Abstract
The diffusion of water into spruce wood coated with an acrylate/polyurethane and with a silica-based coating system is investigated by varying the humidity conditions. Thereby, the change of moisture content (MC) is measured and analysed with the non-destructive method of neutron imaging. For the acrylate/polyurethane based coating system, the barrier effect of the coating on wood sorption in direct water contact and the influence of surface defects on this barrier effect are also tested. On changing the humidity conditions, the specimens with silica-based coating initially show a clear deceleration of the sorption process, whereas after 10 days the MC gradient is nearly similar to the uncoated reference specimens. In contrast, the specimens with acrylate/polyurethane based coating show a strong barrier effect against water sorption into wood over the whole measurement period when changing the humidity conditions and in direct water contact. As can be expected, a defect in the coating strongly reduces its barrier effect. Thereby, the kind of defect (saw kerf or blade cut) is rather irrelevant.
Similar content being viewed by others
References
De Meijer M, Militz H (2000) Moisture transport in coated wood. Part 1: analysis of sorption rates and moisture content profiles in spruce during liquid water uptake. Holz Roh- Werkst 58(5):354–362
Grüll G, Tscherne F, Spitaler I, Forsthuber B (2014) Comparison of wood coating durability in natural weathering and artificial weathering using fluorescent UV-lamps and water. Eur J Wood Prod 72(3):367–376
Hassanein RK (2006) Correction methods for the quantitative evaluation of thermal neutron tomography. Dissertation, ETH Zurich
ISO 12572 (2001) Hygrothermal performance of building materials and products—Determination of water vapour transmission properties. International Organization for Standardization, Geneva
ISO 15148 (2002) Hygrothermal performance of building materials and products—Determination of water absorption coefficient by partial immersion. International Organization for Standardization, Geneva
Klopfer H (1974) Wassertransport durch Diffusion in Feststoffen. (Water transport through diffusion in solids) Bauverlag, Wiesbaden/Berlin (in German)
Lanvermann C, Sanabria SJ, Mannes D, Niemz P (2014) Combination of neutron imaging (NI) and digital image correlation (DIC) to determine intra-ring moisture variation in Norway spruce. Holzforschung 68(1):113–122
Lehmann E, Vontobel P, Scherrer P, Niemz P (2001) Application of neutron radiography as method in the analysis of wood. Holz Roh- Werkst 59(6):463–471 (in German)
Mannes D, Josic L, Lehmann E, Niemz P (2009) Neutron attenuation coefficients for non-invasive quantification of wood properties. Holzforschung 63(4):472–478
Niemz P, Mannes D, Koch W, Herbers Y (2010) Investigations into the water absorption coefficients of timber with variations in timber and moisture type. Bauphysik 32(3):149–153 (in German)
Pourmand P, Wang L, Dvinskikh SV (2011) Assessment of moisture protective properties of wood coatings by a portable NMR sensor. J Coat Technol Res 8(5):649–654
Schindelin J, Arganda-Carreras I, Frise E, Kaynig V, Longair M, Pietzsch T, Preibisch S, Rueden C, Saalfeld S, Schmid B, Tinevez J-Y, White DJ, Hartenstein V, Eliceiri K, Tomancak P, Cardona A (2012) Fiji: an open-source platform for biological-image analysis. Nat Methods 9(7):676–682
Sedighi-Gilani M, Griffa M, Mannes D, Lehmann E, Carmeliet J, Derome D (2012) Visualization and quantification of liquid water transport in softwood by means of neutron radiography. Int J Heat Mass Tran 55(21–22):6211–6221
Siau JF (1995) Wood: Influence of moisture on physical properties. Virginia Polytechnic Institute and State University, USA
Sivertsen MS, Flaete PO (2012) Water absorption in coated Norway spruce (Picea abies) cladding boards. Eur J Wood Prod 70(1–3):307–317
Sonderegger W (2011) Experimental and theoretical investigations on the heat and water transport in wood and wood-based materials. Dissertation, ETH Zurich
Sonderegger W, Hering S, Mannes D, Vontobel P, Lehmann E, Niemz P (2010) Quantitative determination of bound water diffusion in multilayer boards by means of neutron imaging. Eur J Wood Prod 68(3):341–350
Sonderegger W, Vecellio M, Zwicker P, Niemz P (2011) Combined bound water and water vapour diffusion of Norway spruce and European beech in and between the principal anatomical directions. Holzforschung 65(6):819–828
Sonderegger W, Mannes D, Kaestner A, Hovind J, Lehmann E (2015) On-line monitoring of hygroscopicity and dimensional changes of wood during thermal modification by means of neutron imaging methods. Holzforschung 69(1):87–95
Thévenaz P, Ruttimann UE, Unser M (1998) A pyramid approach to subpixel registration based on intensity. IEEE T Image Process 7(1):27–41
Van Meel PA, Erich SJF, Huinink HP, Kopinga K, de Jong J, Adan OCG (2011) Moisture transport in coated wood. Prog Org Coat 72(4):686–694
Zwicker P (2008) Untersuchungen zum Diffusionsverhalten von Holz und Holzwerkstoffen. (Investigations into the diffusion behavior of wood and wood based products) Bachelor thesis, Institute for Building Materials (Wood Physics), ETH Zurich (in German)
Acknowledgments
Thanks go to the Swiss Federal Office for the Environment (Fonds zur Förderung der Wald- und Holzforschung) for financial support.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Sonderegger, W., Glaunsinger, M., Mannes, D. et al. Investigations into the influence of two different wood coatings on water diffusion determined by means of neutron imaging. Eur. J. Wood Prod. 73, 793–799 (2015). https://doi.org/10.1007/s00107-015-0951-8
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00107-015-0951-8