j.biortech.2015.07.032
Rawat I, Kumar RR, Mutanda T, Bux F (2011) Dual role of microalgae: phycoremediation of domestic wastewater and biomass production for sustainable biofuels production. Appl Energy 88:3411–3424. doi:10.1016/j.apenergy.2010.11.025
Rwehumbiza VM, Harrison R, Thomsen L (2012) Alum-induced flocculation of preconcentrated Nannochloropsis salina: residual aluminium in the biomass, FAMEs and its effects on microalgae growth upon media recycling. Chem Eng J 200–202:168–175. doi:10.1016/j.cej.2012.06.008
Şirin S, Trobajo R, Ibanez C, Salvadó J (2012) Harvesting the microalgae Phaeodactylum tricornutum with polyaluminum chloride, aluminium sulphate, chitosan and alkalinity-induced flocculation. J Appl Phycol 24:1067–1080. doi:10.1007/s10811-011-9736-6
Uduman N, Qi Y, Danquah MK, Forde GM, Hoadley A (2010) Dewatering of microalgal cultures: a major bottleneck to algae-based fuels. J Renew Sustain Ener 2:012701. doi:10.1063/1.3294480
Vandamme D, Foubert I, Fraeye I, Meesschaert B, Muylaert K (2012) Flocculation of Chlorella vulgaris induced by high pH: role of magnesium and calcium and practical implications. Bioresour Technol 105:114–119. doi:10.1016/j.biortech.2011.11.105
Vandamme D, Foubert I, Meesschaert B, Muylaert K (2010) Flocculation of microalgae using cationic starch. J Appl Phycol 22:525–530. doi:10.1007/s10811-009-9488-8
Vandamme D, Foubert I, Muylaert K (2013) Flocculation as a low-cost method for harvesting microalgae for bulk biomass production. Trends Biotechnol 31:233–239. doi:10.1016/j.tibtech.2012.12.005
Wang H, Hill RT, Zheng TL, Hu X, Wang B (2016) Effects of bacterial communities on biofuel-producing microalgae: stimulation, inhibition and harvesting. Crit Rev Biotechnol 36:341–352. doi:10.3109/07388551.2014.961402
Wang LL, Ma F, Qu Y, Sun D, Li A, Guo J, Yu B (2011) Characterization of a compound bioflocculant produced by mixed culture of Rhizobium radiobacter F2 and Bacillus sphaeicus F6. World J Microbiol Biotechnol 27:2559–2565. doi:10.1007/s11274-011-0726-2
Wang Y, Yang Y, Ma F, Xuan L, Xu Y, Huo H, Dong S (2015) Optimization of Chlorella vulgaris and bioflocculant-producing bacteria co-culture: enhancing microalgae harvesting and lipid content. Lett Appl Microbiol 60:497–503. doi:10.1111/lam.12403
Woo SG, Yoo K, Lee J, Bang S, Lee M, On K, Park J (2012) Comparison of fatty acid analysis methods for assessing biorefinery applicability of wastewater cultivated microalgae. Talanta 97:103–110. doi:10.1016/j.talanta.2012.04.002
Xu H, Liu Y (2008) Mechanisms of Cd2+, Cu2+ and Ni2+ biosorption by aerobic granules. Sep Purif Technol 58:400–411. doi:10.1016/j.seppur.2007.05.018
Yang F, Li X, Li Y, Wei H, Yu G, Yin L, Pu Y (2013) Lysing activity of an indigenous algicidal bacterium Aeromonas sp. against Microcystis spp. isolated from Lake Taihu. Environ Technol 34:1421–1427. doi:10.1080/09593330.2012.752872
Zheng H, Gao Z, Yin J, Tang X, Ji X, Huang H (2012) Harvesting of microalgae by flocculation with poly (γ-glutamic acid). Bioresour Technol 112:212–220. doi:10.1016/j.biortech.2012.02.086
Acknowledgments
The authors are grateful for the financial support from the National Natural Science Foundation of China (NSFC NO. 51578117), the Development Plan Project of Science and Technology of Jilin Province (20140101006JC) and the Fundamental Research Funds for the Central Universities (2412016KJ011). Moreover, we appreciate the Rhizobium radiobacter (F2) and Bacillus sphaeicus (F6) strain supplied by the Heilongjiang Environmental Biotechnology Key Laboratory of China.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Funding
This study was funded by the National Natural Science Foundation of China (No. 51,578,117), the Development Plan Project of Science and Technology of Jilin Province (20140101006JC) and the Fundamental Research Funds for the Central Universities (2412016KJ011).
Conflict of interest
The authors declare that they have no competing interests.
Ethical approval
This article does not contain any studies with human participants or animals performed by any of the authors.
Informed consent
Informed consent was obtained from all individual participants included in the study.
Rights and permissions
About this article
Cite this article
Zhang, C., Wang, X., Wang, Y. et al. Synergistic effect and mechanisms of compound bioflocculant and AlCl3 salts on enhancing Chlorella regularis harvesting. Appl Microbiol Biotechnol 100, 5653–5660 (2016). https://doi.org/10.1007/s00253-016-7543-3
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00253-016-7543-3