Skip to main content
Log in

Thermal and physical properties of reconsolidated crushed rock salt as a function of porosity and temperature

  • Research Paper
  • Published:
Acta Geotechnica Aims and scope Submit manuscript

Abstract

Crushed salt can be used as backfill to bury and conduct heat away from radioactive waste in salt repositories. As the crushed salt compacts during reconsolidation, its thermal, mechanical and hydrologic properties will change in a manner related to the porosity. Measurements of crushed salt thermal properties are conducted to evaluate such relationships. A simple mixture theory model is presented to predict thermal conductivity of consolidating salt in repository conditions. Experimental work was completed to evaluate the model by measuring thermal conductivity, thermal diffusivity and specific heat of crushed salt as a function of porosity and temperature. Sample porosity ranged from 0 to 46 %, and measurements were made at ambient pressure, from room temperature to 300 °C. These are the temperature conditions expected in a radioactive waste storage facility. Crushed salt thermal conductivity decreases with increasing porosity and temperature. Thermal diffusivity showed little porosity dependence but decreased with increasing temperature. Specific heat also shows little porosity dependence but increases with increasing temperature. Fracture porosity in deformed bedded salt cores appears to reduce thermal conductivity more dramatically than inter- and intra-granular porosity in consolidated salt. A long-term effort to dry crushed salt at high temperatures resulted in a 0.48 weight-percent loss of water that had resided at grain boundaries and in intra-granular fluid inclusions. While this loss does not significantly affect thermal properties, the release of this water volume could impact the mechanical response of the reconsolidating salt and host rock.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12
Fig. 13
Fig. 14
Fig. 15
Fig. 16
Fig. 17

Similar content being viewed by others

References

  1. Acton U (1977) Thermal conductivity of SE New Mexico rocksalt and anhydrite. In: Proceedings of the international conference on thermal conductivity, 15th, Ottawa, 1977, SAND-77-0962

  2. Aubertin M, Hardy HR (1996) The mechanical behavior of salt. In: Proceedings of the fourth conference. Montreal Canada. Trans Tech Publications. ISBN 0-87849-103-1

  3. Bechthold W, Rothfuchs T, Poley A, Ghoreychi M, Heusermann S, Gens A, Olivella S (1999) Backfilling and sealing of underground repositories for radioactive waste in salt (Bambus Project): Final Report. EUR 19124 EN. European Commission, Brussels

  4. Bechthold W, Smailos E, Heusermann S, Bollingerfehr W, Bazargan Sabet B, Rothfuchs T, Kamlot P, Grupa J, Olivella S, Hansen F (2004) Backfilling and sealing of underground repositories for radioactive waste in salt (Bambus II Project): Final Report. EUR 20621 EN. European Commission, Luxembourg

  5. Birch F, Clark H (1940) The thermal conductivity of rocks and its dependence upon temperature and composition: part 1. Am J Sci 238:529–558

    Article  Google Scholar 

  6. Birch F, Clark H (1940) The thermal conductivity of rocks and its dependence upon temperature and composition: part 2. Am J Sci 238:613–635

    Article  Google Scholar 

  7. Brodsky N, Zeuch D, Holcomb D (1995) Consolidation and permeability of crushed WIPP salt in hydrostatic and triaxial compression. In: Proceedings of the 35th U.S. symposium on rock mechanics, pp 497–502

  8. Broome ST, Bauer SJ, and Hansen FD (2014) Reconsolidation of crushed salt to 250 °C under hydrostatic and shear stress conditions. In: 48th US rock mechanics/geomechanics symposium

  9. Durham WB, Abey AE (1981) Effects of pressure and temperature on the thermal properties of a salt and a quartz monzonite. UCRL-85285. Lawrence Livermore National Laboratory, Livermore, CA

    Google Scholar 

  10. Durham WB, Abey AE, Trimmer DA (1981) Thermal properties of Avery Island rock salt to 573 K and 50 MPa confining pressure. UCRL-53128. Lawrence Livermore National Laboratory, Livermore, CA

    Book  Google Scholar 

  11. Durham WB, Abey AE, Trimmer DA (1983) Thermal conductivity, diffusivity and expansion of Avery Island salt at pressure and temperature. In: Larsen DC (ed) Thermal conductivity 16. Plenum Publishing Corp., New York

    Book  Google Scholar 

  12. Durham WB, Boro CO, Beiriger JM, Montan DN (1983) Thermal conductivity of Permian Basin bedded salt at elevated pressure and temperature. UCRL-53476. Lawrence Livermore National Laboratory, Livermore, CA

