Abstract
An industrially degummed Indonesian palm oil was bleached and steam refined in a pilot plant to study the effect of processing on oil color and on the levels of carotenoids and tocopherols. Five concentrations of one natural and two activated clays mixed with a fixed amount of synthetic silica were used for bleaching. For color measurement, the Lovibond method was compared to the CIE (Commission Internationale de l’Eclairage) L*,a*,b* method. The results showed that the L*,a*,b* method is repeatable and that the values found are highly correlated with the carotenoid content of bleached oil samples. The various clays and synthetic silica mixes removed 20–50% of the carotenoids in the degummed oil, depending on clay concentration and activity. For the two activated clays, pigment adsorption increased with clay amount. Steam refining totally destroyed carotenoids in the claytreated oils by heat bleaching. Total tocopherols in the crude oil amounted to 1000 mg/kg, with γ-tocotrienol as the main tocopherolic component followed by α-tocopherol, α-tocotrienol, and δ-tocotrienol. Tocopherol concentrations increased after the bleaching treatment with the most acid clay, and the increase was proportional to the amount of clay used. Both bleaching and steam refining changed the ratios between the various to copherolic components, especially increasing the relative concentration of α-tocotrienol in the refined oil. An average 80% tocopherol retention was obtained after the treatment with acid clay + synthetic silica and steam refining of palm oil.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Goh, S.H., Y.M. Choo, and S.H. Ong, Minor Constituents of Palm Oil, J. Am. Oil. Chem. Soc. 62:237–240 (1985).
Landvick, S.V., A.T. Diplock, and L. Packer, Efficacy of Vitamin E in Human Health and Disease, in Handbook of Antioxidants, edited by E. Cadenas and L. Packer, Marcel Dekker, New York, 1996, pp. 63–87.
Basiron, Y., Palm Oil, in Bailey’s Industrial Oil and Fat Products, edited by Y.H. Hui, John Wiley & Sons, New York, 1996, Vol. 2, pp. 271–375.
Stage, H., The Physical Refining Process, J. Am. Oil Chem. Soc. 62:299–308 (1985).
De Greyt, W., Improved Deodorization Technology for the Production of High Quality Food Oils, presented at 2000 National Seminar on Palm Oil Milling, Refining Technology, Quality and Environment, Genting Highlands, Pahang, Malaysia, July 3–4, 2000.
Sing, C.C., A Revised Long-Term Forecast on World Palm Oil Production and Consumption, Palm Oil Developments 30:45–48 (1999).
Nagendran, B., U.R. Unnithan, and Y.M. Choo, Red Palm Oil—A Carotene and Vitamine E-Rich Refined Oil for Food Uses, presented at the 23rd World Congress and Exhibition of the International Society for Fat Research (ISF), Brighton, England, October 3–7, 1999.
Hodgson, A.S., Refining and Bleaching, in Bailey’s Industrial Oil & Fat Products, edited by Y.H. Hui, John Wiley & Sons, New York, 1996, Vol. 4, pp. 157–212.
Gianazza, M., Raffinazione Fisica dell’Olio di Palma: Messa a Punto di un Impianto Pilota e Studio della Fase di Decolorazione, Marter’s Degree Thesis, University of Milan, Italy, 1996.
Dionisi, F., J. Prodolliet, and E. Tagliaferri, Assessment of Olive Oil Adulteration by Reversed-Phase High-Performance Liquid Chromatography/Amperometric Detection of Tocopherols and Tocotrienols, J. Am. Oil Chem. Soc. 72:1505–1511 (1995).
Feng, H., C.C. Akoh, and R.R. Eitenmiller, The Antioxidant Activity of Less Than Alpha Greater Than-, Less Than Gamma Greater Than- Tocopherols and Less Than Alpha Greater than-, Less Than Gamma Greater than- Tocotrienols in Selected Oils, in Institute of Food Technologists Annual Meeting [Abstract], 1996, p. 122.
Kamat, J.P., H.D. Sarma, T.P.A. Devasagayam, K. Nesaretnam, and Y. Basiron, Tocotrienols from Palm Oil as Effective Inhibitors of Protein Oxidation and Lipid Peroxidation in Rat Liver Microsomes, Mol. Cell Biolchem. 170:131–138 (1997).
Gapor, A.B., M.D. Top, K.G. Berger, T. Hashimoto, A. Kato, K. Tanabe, H. Mamuro, and M. Yamaoka, Effects of Processing on the Content and Composition of Tocopherols and Tocotrienols in Palm Oil, in Palm Oil Product Technology in the Eighties, edited by E. Peshparajah and M. Rajadurai, I.S.P., Kuala Lumpur, 1983, pp. 145–156.
De Greyt, W., and M. Kellens, Refining Practice, in Edible Oil Processing, edited by W. Hamm, and R.J. Hamilton, Sheffield Academic Press, Sheffield, United Kingdom, 2000, pp. 79–128.
Author information
Authors and Affiliations
Corresponding author
About this article
Cite this article
Rossi, M., Gianazza, M., Alamprese, C. et al. The effect of bleaching and physical refining on color and minor components of palm oil. J Amer Oil Chem Soc 78, 1051–1055 (2001). https://doi.org/10.1007/s11746-001-0387-8
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s11746-001-0387-8