    Book  Google Scholar 

  13. Durham WB, Boro CO, Beiriger JM (1984) Thermal conductivity of Permian Basin bedded salt at elevated pressure UCRL-90725, CONF-8310163-11. Lawrence Livermore National Laboratory, Livermore, CA

    Google Scholar 

  14. Hansen F, Callahan G, van Sambeek L (1993) Reconsolidation of salt as applied to permanent seals for the Waste Isolation Pilot Plant. In: Proceedings of the 3rd conference on the mechanical behavior of salt, Transtech Publications, Palaiseau, France, pp 323–335

  15. Hansen F, Ahrens E, Tidwell V, Tillerson J, Brodsky N (1995) Dynamic compaction of salt: initial demonstration and performance testing. In: Daemen J, Schultz R (eds) Proceedings of the 35th U.S. symposium on rock mechanics, Brookfield, VT, pp 755–760

  16. Ingebritsen S, Sanford W, Neuzil C (2006) Groundwater in geologic processes, 2nd edn. Cambridge University Press, Cambridge

    Google Scholar 

  17. Kannuluik WG, Carman EH (1951) The temperature dependence of the thermal conductivity of air. Aust J Sci Res Ser A Phys Sci 4:305

    Google Scholar 

  18. Liu S, Feng C, Wang L, Cheng L (2011) Measurement and analysis of thermal conductivity of rocks in the Tarim Basin, Northwest China. Acta Geol Sin 85:598–609

    Article  Google Scholar 

  19. Mellegard K, Callahan G, Hansen F (2013) High-temperature characterization of bedded Permian salt. In: 47th US rock mechanics/geomechanics symposium

  20. Morgan MT (1979) Thermal conductivity of rock salt from Louisiana salt domes ORNL/TM-6809. Oak Ridge National Laboratory, Oak Ridge, TN

    Book  Google Scholar 

  21. Brodsky N (1994) Hydrostatic and shear consolidation tests with permeability measurements on Waste Isolation Pilot Plant crushed salt, SAND93-7058. Sandia National Laboratories, Albuquerque, NM

    Book  Google Scholar 

  22. Robertson E (1988) Thermal properties of rocks. Report 88-441. US Geological Survey, Reston, VA

  23. Roedder E, Bassett RL (1981) Problems in determination of the water content of rock-salt samples and its significance in nuclear-waste storage siting. Geology 9:525–530

    Article  Google Scholar 

  24. Sass JH, Lachenbruch AH, Munroe RJ (1971) Thermal conductivity of rocks from measurements on fragments and its application to heat-flow determinations. J Geophys Res 76:3391–3401

    Article  Google Scholar 

  25. Smith DD (1976) Thermal conductivity of halite using a pulsed laser, Oak Ridge Y-12 Plant. Y/DA-7013

  26. Stein C (1985) Mineralogy in the Waste Isolation Pilot Plant (WIPP) facility stratigraphic horizon SAND85–0321. Sandia National Laboratories, Albuquerque, NM

    Book  Google Scholar 

  27. Sweet JN, McCreight JE (1979) Thermal conductivity of rocksalt and other geologic materials from the site of the proposed waste isolation pilot plant. SAND79-1134, SAND79-1134. Sandia National Laboratories, Albuquerque, NM

    Google Scholar 

  28. Urquhart A, Bauer S (2015) Experimental determination of single-crystal halite thermal conductivity, diffusivity and specific heat from −75 °C to 300°C. Int J Rock Mech Min Sci. doi:10.1016/j.ijrmms.2015.04.007

    Google Scholar 

  29. van den Broek WMGT (1982) Impurities in rock-salt: consequences for the temperature increases at the disposal of high-level nuclear waste. PB-83-102087. Technische Hogeschool Delft, Netherlands

  30. Wallner M, Lux K-H, Minkley W, Hardy HR (2007) The mechanical behavior of salt. In: Proceeding of the sixth conference, Hannover, Germany. Balkema. ISBN 13: 978-415-444398-2

Download references

Acknowledgments

This work was completed in the Geomechanics Laboratory at Sandia National Laboratories. Sandia National Laboratories is a multiprogram laboratory managed and operated by Sandia Corporation, a wholly owned subsidiary of Lockheed Martin Corporation, for the U.S. Department of Energy’s National Nuclear Security Administration under contract DE-AC04-94AL85000.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Stephen Bauer.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Bauer, S., Urquhart, A. Thermal and physical properties of reconsolidated crushed rock salt as a function of porosity and temperature. Acta Geotech. 11, 913–924 (2016). https://doi.org/10.1007/s11440-015-0414-8

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11440-015-0414-8

Keywords

Navigation